2012 FORD FUSION Complaints

The contact's daughter owns a 2012 Ford Fusion. The contact stated that while attempting to drive from a complete stop at a traffic light, the steering wheel was significantly difficult to turn. The power steering warning light was illuminated. The contact was able to pull over to the side of the road and turned off the vehicle. The contact received a ride from her father. The contact stated that upon restarting the vehicle, the failure recurred. The vehicle was taken to the residence, where it was diagnosed by an independent mobile mechanic. The mechanic determined that the rack and pinion needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was not repaired after the failure. The dealer was notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 15V340000 (Steering). The failure mileage was approximately 168,000.

The contact owns a 2012 Ford Fusion. The contact stated while the vehicle was parked, the vehicle was started, the gear shifter was shifted into drive and the vehicle rolled forward. In addition, the power steering assist fault warning light illuminated. The contact stated that the steering wheel was difficult to steer. The vehicle was towed to a dealer where it was diagnosed as a failed electronic power steering module. The contact was informed that the electronic power steering module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 65,000.

The contact owns a 2012 Ford Fusion. The contact stated while driving at an undisclosed speed, the steering wheel seized with the power steering warning light illuminated. The contact stated the steering wheel became difficult to operate. The vehicle was taken to an independent mechanic where it was diagnosed that the vehicle had lost power steering functionality and needed to be repaired. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Driver door is not locking. Tried with manual key too but not successful. Tried to open door from inside but no success. Looks like door assembly or spring is faulty and designed poorly This can be a safety hazard as driver can't get out of car easily. Pls recall all Ford fusion 2012 and ask dealers to fix it. I checked few articles forums and YouTube videos and everywhere it says there might be a spring problem or some plastic issue in latch or door assembly.

Same issue as others have stated with the power steering just stopping all of a sudden. The car randomly starts yelling about service power steering now and service advancetrac, you put the car in park or turn it off and then the power steering goes out. Had it cleared by a mechanic who said it is a sensor issue. We didn’t get to replace the sensor but power steering came back when he cleared the codes. About a week later it happened again. And like others, there isn’t a recall listed for it with my vehicle just something about the air bags.

The vehicle’s power steering failed on a major roadway with a [XXX] driver at the wheel. This is a defect in the power steering that is known to Ford, the recall was supposedly fixed but it failed again so the fix is also very unsafe. Ford needs to find a way to actually make the steering safe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The power steering went out. They had a recall for it but its no longer available. I never had an issue til now so if it was a danger then it should still be a recall no matter what year it is now

Power steering was repaired under recall warranty about 3 years ago. The replacement part failed. This part should have outlasted the car, this it's a known issue

The contact owns a 2012 Ford Fusion. The contact stated that while the vehicle was in park, the vehicle rolled backward with no warning light illuminated The contact engaged the parking brake pedal, and the vehicle stopped. The contact also noticed that the transmission shifter cable had dislodged from the vehicle. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 113,000.

I am the original owner of this 2012 Ford Fusion. It currently has 122,000 miles. The power steering went out on my car last week. SERVICE POWER STEERING NOW light came on. Had the car towed to the Ford dealership in Sandusky. I was advised the repair would be $2100.00. In doing research I found that while there was not a recall on the car there was the following that was put out by Ford. 15s18 Supplement 3. I contacted Ford customer service and was advised that my car was 2 months out of the build date for the service advisory from Ford. From what I have read this is not an uncommon problem for this model year. Please feel free to contact me. My cell number is [XXX] . Thanks! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)