2022 FORD MUSTANG MACH E Complaints

Vehicle stated "PARKING BRAKE FAULT". Driver (myself) discovered electric parking brake was stuck in the ON position and would not disengage. Vehicle could not be moved on its wheels. Vehicle was in parking garage, and driver became stranded for over 24 hours waiting for a low-clearance tow truck with a dolly that could move the vehicle. Ford dealer (Bill Brown Ford) inspected vehicle and discovered wiring immediately behind BOTH rear electric parking brake connectors were corroded and broken. Ford dealer stated there was an active recall for this issue (CSP 22P31 or TSB 22-2143), but that my vehicle's build date was not included. CSP 22P31 only includes build dates before 15 March 2022; Driver's vehicle has a build date of 24 June 2022. Ford dealer stated they repaired the vehicle by completing the procedures defined in recall CSP 22P31, but Ford did not cover the costs or acknoledge it as a recall repair due to the build date. tl;dr: The critical safety defect defined in Ford recall CSP 22P31 affects vehicles built in July 2022, but Ford has not expanded the recall to cover these vehicles. In this case, the corrosion led to DUAL failure of both rear electrical parking brake connectors, causing two exposed electrical circuits and lock-up of the parking brake.

The vehicle’s rear/360 camera system, SYNC/APIM display system, and Reverse Brake Assist/back-over prevention system appear to have malfunctioned. The vehicle is available for inspection upon request. After a software update was performed by the Ford dealer, the vehicle began displaying the warning message: “Reverse Brake Assist not available — See manual.” At the same time, the rear/360 camera image became distorted and unreliable. The camera display has shown abnormal behavior, including distortion, flickering, black/green screen behavior, and an inaccurate or unclear 360-degree view. This issue was not present before the dealer-performed software update. The safety risk is that the rear camera and Reverse Brake Assist are used when backing up to help detect objects, people, vehicles, or obstacles behind the vehicle. Because the camera image is distorted and Reverse Brake Assist is unavailable, the driver may not receive accurate visual information or automatic braking assistance while reversing. This creates a risk of backing into a pedestrian, another vehicle, property, or an unseen object. The problem has not yet been confirmed by a dealer or independent service center after the failure. UNKNOWN whether Ford has reproduced the issue. The vehicle/component has not yet been inspected by the manufacturer, police, insurance representatives, or others after the issue appeared. UNKNOWN whether the issue is caused by the dealer-performed software update, APIM/SYNC software, rear/360 camera module, camera calibration, camera wiring/connection, or another related system. There were warning messages and symptoms after the failure began. The warning message “Reverse Brake Assist not available — See manual” appeared after the dealer-performed software update. The camera distortion and rear/360 camera display malfunction also appeared after the dea

was driving my 2022 Mustang Mach-E in "One-Pedal" Whisper mode on. I always drive in that mode because it has a great feature where as soon as I take my foot off the accelerator the car slows down significantly. I feel safer in this mode especially in high traffic or on the freeway. I was very slowly turning into a parking spot in a private parking lot, stepped on brake to put car into Park when the car lurched forward without me touching anything, I had no control of my car no matter how hard I pressed on the brake. My car was driving itself!! when it lurched forward it hit a car parked directly in front of it on its right front side then pushing that vehicle about 2 feet! it did not stop even then, it veered to the right and forward and hit another parked car in the next parking space to the first car that was hit. My car pushed the 2nd car about 2-3 feet before it stopped almost hitting the car parked next to it!! There was an eye witness. This event scared me to death. It was as if someone else was driving my car. I had absolutely NO CONTROL of it. It would NOT STOP. I am soo grateful this happened in a parking lot and not in fast traffic or God forbid the freeway. I would not get back inside my car and never will. We had it towed to a certified repair shop. My car sustained front end & right side front damage. The first car hit sustained right front damage. The 2nd car hit was parked next to the first car hit and sustained right front & right side passenger door damage. No injury. The repair shop has a certified EV Specialist who is going to read the recorder to see how it malfunctioned. There was a police report but haven't received it as of yet. We contacted Ford where we purchased our car. They told us it would be better once repaired to sell the car ourselves as it could take a very long time for Ford to agree to buy it back my car back! only has $9,000 miles on it!! I hope Ford takes this issue seriously!!!

