2005 FORD FIVE HUNDRED Complaints

I HAVE RESEARCHED ONLINE AND A LOT OF PEOPLE WITH MY SAME CAR ARE HAVING THE SAME PROBLEM. WHILE DRIVING MY WHOLE DASH BOARD GOES OUT . I CAN NO LONGER SEE HOW FAST I'M GOING. EVERYTHING GOES TO 0 THE GAS GOES TO E AND MY REVERSE LIGHTS STAY ON UNTIL THE DASH BOARD COMES BACK UP. IF AND WHEN IT COMES BACK ON MY CHECK ENGINE LIGHT WILL BE ON. THIS HAS BEEN HAPPENING EVERY SINCE I PURCHASED THE CAR 3YEARS AGO ON AND OFF.

DURING ANY WET WEATHER, WATER INTRUDES INTO MY DOORS AND BECOMES TRAPPED. WHEN OPENING THE DOORS, THE WATER GUSHES OUT AND YOU CAN HEAR WATER SLOSHING AROUND INSIDE. THERE HAS ALSO BEEN LEAKAGE FROM THE FRONT AND REAR PASSENGER DOORS OF WATER INTO THE INTERIOR OF MY VEHICLE FROM THE BOTTOM OF THE DOORS BEING FILLED WITH WATER. DURING THE COLD WEATHER, THIS WATER THEN FREEZES MY LOCKING MECHANISMS WHEN OPENING AND CLOSING THE DOORS. THERE IS A RECALL FOR THIS EXACT ISSUE WITH MY MODEL, BUT ACCORDING TO FORD MY VIN IS NOT INCLUDED EVEN THOUGH THE ISSUE ALSO AFFECTS MY CAR. THERE HAVE BEEN TIMES WHEN MY DOOR WITH "LOCK" BUT IT IS NOT COMPLETELY CLOSED AND HAS OPENED WHILE MOVING. FORDS ONLY RESOLUTION FOR ME HAS BEEN TO FIX THE ISSUE AT MY COST, AND THEY WILL REIMBURSE ME "IF" MY CAR WOULD BE INCLUDED IN THE RECALL. THE CAR HAS BEEN DOING THIS SINCE I FIRST BOUGHT IT USED AND THERE HAS BEEN NO RESOLUTION OTHERWISE BY FORD.

BOUGHT THE VEHICLE USED IN MAY 2010. REALIZED EARLY-ON THAT THE TRANSMISSION WAS NOT SMOOTH, BUT WILLING TO SETTLE FOR LESS THAN PERFECTION SINCE IT WAS A 2005 VEHICLE. IN LATE 2012 OR EARLY 2013, I RECEIVED 'RECALL' NOTICE THAT PCM (I.E. - POWERTRAIN CONTROL MODULE) COULD NEED TO BE REPROGRAMMED DUE TO STALLING, HERKY-JERKY TRANSMISSION, ETC. TOOK CAR TO DEALERSHIP, THEY RAN DIAGNOSTICS, CHARGED ME $100, AND TOLD ME THAT MY CAR WASN'T EFFECTED BECAUSE NO ERROR CODES WERE NOTED AND CHECK ENGINE LIGHT WASN'T ON. I WAS NOT HAPPY, AND REFUSED TO TAKE MY CAR TO THE DEALERSHIP FOR REPAIR. PROBLEM PERSISTED, UNTIL CHECK ENGINE LIGHT CAME ON IN OCTOBER 2017 AT ROUGHLY 125,000 MILES. TOOK TO LOCAL MECHANIC, WAS CHARGED $150 FOR SENSOR REPLACEMENT. LIGHT CAME BACK ON A DAY LATER. TOOK BACK, REPLACED SENSOR FOR FREE (NICE!), BUT LIGHT BACK ON A DAY LATER. TOOK TO A DIFFERENT MECHANIC, WAS CHARGED $250, REPLACED MULTIPLE SENSORS, LIGHT BACK ON THE NEXT DAY. TOOK BACK TO 2ND MECHANIC, WHEN THEY SHARED WITH ME THAT IT WAS LIKELY THE PCM AND THE DEALERSHIP WOULD NEED TO FIX. CALLED DEALERSHIP 3 DAYS IN A ROW, ON HOLD FOR NEARLY AN HOUR THE 3RD TIME, WAS NEVER CONNECTED TO A SERVICE WRITER OR TECH, LEFT 3 VOICE MAILS FOR SERVICE MANAGER AND WAS NEVER CALLED BACK. RESEARCHED ISSUE AND FOUND NHTSA ACTION NUMBER PE11018, WHERE FORD INITIATED A CUSTOMER SATISFACTION PROGRAM 12N03 TO EXTEND COVERAGE TERMS OF REPAIR OF ENGINE IDLE RPM SURGE CAUSED BY PCM NEEDING REPROGRAMMING WITH SOFTWARE CONTAINING UPDATED IDLE SPEED CONTROL. PER NHTSA, SYMPTOMS ASSOCIATED WITH THE CONDITION MAY INCLUDE CHECK ENGINE LIGHT, DIAGNOSTIC CODES (DTCS) P0505, P0506, OR P061B. FORD ISSUED BULLETIN TSB 11-10-21 THAT INCLUDED UPDATED POWERTRAIN CONTROL CALIBRATION.

