2018 FORD FUSION Complaints

2018 fusion ecoboost with no lights or warnings would not start. Took to ford to repair, took them several weeks and several of the same part to fix crankshaft position sensor. Was given a clean bill of health on car. Everything was I'm good condition they said after I paid the 1500.00$ repair bill. Less than 1 week later the car dies while on highway going 65 mph without warning. No lights, nothing. Just sputtered and died. Done all I could to get out of the way so I would not be hit on highway. Catastrophic engine failure resulting in engine locking up had occurred. This car has been taken care of, less than 75k miles on it and the engine is garbage. I lost my job, almost lost my life, lost my home, over half of my possessions all as a direct result of this faulty car that was designed to fail. Ford knows about this engine problem, they continue to sell these cars and refuse to pay for repairs or recall them.

The contact owns a 2018 Ford Fusion. The contact stated that the vehicle had experienced rough starts and there was a slushing liquid sound coming from inside the dashboard. Additionally, while operating the vehicle the check engine warning light remained illuminated and the vehicle stalled. The vehicle was taken to the local dealer who diagnosed that the engine block was cracked and causing coolant to leak into the engine. The contact was advised that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 120,000.

While driving, the low oil pressure warning light illuminated on the dashboard. Within 5-10 minutes, the vehicle began to lose power and struggled to maintain speed. Over the next 15 minutes, the vehicle's performance continued to deteriorate, eventually shutting down completely. Despite multiple attempts, the vehicle was unable to be restarted, the vehicle has not been inspected and the vehicle never gave any prior warning of potential failure this was the frist and only issue I had with this vehicle I had to have the vehicle towed home due to not starting

It was losing calling but no coolant leak, rough idle/driving and blows white smoke out of the exhaust and threw the code p1299 so I took it to a garage and they told me it was the cylinder head gasket but my car has no recalls on it and I looked up my problem and it said 2013-2018 ford fusions with the 1.5l built before June 2019 and mine was built in feb 2018 and I haven’t received any mail about a recall.

The contact owns a 2018 Ford Fusion. The contact stated that while driving 45-50 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the head gasket was blown. The dealer determined that the engine block needed to be replaced. The vehicle was then taken to an independent mechanic, where the engine was replaced. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 97,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was an engine misfire, and the low coolant level warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into cylinder #2 and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under Customer Satisfaction Program: 21N12. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 56,000.

The contact owns a 2018 Ford Fusion. The contact stated while driving 25 MPH and depressing the accelerator pedal, the vehicle hesitated to respond, jerked, and experienced hard shifts while responding. The contact stated that the failure had been recurring while driving. The power train warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with internal transmission damage that caused clutch B to fail. The dealer determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 80,559.

Shift sys fault message appeared on screen. Car will not go out of park. Shifter bushings are no good. Was told if this had happened while driving my car could not be put in park and could result in a crash.

Summary: I purchased a 2018 Ford Fusion from Reliable Chevrolet on [XXX]. After driving the vehicle a little less than 15,174 miles the check engine light came on. The Ford dealership concluded there was a coolant leak into cylinder 2 and suggested a long block replacement. After further investigation it appears this vehicle falls under NHTSA CSP 21N12, 19B37 and TSB 22-2229. The Ford dealership and Ford Motor company refused to assist in providing financial assistance for the needed repairs. We were also not notified by Ford, Reliable Chevrolet, or the extended warranty company (purchased through Reliable Chevrolet (MPP Co)) that this vehicle is subject to multiple NHTSA CSPs or TSBs before the purchase (possible violation of Section 17.46 of TBCC and Section 17.41 of DTPA). Ford Motor Company Customer Ticket - [XXX] Auto Nation Ford (Frisco, TX) Invoice Date July 24, 2024 It is my opinion one or more of the parties mentioned above should be held accountable for the needed repairs as this is a documented defect that should have been disclosed before purchase or at the minimum before out extended warranty expired in March of 2024. Please let me know what other information is needed to help complete this complaint. Best Regards, [XXX] Frisco, Texas [XXX] email - [XXX] mobile - [XXX] Supplement Details: Culpable Parties Manufacture Ford Motor Company 1 American Road, Dearborn, MI 48126 PO Box 6248 Dearborn, MI 48126 Called and opened a case on 08/24/2024 Case [XXX] Seller Reliable Chevrolet 800 North Central Expressway Richardson, Texas 75080 Extended Warranty Company (provided by dealer) MPP Co., Inc P.O. Box 634, Shawnee Mission, KS 66201 Vehicle Information 2018 Ford Fusion VIN- [XXX] Manufacturer: FORD MOTOR COMPANY, MEXICO Series: SE FWDTrim: Gross Vehicle Weight Rating: Class 1: 6,000 lb or less (2,722 kg or less)Drive Type: FWD/Front-Wheel Drive Cylinders: 4Primary Fuel Type: Gasol INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Fusion. The contact stated while driving 45 MPH, the engine started to overheat, and there was smoke coming from underneath the hood. The message "Vehicle Temperature Overheating" was displayed. The contact pulled over to the side of the road and allowed the vehicle to cool down. The contact was able to continue driving; however, the failure recurred several times while driving. The contact pulled to the side of the road several times until arriving to the residence. The vehicle was taken to the dealer, where it was diagnosed that the PCM had failed. Additionally, the dealer diagnosed there was coolant intrusion in the engine cylinders. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21N12. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 181,000.