2012 FORD FUSION Complaints

The contact owns a 2012 Ford Fusion. The contact stated that while driving 50 MPH, the vehicle lost power steering functionality and almost caused a crash. The message "Service Power Steering Now" was displayed. The contact was able to drive to the destination. The contact stated that the vehicle had become undrivable due to the failure. The contact related the failure to NHTSA Campaign Number: 15V340000 (STEERING); however, the VIN was not included. The dealer and the manufacturer were not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 130,000.

Brake system. Pedal is soft and braking force to stop is reduced. Yes, at first they thought it was the brake booster, and know thinking it is the master cylinder, now they aren't even sure what it might be. Ford dealership techs. No, pedal was "squishy" when braking

I was just driving and I lost power steering, it was incredibly difficult to steer and it was Heavy Steering, and warnings appeared on the dash.

Se traba y se pone duro el "gobierno" junto con la cremallera electroasistida el volante no gira ni con el carro prendido, no eh echo uso de la campaña 15S18, nunca ah Sido asistido por el fabricante Ford, ni mucho menos lo eh metido a un taller de servicio independiente ni con aseguradoras y no me marco algún sensor del tablero antes de que me sucediera este problema con la "dirección asistida averiada"

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 40 mph, the steering wheel was hard to turn. The low tire pressure message was displayed. There was another unknown system message being displayed. The contact indicated the failure was related to NHTSA Campaign Number: 15V340000 (Steering). The vehicle was taken to the local dealer, where it was diagnosed and determined that the power steering pump was the cause of the failure. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was unknown.

Our 2012 Ford Fusion had a sudden and complete loss of power steering & “Power Steering Assist Fault’ flashed on dash. The steering immediately became extremely difficult to operate, requiring both hands and excessive physical force just to turn the wheel. It felt less like driving a passenger car and more like wrestling a fully loaded dump truck with flat tires. This created a serious safety concern because the failure occurred without warning and fundamentally affected our ability to steer the vehicle safely. Fortunately, my wife was not driving at the time. The amount of force suddenly required to turn the wheel could easily be overwhelming, particularly during an emergency maneuver, in traffic, or while entering an intersection. After the failure occurred, we discovered vehicle had previously been subject to recall 15V340000 and Ford Safety Recall 15S18, both involving the exact electric Power Steering Control Module (“PSCM”) that has now failed. Under that recall, a Ford dealer performed only a software update on 10/17/2016. We opened a case with Ford, brought the vehicle to a local dealer & paid for a diagnostic inspection. Using Ford IDS equipment, dealer confirmed the condition and documented ‘NO COMMUNICATION WITH PSCM’. The dealer report quoted “Steering Gear Assembly - Rack & Pinion Assembly Replace: $3,215.81.” The diagnosis was reported directly to Ford under the active case number. Despite the recall history and confirmed failure of the same steering system covered by the prior recall, Ford denied assistance because the earlier software reprogramming had already been completed. Our position is that this is clearly a hardware failure involving the recalled electric power steering system itself — the precise condition the recall was intended to address. Ford’s own recall communications dated May 17, 2019 specifically instructed owners to retain recall documentation in the event this exact situation later occurred.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the power steering became inoperable with the electronic power steering warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 176,020.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at various speeds and making a left turn, the driver's side door unexpectedly opened. The contact stated that the door ajar warning light was illuminated. The failure became a recurring failure. The contact had taken the vehicle to a local dealer where it was diagnosed, and determined that the door latch needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 20V177000 (Latches/Locks/Linkages). The contact informed the dealer of the recall and was informed that the VIN was not included in the recall. The manufacturer was informed of the failure. The failure mileage was approximately 124,000.

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 20 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact was able to continue driving, but the steering wheel was difficult to turn. The vehicle was driven to an independent mechanic, where it was diagnosed, and determined that the steering gear had failed and needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The manufacturer was notified of the failure but denied assistance due the manufacturing date of the vehicle. The failure mileage was approximately 56,000.

The contact owns a 2012 Ford Fusion. The contact stated that while operating the vehicle, the power steering malfunctioned, and the steering wheel was extremely difficult to turn in either direction. The vehicle was driven to the local dealer, and the power steering control module was updated under NHTSA Campaign Number: 15V340000 (STEERING); but the failure was not corrected. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was approximately 190,000.