2012 FORD FUSION Complaints

The contact owns a 2012 Ford Fusion. The contact stated that while making a left turn, the vehicle inadvertently lost power steering. The warning message "Power Steering System Default" illuminated. The contact stated she was able to continue to drive the vehicle with manual steering. The dealer was notified of the failure. The contact was awaiting a call back from the dealer. The contact stated that the failure had been reoccurring while driving. The contact referenced NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was not notified of the failure. The vehicle was not diagnosed or repaired. The approximate failure mileage was 88,000.

The power steering assist failed while driving on freeway. Steering all but locked up. Power assist failure code presented itself beforehand, pretty much from the week I purchased it, and the owner's manual instructed to pull off road, turn off engine and restart to stop code (??), which always worked, until 2 weeks ago. It was a very scary and unsafe situation when it failed while driving. After research I found out Ford used shoddy and faulty parts for the power steering modules. I never received any correspondence from Ford or NHTSA for my vehicle, yet when I called a Ford dealer they said my car was affected and could be fixed if under 150,000, which it is not. But, had I k own this was an issue, I would have had it repaired from the beginning, and not followed what the FORD MANUFACTURER OWNER'S GUIDE SUGGESTED each time. I want my car repaired by Ford and they are refusing stating NHTSA was responsible for recall informing, which again I was not informed.

Electric power steering assist fault. Had power steering one minute and the next minute it is extremely difficult to steer. Called Ford and told them the issue. They said that the recall for this had been done already. They downloaded new programming, but never changed the part. Then they put an extended manufacturer warranty to 150,000 miles. Incident happened just over the extended warranty period and have done research on many complaints about the same issue. Ford refuses to do anything about it and repair costs are over $2,000.00. This is extremely dangerous and may cause serious injury or even death at higher speeds. Luckily no one was hurt this time.

Power Steering Assist Fault. When attempting to operate vehicle, it would not allow for steering. This put my entire family at risk for accident.

Door handle open mechanism failed (of driver side door) thus causing a safety issue because you cannot exit the vehicle when inside, except by rolling down the window. This issue has been reported by several other owners.

The powersteering fault was never taken care of when we went to get it fixed at the dealership. We had taken it in because it was a recall error and because the fault "didn't show up" when they were trying to fix it they said that they couldn't do anything about it and returned the car to us in less than one day which the work that was actually required would have taken longer to do. We didn't know what to do or how else to complain but now the vehicle is permanently stuck with this error and wont budge.

The contact owns a 2012 Ford Focus. The contact stated that upon the start of the vehicle, the power steering assist failed to operate without warning. The contact had initially taken the vehicle to an independent mechanic where he was informed that the steering rack needed to be replaced. The mechanic also informed him that since the power steering was electric, the vehicle had to be serviced and programed by an authorized dealer. The contact then took the vehicle to a dealer and it was confirmed that the steering rack needed to be replaced. He was provided an estimate for the repair but was declined. The manufacturer was notified of the failure and provided the contact a case number. The vehicle was not repaired. The failure mileage was unknown.

2012 Ford Fusion SE 4cyl 81,782 miles Power Steering Rack failure - Hazardous situation without previous system degradation, warning or indication. Loss of steering control, not able to steer, steering wheel would not turn without using great force. After engine stop and restart, the dash lamps were illuminated: Fault Lamp = Service Power Steering Now Fault Lamp = Service Advancetrac System Problem happened during a vacation road trip in the mountains of Kentucky. The vacation was interrupted. The car towed to Greenwood Ford dealership in Bowling Green KY. Fault not covered under recall or warranty. Steering rack replaced at a cost of $3200. Ouch. will it happen again? Dealer could not return failed parts to me without additional $1500 core charge paid by me. We also paid towing and rental car costs. The same failure is happening to many 2012 Ford Fusions.

Our 2012 Ford Fusion began displaying a “POWER STEERING ASSIST FAULT” summer of 2021. We did not record the 1st instance of this fault, but began recording subsequent instances on 7/25, 10/18, 10/20, 10/21 On 10/21 the vehicle also displayed “SERVICE ADVANCE TRAC.” We were unable to steer the car when the fault occurred, although we were able to put it in reverse or drive, which seems extremely dangerous. Fortunately, these instances occurred while parked. The vehicle ignition was turned off and restarted, which cleared the fault & power steering resumed. This vehicle had less than 69,000 on Aug 4, 2021 when taken to Courtesy Ford in Portland, OR where the vehicle was purchased to replace the driver side airbag under recall notice received in the mail. We had them investigate the power steering assist fault during the same service. We were advised that the Ford mechanic was “Unable to duplicate customers concern” and “No fault codes in the system.” The vehicle was then taken to Damerow Ford in Beaverton, OR on 11/18/21. The next day, 11/19/2021, we were advised of an electrical problem in the steering assembly. We were told that it needed to be replaced along with some bolts and nuts. The invoice indicates that the steering gear assembly was replaced & gear was programmed. The bill came to over $2205.62. We’ve discovered through an online search that Ford is well aware of this problem & has been for years. We’ve been told by both dealers our VIN number is not included in the recall and the extended warranty for this issue, which makes no sense. Fortunately, we did not experience the lack of steering while driving, as others have. Our lives & vehicle & the lives and property of others on and along the roadways we have traveled were jeopardized with a well known safety issue & Ford Motor Company is not standing behind their product. Do we have recourse for reimbursement from Ford Motor Company through the NTSB for this unethical corporate behavior?

The power steering goes out and a warning message comes on saying power steering assist fault. Called a Ford dealership and they said there was no recall for this.