2022 FORD MAVERICK Complaints

I had just filled up my truck with gas and started driving to work today and the truck went into limp mode. It flashed a low gear warning, then started to slowly stop, all of the system alarms went off, including the check engine light. There were so many pop-up's I can't recall them all. I was able to pull over and start slowing down before it engaged the emergency brake and I experienced a hard stop. I turned the truck off and back on with no help. I turned the truck off again and opened the door, then shut the door and turned the truck back on and the brake was then turned off but check engine light still on. When I put the truck in drive it would start to accelerate without me pressing the gas. I pulled over again and turned the truck off again and back on. This time the truck behaved more normally but the check engine light is still on. Not sure if this is related to last recall service I recieved.

After shutting the vehicle off and removing the key from the ignition the ICE engine continues to run for a bit. The steering wheel display is also lit up and I had the door open to the vehicle. I opened the hood and confirmed the engine is running. This has happened a few times so far. Sometimes the display that shows the MPH and other info goes out but the engine still runs. I've also had occasions when the key is removed, the engine is running and then shuts off. Pressing the gas pedal, the engine comes to life. If I hold the pedal down the ICE engine runs, remove my foot from the gas and the ICE engine shuts off.

The contact owns a 2022 Ford Maverick. The contact stated that for two years from the end of November to April, he observed a burning odor in the cabin of the vehicle, that caused him to have a headaches and stomach aches. The vehicle was taken to a dealer on multiple occasions where the failure was not able to be replicated. The vehicle was then taken to a different dealer where it was diagnosed that the blower motor resistor needed to be replaced. The vehicle was repaired but the failure persisted. The contact believed that the failure was associated with NHTSA Campaign Number: 23V380000 (Engine). The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 3,975.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Vehicle was in cruise control driving along the highway at-speed when the engine suddenly cut out and cruise control stopped maintaining speed. Pressing the accelerator did nothing, but the brakes still worked. After turning cruise control off the accelerator was still having no effect, and the vehicle did not let me re-engage cruise control. All other electronics (navigation, music, dash, hazard lights, etc.) continued to work fine, but I noticed that the light on the gear selector was blinking instead of the normal solid yellow. I pulled over onto the shoulder and came to a stop, at which point the vehicle put itself into park and engaged the parking brake. Several warning and advisory messages appeared on the screen advising me not to drive the vehicle, and almost all of the warning lights on the dash lit up. The electronics continued functioning for a time, but after a short while (less than 2 hours) they died as well. This included the locks, mileage indicator, windows, hazard lights, and gear shift—the vehicle could not be put into neutral. The vehicle was loaded onto a flatbed tow truck and taken to a dealership. Service invoice is attached. To summarize, it appears that a failure in the heat exchanger caused engine to cut out. Cause of electrical failure after stopping is unknown.

On April 22, 2024 my truck had a loss of power foe the second time while driving on the interstate with my family. There was no warnings or anything, the truck simply lost power and I had to pull off the road at which point it went into limp mode. I had several lights on my dash, Mai ly the check engine light and my mobile app recorded a fault with the drive train. This is now the second time this has happened in a few months. I have taken it to the dealer both times and they've told me that nothing is wrong with my truck. I explained that it is extremely dangerous but they said they can't do anything because the truck isn't reporting any issues. Please put pressure on ford to fix this. It is getting out of control.

Recently got a couple recalls done and then yesterday while I was driving back home I Ford chimes twice and then see a plethora of service lights and dash warnings. Completely lost power on the freeway pulled over from originally being in the left lane in time. But could of been a lot worse if I wasn't coming back at 11pm. Restarted the truck and it let me go a max of 20mph all the way home (luckily I was near my exit) flooring it the entire time. Then after an hour of sitting at home I started it up again to surprisingly what felt like full power again but with a check engine light.

Driving at 30 mph when car lost power, emergency brake came on, would not accelerate. check engine light came on with multiple other warnings like drive modes disabled, service advancetrac, pre-collision assist not available. have video. was able to coast home as not applying accelerator pedal resulted in auto increased acceleration. luckily i was on a residential street. this vehicle is an absolute lemon.

I was driving in town going about 20 MPH when I approached and intersection and stepped on the brakes. The brakes locked up, multiple warning lights, messages, audible alarms went off. I though the truck died and I put it in park and turned off the key. Then I turned the key back on, all the lights and warnings came back on, but it also said ready to drive. I was not able to accelerate using the gas pedal, truck was moving slowly on its own, it gained some speed but only ran on the electric motor. No gas engine. I got 3 blocks to my destination very slowly and shut the truck off. I had to go inside to do some work and when I came back about an hour later I turned the truck on and all the alerts were gone except the check engine light. It did run normal then. After calling the dealership they said to bring it in so they could look at it. I left it there and they called later saying they had pulled multiple error codes, did not tell me what they were, they cleared all the codes and drove it and said it did not act up for them and said I could come pick it up. I do not want to drive it because I feel like this could happen again at any time and if I were driving at a higher speed or on a interstate and this happened who knows who could have been hurt. This Maverick is my daily driver for work ect. but I will not drive it unless I absolutely have to right now. I got no answers from the dealership. Before this, no warning lights had been on.

The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 45 MPH, his girlfriend who was occupying the front passenger's side seat, informed him that there was an abnormal odor inside the vehicle. Additionally, the contact sustained severe headaches while driving. The contact drove to the hospital, where he was informed that there was an elevated level of carbon monoxide in his blood, and he had sustained carbon monoxide poisoning after two hours of exposure. The contact also stated that the check engine warning light was illuminated intermittently. The vehicle was taken to the dealer, where it was determined that the heater exchange needed to be replaced. The vehicle was repaired. Additionally, the contact stated while driving 70-75 MPH with the Adaptive Cruise Control engaged, a message indicating that the gear was changed forcibly was displayed, and the Eco mode was disengaged, and the engine stalled. The contact was able to pull to the side of the road. The messages "Service Advancetrac", "Service Engine Soon" "Pre-collision Assist Not Available" and "Hill Assist Not Available" were displayed on the instrument panel. Additionally, the messages "Power Train System Fault" and "Collision Assist Unavailable" were displayed on the mobile app. The traction control warning light was illuminated. The contact was able to restart the vehicle after several attempts and a Police Officer assisted the contact in driving to the other side of the road. The contact was able to continue driving at 45 MPH. The vehicle was taken to the dealer, where the failure could not duplicated because the check engine warning light was not illuminated. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 18,000.