2000 FORD RANGER Complaints

THE FRAME ON THE TRUCK IS CRACKED BADLY BEHIND THE CAB ON THE PASSENGER SIDE. THERE IS NOT EXCESSIVE RUST TO JUSTIFY THE CRACKED FRAME. THE TRUCK WAS IN A MINOR ACCIDENT OVER A YEAR AGO AND WAS REPAIRED COMPLETELY. THERE WAS A COMPLETE INSPECTION OF THE WHOLE TRUCK AT THAT TIME AND THERE WAS NO FRAME DAMAGE. THE TRUCK IS MAKING A RATTLING SOUND BEHIND THE CAB AND WE NEED TO MAKE A REPAIR TO FIX THIS BEFORE CONTINUING TO DRIVE IT. WONDERING IF THERE IS A RECALL ON THE 2000 FORD RANGER LIKE THE TOYOTA. *TR

WHILE HOME FROM COLLEGE FOR THE WEEKEND I INVESTIGATED THE SMELL OF GAS MY SON WHO DRIVES THIS EXTENDED CAB RANGER XLT NOTIFIED ME OF. UPON LOOKING UNDERNEATH I NOTICED A SMALL SHINNY SPOT ON THE BOTTOM OF THE TANK WITH NO DRIPS OR RUNS. AFTER RETURNING TO COLLEGE LATER THAT WEEK HE STATED IT WORSENED TO LEAKAGE ON THE GROUND OF DUEL 4" SPOTS, ONE ON EACH SIDE BELOW THE TANK. AFTER VIEWING A PHOTO OF THE BOTTOM OF THE WET TANK I NOTICED DROPS ON THE FORWARD STRAP. I DROVE THE TRUCK TO MY LOCATION THIS PAST WEEKEND AND PULLED THE BED OFF TO ACCESS THE TOP OF THE FUEL PUMP WHICH HAD STANDING FUEL. UPON TURNING THE KEY TO ACTIVATE THE FUEL PUMP I SAW A FINE PINHOLE SIZED STREAM PUMPING FROM THE PLASTIC 90 DEGREE FITTING ON TOP OF THE PUMP. UPON CLOSER INVESTIGATION I NOTICED THIS LEAKING FITTING HAD WHAT APPEARED TO BE ABRASION AT THE OUTSIDE TURN. I WAS ABLE TO OBTAIN A REPLACEMENT FITTING AND REPLACED IT FIXING THE LEAKAGE PROBLEM. THE COST OF THIS REPAIR TO ME WAS THE 8 HOURS VACATION TIME AT $28 PER HOUR I WAS REQUIRED TO USE TO ACCOMPLISH THE REPAIR AND THE COST OF THE NEW FUEL LINE FITTING. THE SERIOUSNESS OF THIS FITTING FAILURE AND MY CONCERN IS THAT IT WILL HAPPEN TO SOMEONE WITH LESS AWARENESS OF THEIR SURROUNDINGS WHILE DRIVING THIS MODEL OF VEHICLE. HAD THIS FAILURE GONE UNDETECTED, IGNORED OR EVEN SPRAYED FUEL ONTO THE ADJACENT HOT EXHAUST THIS WOULD HAVE BEEN TRAGIC. FORD AND THE NHSTA NEEDS TO LOOK INTO FIRST WHAT CAUSES THE DAMAGE TO THESE FITTINGS AND IF REPLACING THIS PLASTIC FITTING WITH A STEEL ONE WOULD BE A WAY TO PREVENT THIS CRITICAL PART FROM BECOMING DAMAGED OR WORN TO THE POINT OF CATASTROPHIC FAILURE. THE REPAIR COST SHOULD BE REIMBURSED TO THE OWNERS OF THESE 2000 FORD RANGERS BY FORD SINCE THIS IS AN UNADVERTISED EXPENSE TO US WHO PURCHASED THESE VEHICLES WITH THIS ENGINEERING DEFECT AT THE TIME OF PURCHASE. *TR

I TOOK THE TRUCK TO HAVE MUFFLER REPLACED AND BEHIND BOTH FRONT WHEELS THE FRAME IS ROTTEN TO THE POINT IT IS NO LONGER SAFE TO DRIVE. 3 YEARS AGO I HAD THE TIE ROD END FALL OUT IN THE DRIVEWAY. THE TRUCK RUNS GREAT, BODY IS STILL SHINY AND IN GOOD SHAPE BUT THE FRAME IS TOTALLY ROTTEN. WHEN THE TRUCK WAS ABOUT 4 YEARS OLD THE OIL PAN ROTTED OUT AND TO REPLACE IT THE MOTOR HAS TO BE PULLED. I MAINTAINED THE TRUCK WELL ONLY TO FIND OUT IT IS JUNK AT 78,000 MILES AND ONLY WORTH JUNK PRICE. SEEM I AM NOT THE ONLY ONE WITH THIS HAPPENING. I HAVE ALWAYS BOUGHT FORD TRUCKS BUT NOT ANYMORE. *TR

