2022 FORD MAVERICK Complaints

While driving on the streets the powertrain module gave out. It started to jerk around 30 mph and then just would not go.

Engine failure with fire. Fully engulfed within seconds. Police and fire on site. AAA insurance No prior issues with vehicle

What component or system failed, and is it available for inspection? The right frame engine mount, differential/rear mount, and upper engine mount were all torn or broken. Both front CV axle shafts also needed replacement. Repaired 8/17/2026 by Miami County Auto, Louisburg, KS (invoice #13092). No, I don't have the parts anymore. How was your safety or the safety of others put at risk? The vehicle developed a wobble/vibration under acceleration that was reported as "getting worse" — pronounced enough to visibly shake objects in the cabin. The shop noted the engine mounts were torn/broken, allowing excess engine movement, which increases risk of further mount or drivetrain component failure and loss of vehicle control, especially at highway speeds or during hard acceleration. Has the problem been reproduced or confirmed by a dealer or independent shop? Yes — confirmed and repaired by an independent shop (Miami County Auto) on 8/17/2026 at 104,205–104,211 miles. Not taken to a Ford dealer. Has the vehicle been inspected by the manufacturer, police, insurance, or others? No — only inspected and repaired by the independent repair shop noted above. Were there warning symptoms before failure, and when did they first appear? Yes — a wobble/vibration under acceleration that subsided when off the throttle, and progressively worsened over time before the repair. Originally I thought it was a recently repaired tire that was unbalanced. Took it to Ford dealership to rebalance. They said there was no wobble (there was) and took it the independent shop.

The Ford Maverick is subject to rodent invasions which caused an engine fire. We had to file a State Farm Insurance Claim ($4016.36 of repairs done to repair the engine including electrical, emission system, cowl, fuel system, and insulation.) This was completed XXX. We have been faithfully spraying the engine with Rodent Repellent, using Natural Repeller packs, and rat snap traps. We have regularly checked the engine to see if they have come back. Yesterday, XXX, low and behold there was evidence of rat/mice droppings, insulation, food, nesting, etc. We again have spent time and money to clean the engine and use the above-mentioned products to try to protect the engine. After moving the truck, again on XXX, there was new evidence. We treated again. This is causing us stress. This should be a recall and Ford made to remedy. Sincerely, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving my 2022 Ford Maverick on a public road, the vehicle suddenly lost acceleration and would not respond normally when I pressed the accelerator. I was left in the roadway and could not safely continue driving, creating a risk of being struck by other traffic. The vehicle was later inspected by a Ford dealership and diagnosed with a major internal transmission failure at approximately 62,000 miles. The Ford dealership recommended a rebuilt/replacement transmission. The vehicle remains available for inspection. I did not have advance warning that the transmission was about to fail.

On 7-2-26, my 2022 Ford Maverick Hybrid was brought to College Station Ford to receive the remedy for mandatory Safety Recall 24S59 (NHTSA Campaign 24V684000) regarding the frozen Rear View Camera display image. Prior to this service, the vehicle’s electrical, starting, and hybrid systems functioned flawlessly without error.Immediately following the completion of the recall service, which required a software flash of the Connected Touch Radio/Audio Control Module (ACM), the vehicle suffered a catastrophic module network failure resulting in a permanent no-start condition. The vehicle's Powertrain Control Module (PCM) and Body Control Module (BCM) have glitched into a permanent High-Voltage System Isolation Lockout loop.Independent professional laboratory load-testing has certified that the vehicle's low-voltage 12V auxiliary battery is healthy, fully charged, and completely functional. However, the vehicle can currently only be turned on by attaching an external 12V jump-pack directly to the battery system. This external voltage spike manually overrides the corrupted software communication loop, forcing the vehicle's electrical relays to close.The dealership has refused to remedy this botched recall programming, claiming the physical hybrid high-voltage lines have suddenly failed. Because a low-voltage 12V jump-pack cannot power or repair broken high-voltage traction lines, the vehicle is suffering from a software-induced safety lockout directly caused by the failed execution of Recall 24S59.This presents an active, extreme safety hazard. A hybrid powertrain suffering from un-remedied module communication failures and high-voltage isolation fault lockouts risks a sudden, unexpected, and catastrophic loss of motive power while operating at highway speeds on public roads.I am filing this report because the manufacturer's official recall remedy has introduced a dangerous, debilitating safety flaw to the vehicle's primary powertrain loop.

I had stopped at an intersection and when I applied the gas, the truck stuttered a bit before going. It ran okay for less than a mile. I stopped at the next intersection and when I applied the gas, the truck shuttered, started to go then just stopped. It stayed running but didn't want to go. I was able to get it through the intersection but that was it. The message i am getting is powertrain malfunction/reduced power. When we put our diagnosis tool on it, we get code P0757.

The driver's side (left front) door failed at the check-arm attachment point inside the door assembly: the spot welds securing the check-arm reinforcement bracket to the inner door structure cracked and separated. The vehicle is a commercial fleet 2022 Ford Maverick XL SuperCrew with approx. 82,000 miles. The vehicle and failed component are available for inspection upon request. First symptoms were difficulty opening and closing the door with popping/cracking noises. No warning lamps or messages occurred; the failure is concealed inside the door. This is a safety risk because the check arm attachment supports the door's structure. The same weld separation on related vehicles has been documented by NHTSA (investigation PE23-013) to cause doors that fail to latch, fail to stay closed, or open while driving, risking occupant ejection and injury. The failure was confirmed 7/17/2026 by Grapevine Collision Center (Grapevine, TX) after a Ford dealership stated there is no recall or warranty coverage for the Maverick and referred me there. The shop diagnosed broken check-arm welds and quoted $2,602.46 for a door shell replacement, noting it has seen this identical failure on Ford Escapes and Lincoln Corsairs. Not inspected by Ford, police, or insurance. This is the same failure mode NHTSA investigated on 2020-2021 Escapes (PE23-013), which Ford addressed via Customer Satisfaction Program 23B56 covering 2020-2023 Escapes. The Maverick shares the same C2 platform and door design but is excluded, leaving owners to pay out of pocket for a defect Ford repairs free on sibling vehicles.

Driving on highway, approximately 65mph when all of a sudden the "door ajar" symbol on instrument panel lit / sound dinged, and the passenger who had their elbow on the door screamed. The passenger side door unlocked and "opened" as in it unlatched. It did not open all the way for her to fall out, but it was no longer fully closed. This is a 2022 vehicle. This happened for the first time in 2026 after 34k miles. There is an active recall for the same make / model but for some reason my VIN is not included. I'm pretty sure it should be after this experience.

I am filing a formal safety defect complaint regarding a severe catastrophic transmission failure on my 2022 Ford Maverick ( 2.0L EcoBoost 8f35 8 speed transmission ) that poses an immediate safety hazard to occupants and sharing traffic. Upon inspection a heavy volume of metal shavings flakes were discovered also the code PO73D unable to engage in neutral came up. The safety risk of this specific failure is extreme because the vehicle is physically unable to respond to a neutral command the driver cannot clear or cut engine power to the drive wheels during an emergency mechanical malfunction or a potential unintended acceleration event. Furthermore because the metal debris the truck exhibits severe erratic shifting behavior and a persistent risk of sudden high speed wheel lockup drivetrain binding or stalling inactive traffic. Ford motor company is fully aware of this component failure despite my vehicle exhibiting the exact failure mode the exact code PO73D and metal debris found has refused financial responsibility I urge the NHTSA to upgrade this known issue to a mandatory safety recall