2017 FORD FOCUS Complaints

I bought my 2017 Ford Focus SE on [XXX] from Long McArthur Inc. 3450 S 9th St, Salina, KS 67401, 785-823-2237. About a year after buying it, it started to shudder and I was hearing a grinding sound. I was told it had some kind of energy efficient engine and I read it made seem to be stopping. That is what I thought it was. It got progressively worse. On [XXX] the clutch was replaced, 13370 miles. On [XXX] I reported the problem was still happening, 18274 miles. Mechanic notes "Measure clutch shudder got 5205 RPM, below spec for clutch replacement. Power train warranty expires [XXX]. Bring back before it expires and we will check again." I did not take it back in because it didn't seem as bad. But since December of 2023 it has gotten worse. It hesitates when going from a stop to a start. On [XXX] I was pulling into traffic from a stop and it hesitated for about 4-5 sec and then bounced forward and went. I was nearly hit by 2 cars. On [XXX] I called the service department at Long McArthur, the person I talked to said to replace the clutch it would be $2,700.00. He said it will probably go right out. He suggested getting rid of it. This is a know defect by Ford, recall Campaign/NHTSA#18S07/18V169 Issue Date 2018-03-12. I was never notified of this recall. Not from the dealer or Ford. The problems started with the 2015 models. Current miles 24,574. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Ford Focus. The contact stated that while his son was driving 45 MPH, there was an abnormal pop and rattling sound coming from the engine, and the vehicle lost motive power. The check engine and oil warning lights were illuminated. The vehicle was towed to an independent mechanic, who completed a diagnostic test, and retrieved unknown fault codes, and referred the contact to the dealer. The vehicle was towed to the local dealer, where it was diagnosed that the engine oil pump tensioner disintegrated and sent sharp metal fragments through the engine. The vehicle was not repaired. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The contact stated that the failure was related to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The failure mileage was approximately 104,000.

The contact owns a 2017 Ford Focus. The contact stated while driving at an undisclosed speed and attempting to accelerate, the RPM's increased quickly however, the vehicle failed to respond as needed with the vehicle jerking and shuddering. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the clutch throw-out bearing, requiring a replacement of the clutch assembly. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V169000 (Power Train) but the VIN was not included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 62,000.

Engine failed on our 2017 Ford Focus with 1.0 liter Ecoboost engine while driving the vehicle under normal operating conditions on December 14, 2023. Car experienced a dramatic loss of power while driving. Vehicle appeared to not be shifting correctly and would not accelerate. Owner worked to get vehicle to a safe location off the road when "Engine Fault, Service Now" message appeared. Driver pulled off into parking lot ASAP and stopped vehicle. Inspection of vehicle after stopping showed engine fluids had leaked out of engine starting back through parking lot to road. Did not attempt to restart vehicle and had vehicle towed back to repair shop for diagnosis. Initial diagnosis discovery revealed the vacuum pump had failed, along with the turbo charger. Additional follow up inspection revealed after draining fluids pieces of rubber and metal shavings in the drained oil. Rubber pieces appear to be related to timing belt failure. Engine replacement costs of $7100 dollars were incurred on Vehicle was purchased in 2021 with 17,000 miles on it purchase value $15,000. Difficult and very costly situation since the vehicle is needed for school and work with no good alternate vehicles available. Used to advocate for Ford products since purchasing a 2016 Escape. Very disappointed in the quality of the 1.0 liter engine.

I was driving the car home and the oil light started to flash. I stopped and checked the oil level and it was fine. The oil light then stayed on and I started to notice a slight loss in power, then pinging noises coming from the engine. I did not drive the car after this. I called the dealer and the car was towed to Palm Coast Ford. The dealer called back and said the engine was blown, metal in the engine. After research, I found out there is a recall on the car, 23S64. At first the dealer said there was nothing they could do, but now Ford has agreed to give me a rental car until the issue is resolved.

The contact owns a 2017 Ford Focus. The contact stated while driving approximately 45 MPH, the vehicle stalled and the contacted coasted the vehicle to a stop light. No warning light was illuminated. After several attempts, the contact was able to restart the vehicle, and continued driving to the destination. The contact refueled the vehicle and attempted several times to restart the vehicle. The vehicle was taken to the dealer after the check engine warning light illuminated and the contact retrieved DTC code: P1450. The dealer stated that the vehicle was inspected in 2018 under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) without any part being replaced. The VIN was not included in the recall. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.

The contact owns a 2017 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. The oil pressure warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure of the timing belt resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 125,000.

The check engine light came on, then when I started driving it was a little sticky/ rough. I continued to drive it home and the rpm started going up when not needed. I had a code read done and came back as a P07A3, transmission friction element A stuck on.

The contact owns a 2017 Ford Focus. The contact stated that while operating the vehicle, the timing belt and engine oil pump belt fractured, and the vehicle lost oil pressure and the engine failed. The oil pressure, check engine, and battery warning lights illuminated. The vehicle was towed to a local mechanic and was diagnosed with engine failure. The vehicle was repaired. The contact referenced NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) as a possible solution however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The approximate failure mileage was 86,600.

The contact owns a 2017 Ford Focus. The contact stated while operating the vehicle, the message "Transmission Overheating" was displayed, and the vehicle lost motive power. Additionally, the check engine warning light illuminated, and the gear was stuck, and the vehicle failed to properly accelerate. The vehicle was towed to the local mechanic who diagnosed the vehicle and determined that the clutch had fractured. The contact stated the vehicle was taken to the dealer several times, but the failure could not be duplicated. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure. The approximate failure mileage was 98,000.