When starting car the instrument cluster was entirely blank. Center infotainment was functional. Due to use of digital dash in the car there were no warning lights or any information including speed available. It is unknown if any safety/driver assist systems were on or off because the display was non-functional. Issue resolved after performing 1 or more software resets documented across the internet but not documented in the manual. Steps to reset appear to be: 1) Perform a hard reset of the car (hold brake 15 sec, release brake 15 sec, press start without bake). 2) Allow car to fully reset and then turn off. 3) Move far enough away from car to trigger locks and put car into low power mode. 4) Return to car and power on. Hard reset did not provide immediate fix. Sync soft reset did not work.

On December 17, 2022, I purchased a new 2022 Ford Mustang Mach-E, VIN [XXX] -Lewis of Hoover Inc. for $48,665.00. Seven months later, the vehicle suffered a complete loss of drive power at highway speed — a near-serious injury (if not fatal) incident on a vehicle Ford had already identified as defective and subject to recall. In approximately July-August 2023 — seven months after purchase with only approximately 13 miles at purchase — the vehicle lost all drive power while I was driving on the freeway [XXX] ) at [XXX] le stalled completely. I was fortunate no vehicles struck me. The vehicle eventually restarted. I drove directly home and did not continue with my planned out of town trip. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Parking brake malfunction indicated. Ford CSP 22P31 covers repair of the issue for vehichles with a manufacture date before 3/15/22. My vehicle reached the US on 6/22/22. Ford has offered to cover a small part of the repair, but won't include me in the fix due to manufacture date. So Ford ended the program, NEVER FIXED THE ISSUE, and now won't offer to repair my car.

Vehicle shutdown while driving causing total power loss and hitting a parked vehicle. No alerts or notifications were present at the time.

File against: Ford Motor Company Vehicle: 2022 Ford Mustang Mach-E VIN: [XXX] Safety Complaint While driving, the vehicle unexpectedly slowed down, lost power, and became inoperable, creating a serious safety hazard. I was able to pull over safely, but the sudden loss of motive power occurred during active roadway conditions. Dealer diagnosis identified a wiring harness connector failure affecting communication between vehicle control modules. After the repair, the same issue reoccurred within one to two days, again causing loss of power. The vehicle is currently back at the dealership, and the underlying defect has not yet been permanently resolved. This recurring electrical failure represents a loss-of-motive-power safety risk that may indicate a broader wiring harness defect affecting vehicle reliability and safety. Thanks and Regards INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car gave an error in the middle of the trip and displayed 'Stop Safely Now'. Will not start and run after this warning. The extended battery was fully charged before the trip and after 100 miles of driving it showed this message with 54% battery left.

Vehicle: 2022 Ford Mustang Mach-E Mileage at failure: ~36,800 miles Complaint Description: The left rear electronic parking brake (EPB) wiring harness/connector failed, resulting in a parking brake fault and abnormal braking behavior. This component is not a wear-and-tear item and is located in a fixed, protected area of the vehicle. It is not subject to routine maintenance or driver interaction. The failed wiring harness was inspected by an authorized Ford dealership and is available for further inspection upon request. This failure put safety at risk because the electronic parking brake is a safety-critical braking system. The fault created uncertainty regarding proper engagement and release of the parking brake, increasing the risk of unintended vehicle movement when parked and reduced confidence in braking reliability while driving. The problem was confirmed and diagnosed by a Ford dealership, which determined the wiring failure developed over time due to moisture intrusion and corrosion, not misuse, accident damage, or normal wear. The vehicle and component were inspected by an authorized Ford dealership. Ford Motor Company reviewed the repair documentation through Ford Customer Care but did not dispute the diagnosis. The component has not been inspected by police or insurance representatives. A parking brake fault warning message appeared shortly before diagnosis, accompanied by abnormal braking behavior. There were no prior accidents, vehicle modifications, or external damage related to the failure. This failure is identical to a known defect already acknowledged by Ford in Customer Satisfaction Program 22P31, which covers EPB wiring harness connector failures on other 2021–2022 Mustang Mach-E vehicles. Although my VIN was excluded, the same non-wear safety defect occurred within the same model year, indicating a broader safety concern beyond the original VIN population.