THIS TRUCK FRAME IS RUSTING OUT SO BAD THAT THE REAR BUMPER WHERE IT IS ATTACHED TO THE FRAME JUST BROKE OFF ON 3/20/13. I ALSO HAVE A FORD ESCAPE 2001 WITH 160000 MILES AND VERY LITTLE RUST. THIS TRUCK HAS ALSO BEEN GARAGED AND KEPT CLEAN AND WASHED ABOVE AND BELOW.

REAR BUMPER BROKE AWAY FROM THE FRAME. WHEN INVESTIGATING FOUND THE FRAME WHERE THE REAR BUMPER ATTACHES TO AS WELL AS THE SPARE TIRE IS COMPLETELY ROTTED AWAY. EXTERIOR BODY IS IN EXCELLENT SHAPE BUT THE FRAME IS BADLY RUSTED FROM FRONT TO BACK. I AM SCARE TO CONTINUE DRIVING THE VEHICLE OR FEAR OF A CATASTROPHIC FAILURE OF THE FRAME. CAN NOT REPAIR TO REATTACH THE BUMPER BECAUSE THERE IS LITERALLY NO SOUND METAL LEFT ON THE FRAME TO WELD TO. *TR

WAS DRIVING VEHICLE ON HIGHWAY AND HIT A HOLE IN ROAD AND LEFT SIDE OF VEHICLE SANK DOWN FRAME HAD HOLE IN SIDE. *TR

TL* THE CONTACT OWNS A 2000 FORD RANGER. THE CONTACT STATED THAT THE DRIVER FRONT WHEEL SPINDLE FAILED WHILE DRIVING AT 2 MPH. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS CONFIRMED THAT THE WHEEL SPINDLE HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 70,000.

LEFT REAR SPRING SHACKLE SNAPPED FROM FRAME. EXCESSIVE FRAME ROT IN MANY AREAS. VEHICLE MOST LIKELY WILL NOT PASS NEXT STATE INSPECTION. *TR

THIS IS THE SECOND TIME THIS TRUCK HAS FAILED N H STATE INSPECTION FOR FRAME PROBLEMS,FIRST TIME WAS FOR A RUSTED THROUGH CROSS MEMBER WHICH I HAD TO HAVE WELDED,11/17/2009. NOW I GO BACK FOR ANOTHER INSPECTION ON 11/30/2012 AND WAS TOLD I HAD TO REPLACE REAR SHACKLES WHICH I SAY OK,THE REPAIR SHOP CALLS ME AND TELLS ME THE FRAME IS ROTTED THROUGH AND THEY CAN NOT PUT IN THE, FRAME HAS TO BE REPLACED FROM BACK TO ABOUT 4 FEET TO THE FRONT AND AT ANOTHER COST OF 350$ THE LAST COST WAS THE SAME 350$.I TAKE VERY GOOD CARE OF THIS TRUCK AND THE BODY LOOKS LIKE NEW.THE WELDING SHOP GUY TOLD ME HE HAD TO DO SEVERAL OF THESE REPAIRS TO EVEN 2002 FORD TRUCKS,I CAN NOT SEE THE REASON FOR THIS,THIS IS THE FIRST OF ANY CARS OR TRUCKS I HAVE EVER OWNED THAT HAD FRAME PROBLEMS,CAN YOU HELP RECOUP SOME OR ALL OF MY MONEY ON THIS,I AM DISABLED AND ON A FIXED INCOME AND CAN NOT AFFORD TO THROW MONEY OUT THE WINDOW,THANKS FOR YOUR HELP. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHILE DRIVING I HEARD A CLUNKING NOISE IN THE REAR OF THE VEHICLE I LOOKED TO SEE THE FRAME HAD RUSTED THROUGH IN AT LEAST TWO PLACES, THE SHOCK ABSORBER UPPER MOUNT HAD RUSTED OFF. THE GAS TANK STRAPS MOUNTS WERE ABOUT TO FAIL. I HAD REPLACED THE GAS TANK FEEDER TUBE THAT HAD CORRODED OFF THE YEAR BEFORE. THE TRUCK BODY IS STILL IN VERY GOOD CONDITION BUT THE FRAME APPEARS TO BE GONE. THE TRUCK HAS SEEN VERY LIGHT DUTY AND HAS NEVER BEEN USED OFF ROAD. SINCE THAT TIME I HAVE FOUND MANY OF THE SAME OCCURRENCES ON THE INTERNET.