2016 FORD FUSION Complaints

Car initially showed a warning alert for failed traction control. Attempted to reset using steering wheel reset, failed. Tried backing car up and steering became extremely hard to do, requiring maximum effort to turn wheel. Steering power assist light lit up on dashboard. Parked car. Made appointment with Heritage Ford, South Burlington, VT. Upon subsequent investigation discovered that 2016 Fusion had been recalled #19V632000 but only when sold in Northern States where salt was being used or currently registered in (Vermont was included). I moved to Vermont to be with family in 2020. Failure occurred about [XXX]. 1). Had this failure occurred, while driving we could have had a fatal accident. 2). Shouldn’t there be provisions for folks who move into northern states originally identified or is Ford dictating these non recalled cars remain in non salt applying states for their life? Shouldn’t all cars have been recalled to prevent catastrophic failures? 3). Failing the recall shouldn’t the cars be supplied with warning placards saying that exposure to excessive road salt could result in catastrophic steering failure? 4). I recently asked the service rep (Amanda) at Heritage if there were any other recalls for this car and she said no. Does that mean this vehicle is exempt from the recall because it got to the state after some arbitrary deadline? Does allowing cars to travel the roads of any Northern state with this defect make sense? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Ford Fusion. The contact stated that when the vehicle was started, the contact noticed that the engine was misfiring. The check engine warning light was illuminated. The contact replaced coil pack however, a month later the failure reoccurred. The contact noticed that the coolant reservoir was empty but there were no signs of a leak. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 138,000.

The contact owns a 2016 Ford Fusion. The contact stated that while her husband was driving at 70 MPH, the temperature started indicating that the engine was overheating, with a message “Engine temperature high” displayed. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the engine was low on oil, resulting in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 102,000.

The contact owns a 2016 Ford Fusion. The contact stated that the check engine warning light illuminated while starting the vehicle. The contact also stated that the vehicle hesitated while depressing the accelerator pedal while driving at various speeds. The vehicle was taken to an independent mechanic where several speed sensors were replaced. The contact then stated that while driving in stop-and-go traffic, the vehicle stalled with white smoke coming from under the hood. There was no warning light illuminated. The contact drove the vehicle to a parking lot where it was later towed to an independent mechanic. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 103,000.

I was driving my car when i saw an emergency sign on the dashboard telling to safely park. then the car could only drive using the power generated by the electric battery and when the battery went out of power the car could not switch to gas to use the engine power I was on san mateo bridge when it happen I could feel the car rolling back on a park gear.

When I was backing out of my apartment complex and tried to turn left the car just stopped and when you turn the wheel it says service advance trac and hill Start car hasn’t been drove since last Friday

The contact owns a 2016 Ford Fusion. The contact stated that the vehicle hesitated while depressing the accelerator pedal and was shaking abnormally while idling with the check engine warning light illuminated. Additionally, the contact stated that the temperature gauge indicated that the vehicle was hot with white smoke coming from the exhaust pipe. The vehicle was initially taken to an independent mechanic who diagnosed the vehicle with a defective spark plug. The spark plug was replaced; however, the failure persisted. The vehicle was then taken to a dealer, and it was discovered that there was coolant intrusion into an engine cylinder. The vehicle was diagnosed with engine failure. The manufacturer was notified of the failure but offered no assistance. The vehicle had yet to be repaired. The failure mileage was approximately 130,000.

After doing research I have found that I am not the only one experiencing this issue,but I have a 2016 ford fusion 1.5 ecoboost engine and I am having problems with my cylinder leaking. I have to constantly refill coolant and the only option to fix this issue is to replace the motor

The car stalls out and stops moving out of no where while driving and smells like fuel as well

Steering fault indicator on dashboard and then steering loss displayed and now can not steer car