2022 FORD MAVERICK Complaints

Two issues with my 2022 Hybrid Maverick: First, the brakes are unpredictable. Often in slow moving situations, the brakes fail to engage until I ultimately have to floor the pedal often causing a grinding noise and abrupt stop. Attempts to slowly brake sometime fail. Passengers in truck are thrusted forward when this occurs and I often feel like I am going to rear end someone. Brakes will be assessed next week at my local FORD dealer in conjunction with the engine problem. For a SECOND TIME my ENGINE FAILED WHILE ACCELERATING on 55 mph highway. As I normally accelerated to cross the Choptank River bridge in MD, the engine revved but the car failed to accelerate, the engine malfunction came on and a red box saying to pull over safely. Having experienced this before, I knew I had to get off the highway. I barely made it across two lanes of traffic to pull off to the adjacent fishing pier. I noticed my electric power was a low as my window would barely move. I turned off the car and called my dealer. They advised that I could get a tow or if I felt safe, and the car turned back on, to drive it in even though the malfunction light was still on. So I drove it home Friday night and it goes to the dealer on Monday. However, this engine failure happened to me once before in early December which required a tow in to the dealer. Again, I was normally accelerating on RT.695 when the engine revved but the truck slowed/stopped in a exit/merge area. I did not have enough power to get to the shoulder so I managed to pull over into the small area of the merge/on ramp. At this time my car went into a Deep Sleep, nothing worked. Once towed to the dealer, they assessed my car had an "old" battery in it and replaced it. Guess it wasn't the battery since my engine has failed again. Also, since the first engine failure, my overall gas mileage only averages 35 mpg but before these episodes I averaged 41mpg for 8 months. Feeling VERY UNSAFE in my Maverick now!

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 22V594000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. Parts distribution disconnect.

When driving at low speeds (approximately less than 10 miles an hour) and I depress the brake there is frequently a delay in brake response followed by a sudden jolt when the brakes finally engage.

I know there are issues with the Hybrid versions, but this one is not a hybrid. I have had the battery die 4 separate times resulting in me being stranded due to no fault of my own. This Ford Maverick was purchased through the Military Auto Sales at Ramstein AB Germany. It is US-spec and owned/operated by a US Military member stationed overseas. The first time it happened at the Frankfurt airport after owning it for a week and driving it from the Port of Bremerhaven (port of entry). Once I got it jumped and back to Ramstein I did not have an issue for 3 weeks. It died after sitting for three days over New Years. I jumped it and drove it around for over an hour to charge the battery. I then left it for a few days to see if it occurred again. One week later it died. I then jumped it and drove it around again to charge the battery. At this point I suspected the Ford Pass Connect, bluetooth or wifi to be the cause so I turned all of those off. After going on a work trip for a week I came back to discover it was dead again. Something is wrong with teh battery or electrical system. It should automatically go to a deep sleep mode if lower voltage is detected. I don't know what is running (it is not something the driver selected) but it is killing the battery. The last time my Duracell jump pack registered an error and could not jump it. This is a serious defect that can leave people stranded without warning.

Hybrid Maverick: The brakes grab so abruptly while coming to a stop. It will jerk your upper body forward. Sometimes the brakes won't grab until the very last second. It feels like the transition from Hybrid braking to mechanical braking is lethargic then grabs all of a sudden. In stop and go traffic there is a lack of confidence that the brakes will actually stop you in time. It literally hit or miss. Very dangerous and jarring. It is not something that the driver can get used to through muscle memory. As the driver you have zero control over this action. Anything slow and/or at a downward slope in traffic will make you cringe.

This is a hybrid braking issue where an extreme loud 'clunk' noise which can be felt coming from under the car at low speed less than 10 miles an hour when braking the car. In addition, the brakes seem to not engage properly at stop and go traffic forcing driver to stomp on the brakes to make the car stop. The brakes sometimes won't release after stopping forcing the driver to hit the throttle where the car suddenly lunges forward after the sudden release of the brakes. The Forward Collision warning also comes on unexpectedly without having another car in front of me. Happened twice since ownership of the car. Seems to be common in cold weather.

When I use my remote start option and just put my key in the ignition and start the truck it has a constant burning wire smell. If I come to the truck and turn it off after remote start and just restart it with the key I don't smell the burning wire. If I don't use the remote start option and just start my truck with the key I don't smell the burning wire smell.

When I go to stop the vehicle brakes take longer to catch on to stop the vehicle. This has been an ongoing problem since vehicle pick up March 2022. I drove my truck in the last snow fall we received and when I went to brake it was much worse than in normal conditions. It felt like I slid into the stop and had to push the brakes really hard and my kids heads jerked trying to brake. Clearly is a safety issue. When I was in a drive thru waiting for my food the truck jerked forward and it felt like the transmission was falling out.

My hybrid has an occasional shudder/rattle/vibration noise when the gas engine switches off. Started around 1900 miles on the odometer. Occurs at all speeds with the most noticeable shudder/rattle/vibration noise when stopped. I was worried that the transmission may cease to work and leave me stranded in traffic. There were no errors codes and no warning lights. Has been at the Ford dealer for 26 days as of today with no resolution nor a diagnosis.

When braking at slow speed and almost stopped, the brakes grab hard suddenly and prematurely then lock without pushing the brake pedal any harder. Happens when I'm just slowing to stop. I have not taken the vehicle in for this. I have not had an accident. No one has been hurt. It is a safety risk stopping short of the intended spot. Driver and passengers suddenly getting jerked forward when not prepared. Loud bang or grabbing noise. Could be rear ended due to sudden unplaned braking. Doesn't occur everytime. No dash indicator lights on when this occurs. Brakes release is normal after this occasion. This has happened numerous times since purchase in March 2022.