WHEN I TEST DROVE THIS VEHICLE THE RPM FLUCTUATED AND JERKING AS IF IT WAS A MANUAL OPPOSED TO AUTOMATIC AS INCREASING SPEEDS. THERE WAS A RECALL LETTER MAILED TO ME A FEW YEARS LATER AND FORD DEALERSHIP CLAIMED THE ISSUE WAS RESOLVED. WITHIN A FEW DAYS IT BEGAN AGAIN. I HAVE OWNED THIS VEHICLE 10 YEARS WITH THE SAME SAFETY ISSUE AND HAVE HAD TO PULL OVER NUMEROUS TIMES WHEN THE RPMS DONT RESET WHILE ON THE HIGHWAY TO AVOID ACCIDENTS. I AM NOW FILING A FORMAL COMPLAINT BECAUSE I WAS REAR ENDED DUE TO THIS ISSUE BY A PERSON WITH NO INSURANCE. HOW CAN I GET THIS TO GO AWAY BEFORE SOMEONE IS HURT

GEARING INTO REVERSE IS HEAVY SHIFTING TRANSMISSION O2 SENSOR BANK 1 NEED REPLACING

HARSH AND DELAYED SHIFTING. LUNGES FORWARD WHEN IN DRIVE AT STOP EVEN WITH FOOT ON BRAKE, SAME IN REVERSE. CAR SHIFTS FINE FOR FIRST 20-30 MINUTES THEN STARTS TO SHIFT HARD UP AND DOWN... SEEMS TO GET WORSE AS CAR GETS WARMER

AT LOW SPEEDS, WHEN TURNING AND WHEN ACCELERATING FROM A STOP, THE CAR WILL SHAKE, LUNGE AND THEN SHUT OFF. SOMETIMES IT JUST SHAKES AND HESITATES AND THEN KEEPS GOING. SOMETIMES IT TAKES A WHILE TO GET IT RUNNING AGAIN. IT ALWAYS HAPPENS WHEN THE CAR IS IN MOTION. A COUPLE OF TIMES THIS HAPPENED, THE TRANSMISSION ERROR CODES WERE DISPLAYED. I HAVE HAD THE TRANSMISSION CHECKED OUT AND IT WAS FINE.

TRACK BAR BRACKET ON THE EXIT FROM MY DRIVEWAY TO THE ROAD THE CAR STARTED TO DRIVE ERRATICALLY. AFTER STOPPING THE CAR AND INVESTIGATION I FOUND THAT REAR RIGHT TRACK BAR BRACKET IS COMPLETELY DETACHED FROM THE CAR BODY. IT LOOKS LIKE A COMPLETE STRUCTURE FAILURE. FORTUNATELY, THE FAILURE HAPPENED AT VERY LOW SPEED AND NO ONE WAS HARMED. PHOTOS OF THE CAR ARE ENCLOSED.

I TOOK MY BATTERY OUT MY 2005 FORD FIVE HUNDRED AND THE FAIL SAFE ENGINE MODE WRENCH LIGHT CAME ON AND IT WONT GO OFF THIS NEED TO BE RECALL THEY SAY THE COMPTER SHUT DOWN AND I HAVE TO GET IT RESETED I WAS DRIVING THE VEHICLE AND IT ALMOST HIT SOMEONE WHEN IT JURK TO THE FRONT AND I ALMOST HIT A VEHICLE BACKING UP

FRONT DRIVER SIDE LOWER CONTROL ARM BALL JOINT SHEARED OFF AT 25 MPH WHILE MAKING A LEFT HAND TURN AND THEN SNAPPED THE CV JOINT AXLE SHAFT CAUSING THE DRIVER SIDE WHEEL TO JAM INSIDE THE WHEEL WELL AND DAMAGE LOWER PART OF BODY AND FENDER. THE VEHICL WAS TOTALLY DISABLE AT THIS POINT SITTING IN THE MIDDLE OF AN INTERSECTION. SIMILAR INCIDENT HAPPENED TWO YEARS AGO WITH THE PASSENGER SIDE FRONT WHEEL AND THE LOWER CONTROL ARM BALL JOINT SHEARED AND SNAPPED THE CV JOINT AXLE SHAFT AT 45 MPH AND CAUSED VEHICLE TO TURN 180 DEGREES BLOCKING TWO LANES OF HWY. THAT TIME FRONT WHEEL DAMAGED WHEEL WELL AND SENSOR WIRES ON THAT SIDE FO THE ENGINE BAY