2012 FORD FUSION Complaints

The contact owns a 2012 Ford Fusion. The contact stated that while driving 40 MPH, the vehicle lost power steering functionality, causing the steering wheel to become very stiff. The contact proceeded to coast the vehicle to a stop and the traction control light illuminated. Additionally, the messages "Service Power Steering Now" and "Advance Track System" were displayed. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact referenced NHTSA Campaign Number: 15V340000 (STEERING); as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 198,000.

The contact owns a 2012 Ford Fusion Hybrid. While the contact’s daughter was operating the vehicle, the steering wheel was very difficult to turn in either direction, with the message "Power Steering Malfunction" displayed. The vehicle was towed to the local dealer who diagnosed that the steering rack was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 68,000.

The contact owns a 2012 Ford Fusion. The contact stated that while driving under 35 MPH, the vehicle was shaking abnormally. The vehicle was shaking abnormally while idling as if the vehicle would shut off. The contact had replaced the battery 8 times; however, the failure persisted. While driving approximately 65 MPH and overtaking other vehicles, the check engine warning light began flashing temporarily. The failure had occurred twice. The vehicle was taken to the dealer who diagnosed the vehicle that the oil was leaking from the valve cover gasket, oil pan, and front seal and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was unknown.

The power steering failed. The Ford dealership technician identified the power steering gear box was faulty. It is currently at Suburban Ford of Sterling Heights (Michigan) and available for inspection. The vehicle has approximately 84,000 miles and is good condition otherwise. This vehicle is used to transport our children to and from school. My wife was placed in danger because her ability to control her vehicle was eliminated. The vehicle had recall 15S18 completed in 2016, but, only the computer was updated. The faulty part was not replaced. The error message associated with this recall appeared on the dash, "Power Steering Assist Fault". We had the vehicle towed to the dealership for assessment. A technician at Suburban Ford Sterling Heights identified the faulty part was the same one associated with the recall. Ford Customer Support would not authorize repairs as part of the recall despite the fact the exact part involved in the recall, which was not replaced, has failed. The vehicle showed signs of malfunction starting Sunday, [XXX]. The power steering intermittently failed on Monday, [XXX]. Our insurance roadside assistance towed it from a commercial location on Monday, [XXX]. The vehicle has no other mechanical issues that could be attributed to this failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Power steering assist fault. While driving power steering stopped working. No matter what i do to reset it will not work Took to dealer found there was a recall the pscm had been previously flashed under 15s18 recall. The steering gear was not replaced which put it under 15n01 program Now the internal angle sensor on rack has gone out.so in short they did half the recall repair. Called ford they refuse to pay for repair saying its past 15n01 guideline's.which are 10 years 150,000 miles i only had 89k when it went out. Why are safety recalls allowed to expire? For dealer to fix its a $4k repair. The car isnt even worth that. Unfair for consumers!!

Ford issued recall 15s18 for electrical issue in sterring gear in 2015 Our fords power steering system failed on 01/13/2025 Huntington Ford dealership refused to repair after diagnostic shows a power steering system fail claiming that we are not covered for the recall

The contact owns a 2012 Ford Fusion. The contact stated that while her husband was driving at an undisclosed speed, the steering wheel became firm and difficult to turn in either direction. The power steering warning light was illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

EPAS, electronic power steering assist, not a question of "if" it will go out, but "when". Ford has acknowledged an issue but classified it as a "CSP" so they don't have to do anything about it as opposed to a recall, this issue effects multiple models in multiple years, the unit in question is near an exhaust manifold with a small heatshield, and over time the heat shield isn't enough to protect the components resulting in a failure, this failure is huge for losing control of a 3,500 lb , slowing reaction time at low speeds, i.e. parking lots or neighborhoods with kids as it takes immense effort to turn even slightly, for refuses to fix the issue but is aware how detrimental it is to the safety of its drivers. Owners that had the "software reset" had the previous "CSP" cleared (15S18) still failed, as a result they refuse to follow through on the related supplement #3, this needs to be re-opened, and a proper recall issued before life is lost.

Power-steering failed as well as received a warning on dash to "service advance trac, service power steering now" All warning came up during a approx. 1 hour drive and the power steering fully shut off after turning car off then back on at a gas station on the way. Lack of power steering puts lives at risk due to the difficulty the driver has in controlling the vehicle particularly at lower speeds where it is more likely there are pedestrians around.

The contact owns a 2012 Ford Fusion. The contact stated that the vehicle lost power steering assist functionality upon starting the vehicle with the "Power Steering Assist Fault" message displayed. The contact stated that prior to the latest failure, the failure was intermittent; however, the power steering assist would return upon restarting the vehicle. The contact stated that the failure persisted after several attempts to restart the vehicle, and the contact used excessive force to drive the vehicle to the residence while a friend drove closely behind for assistance. Upon investigation, the contact discovered NHTSA Campaign Number: 15V340000 (Steering); which he linked to the failure. The manufacturer was notified of the failure and referred the contact to the dealer after providing an estimate for the repair. The vehicle was not repaired. The failure mileage was approximately 70,000.