2020 FORD MUSTANG Complaints

2020 Ford Mustang with the 2.3L EcoBoost engine. The vehicle has a documented history of coolant loss with no visible external leak, consistent with the known coolant-intrusion defect in Ford's 2.3L EcoBoost engines where coolant leaks internally into the cylinders. The vehicle previously threw a cylinder misfire code (P0301) and now shows a crankshaft/camshaft timing correlation fault (P0017). A scan tool confirmed the exhaust camshaft is approximately 18–19 degrees out of correlation. A new variable valve timing oil control solenoid was installed and did NOT resolve the fault, confirming the problem is mechanical — a worn/stretched timing chain. This wear is consistent with the oil dilution and contamination caused by internal coolant intrusion. The problem has been confirmed by an independent service center via scan data. The vehicle is available for inspection. Warning symptoms included the check engine light, a loud rattle on cold startup, and occasional hard/no-start conditions. This is a safety concern because internal coolant loss can cause overheating, cylinder head cracking, and potential engine failure or fire while driving. Repair cost quoted at approximately $2,000. Mileage approximately 54,400.

I suspect an electrical problem/short is causing my passenger side window to open and close about half an inch uncontrollably. This has been a minor inconvenience but last time it happened, it triggered the passenger door to open when driving. I had to pull over to manually secure the door. Very troubling safety issue.

The 10-speed automatic transmission on my 2020 Mustang failed internally at approximately 18,073 miles. The vehicle began shifting harshly at low speeds with an intermittent clunk. While driving, the transmission would slip slightly and then either surge forward or hesitate with a dull thud before engaging. The behavior was unpredictable and worsened over time. No warning lamp ever appeared and no diagnostic trouble codes were stored, so the driver gets no advance notice of this condition. This is a safety hazard when pulling into traffic, turning across an intersection, or merging. When power arrives late, abruptly, or not at all, the driver cannot judge a gap in traffic reliably. An authorized Ford dealer verified the concern on a test drive, confirmed the vehicle failed the CDF clutch cylinder leak test, and documented an internal tapping noise in Drive and Reverse. Fluid level was in spec. The dealer performed Ford TSB 25-2475, which addresses harsh and delayed shifting on this transmission: the unit was removed, torn down on the bench, the CDF cylinder replaced, and the unit reassembled and reinstalled. It did not correct the concern. The dealer's written notes state the concern was still present, the TSB did not cure it, and the transmission has an internal failure requiring replacement. Independent transmission specialists I consulted all recommended full replacement rather than rebuild, citing known problems with this transmission in this model year. Ford has revised multiple technical service bulletins on harsh and delayed shifting for this transmission over several years. My vehicle failed at roughly 18,000 miles, far under the 60,000-mile powertrain warranty limit, but Ford declined assistance because the five-year time limit had passed.

I own a 2020 Ford Mustang EcoBoost with approximately 75,000 miles. My vehicle developed a check engine light with diagnostic codes P0300 (random misfire) and P0301 (cylinder 1 misfire). I also began experiencing white smoke from the exhaust during cold starts. An independent repair shop suspects coolant is entering cylinder 1 due to a possible head gasket failure. They have recommended removing the cylinder head to inspect for cracks, check for warping, pressure test the head, inspect the cylinder walls, and replace the head gasket and related components if no further engine damage is found. The vehicle was properly maintained, and these symptoms appeared unexpectedly.

The contact owns a 2020 Ford Mustang. The contact stated while the vehicle was parked, the contact noticed smoke coming from underneath the hood. The vehicle was unoccupied. The contact inspected the vehicle. The contact stated that the fire was about three inches from the back of the engine, close to the fire wall. The contact used a nearby fire extinguisher and extinguished the fire. The contact stated that upon further inspection of the vehicle, the contact noticed brake fluid on the ground underneath the vehicle. The vehicle was towed to the dealer, however the diagnostic test had not been completed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the failure was a known failure with the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 41,331.

My car has always been a little rough on shifting since around 40k miles when I got it. I never really noticed after awhile and never had any problems. No lights flashing or codes no issues with anything under the hood. The other day my trans light popped on, but nothing was wrong the car was still driving fine. I took it in to get looked at the first shop said no codes were popping up and then I took it to another and they said the whole transmission now needs to be replaced. I went to look around and apparently a lot of people have issues with the transmission on the 2020.

Check engine light came on, car lost power on highway. Car continues to have the same issue after repairs have been made. Ford App says engine misfire, after every repair. Ford mechanics fix spark plugs, coils, electrical. None of which has fixed the issue of stalling on the highway which poses risk of me the driver and others driving on the highway. The only light that comes on is engine light.

My husband was notified via the Ford app that there was an issue with his airbag system. He called the dealership and set up an appointment. We brought in the car to German Ford dealership in Beavercreek on 4 May, where they confirmed that the airbag was bad and needed to be replaced. They confirmed it was the airbag on the drivers side knee. The airbag light did come on, but we were under the impression airbags usually last the lifetime of the vehicle. Thankfully the car warranty covered the replacement, and we just had to pay the deductible. However, had my husband been in a crash that airbag would not have deployed, there is also the chance that the airbag could have deployed randomly while he was driving, which would have caused a potentially fatal crash.

My vehicle would suddenly downshifted to first, constantly seek for gears, loss of traction from not finding gears, and transmission died at 120k miles.

IMRC actuator rod broke causing the air/fuel mix to be sporadic. Creating a misfire on random cylinders. Major loss of power and very jerky motions, causing the vehicle to loose control. Luckily it was on an open spacious road. Unfortunately this has been an ongoing problem and there is nobody selling updated parts the electronics will recognize and very difficult to find oe replacement parts, real costly. And may fix the issue for a short period of time. I have a brand new manifold off of a same totaled mustang since Dec 2025 and the same part broke.