2018 FORD FUSION Complaints

The contact owns a 2018 Ford Fusion. The contact stated while driving 35 MPH, the engine started to misfire. The contact stated that the check engine warning light was illuminated. The contact turned off and restarted the vehicle and was able to continue driving to her destination. The contact stated on July 28, 2023, while driving 35 MPH and depressing the accelerator pedal, the vehicle failed to exceed 35 MPH. The contact parked the vehicle because the vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the engine to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 105,669.

The contact’s son owns a 2018 Ford Fusion. The contact stated that while her son was driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle decelerated while the accelerator pedal was depressed. The vehicle was taken to an independent mechanic where it was diagnosed and determined that coolant had leaked into the engine, and the engine needed to be replaced. The vehicle was not repaired. An undisclosed dealer and the manufacturer were notified of the failure and the contact was informed that the VIN was not included in a recall. Additionally, the mileage had exceeded any extended warranty coverage. No further assistance was provided. The failure mileage was approximately 129,000.

The contact owns a 2018 Ford Fusion. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to a certified mechanic who after 3 days diagnosed and determined there was coolant intrusion into cylinder #2. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact spoke with the dealer and was informed that the failure was a known issue; however, the VIN was not under recall. The manufacturer was not made aware of the failure. The approximate failure mileage was 127,000.

In July 2023 my vehicle started to display a shudder upon start up. The check engine light came on. I took the vehicle to my local mechanic who informed me that there was a cylinder 1 misfire. The spark plugs were replaced. Approximately one week later the engine light came on and I took the car to the local mechanic.. The mechanic said cylinder 1 was again misfiring. The mechanic examined the engine and determined that the newly installed spark plugs were corroded due to engine coolant leaks. I was advised that Ford Motors issued TSB 22-2133 for this problem recommending an engine replacement. I took the car to the local Ford dealership for a diagnosis. The dealership informed me that the engine coolant was empty and that the engine needed to be replaced and cited the TSB. Research showed that Ford Motors has known of this problem affecting the 2.0L EcoBoost engine for many years but has not taken steps to discontinue manufacture of the type of engine affected and continued to use it in other models and year vehicles. The sudden loss of engine coolant and resulting catastrophic engine loss is a serious safety issue where a vehicle, if continued to be driven, could overheat, catch fire or cause a serious accident if occurring on a highway at speed. Ford Motors should issue a recall of this engine and replace them in all affected vehicles. Presently, Ford will only replace the engine if after the problems occur and at the consumer's expense. Ford knowingly manufactured, used, and sold defective engines in many model year vehicles risking customer safety and causing consumers financial hardships to correct the problems with no guarantee that the problems will not reoccur.

my vehicle axel and suspension broke while driving vehicle hit driver side curb while in turning left lane at the intersection during the green light to avoid another vehicle driving unsafe. Hitting a curb should not have cause vehicle axel and suspension to collapse. This could have caused major accident because vehicle behind me could have ran into the rear end of my vehicle while in the turning. Also particles were falling from underneath the vehicle while trying to get vehicle over to the far right lane out of the way of other vehicles.

Bushing that controls the shift gear pops out I am aware that other fords have a recall for this yet this one is absent from your list

I purchased a 2018 Fusion in January with 118k miles. 6 months later the engine light came on sometimes it wouldn’t start. Misfires can cause fires and it was absolutely chugging gas. Took it to ford they diagnosed coolant intrusion and said I need the new updated cylinder block. Wasn’t covered under my extended power train warranty I had with the car and it was almost a $9000 fix. I’ve got a lemon on my credit now and ford needs to recall or compensate to this asap

The contact owns a 2018 Ford Fusion. The contact stated that while driving uphill at an undisclosed speed, the check engine warning light remained illuminated with the engine temperature gauge showing that the engine was overheating. The vehicle was taken to the local mechanic who diagnosed that the engine was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 124,000.

The contact owns a 2018 Ford Fusion. The contact stated that on several occasions while shifted into gear, the vehicle failed to respond as needed. The contact stated that the parking brake warning light flashed and remained illuminated. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact stated that the VIN was not under recall. The contact was advised to contact the NHTSA Hotline for assistance. The failure mileage was approximately 59,000.

My car has to replace the TRANSMISSION with 54.275 miles . The reason for chance was , when accerating car maked a loud ratlling/screeching noise, from internal noise from transmission. Santa Monica Ford Lincoln Dealer did the job. Then after about driving 35.000 miles, againg The same noise. I tool The car back to SANTA MONICA FORD LINCOLN DEALER, and they (Car had 96000 miles, that time) and they refused to fix it again. They Cheked it, and found the same problema with this transmission. My car is Parking for over a year. FORD never help.