2019 FORD RANGER Complaints

HVAC BLOWER MOTOR NEEDS REPLACED AND EVAP BOX PER FORD DEALERSHIP TODD JUDY FORD. THERE HAS BEEN A PREVIOUS RECALL ON THE SAME MODEL FORD RANGER YEAR 2019. AIR CONDITIONING WORK FINE ON THE PASSENGER VENTS BUT BLOWS OUT HOT AIR ON DRIVERS SIDE. 2 SEPARATE MECHANICS AT INDEPENDENT MECHANIC AND TODD JUDY FORD DEALERSHIP REPORT THERE HAVE BEEN PROBLEMS WITH THE FORD RANGER AIR CONDITIONING AND HEATING SYSTEM REGARDING DUAL TEMPERATURE UNITS. DEALERSHIP REPORTS THAT THIS IS NOT COVERED UNDER WARRANTY AND IS ESTIMATED $3200 IN REPAIR. THE INDEPENDENT MECHANIC IS NOT ABLE TO OBTAIN THE PART AND DISCOVERED THERE WAS A PREVIOUS RECALL ON THIS PART ON THE 2019 FORD RANGER. I HAVE CONTACTED FORD CUSTOMER SERVICE DEPARTMENT AND THEY SPECIFY THAT THIS PART AND FAILURE OF MY 2019 FORD RANGER DOES NOT HAVE MY VEHICLE LISTED UNDER THE RECALL ALTHOUGH IT IS THE SAME MODEL. THE PROBLEM WAS DISCOVERED ON [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford Ranger. The contact stated that while driving at approximately 65 MPH, the vehicle started losing motive power. The check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with an ERG failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact related the failure to the Customer Satisfaction Program: 21M03. The failure mileage was approximately 185,000.

I lose power in my vehicle and the code is saying something about my exhaust not showing the correct air pressure. This is causing my truck to shake and gas and brake pedal to stiffen while driving

There's something wrong with the heater motor or the heater itself. When the heat is on even at the lowest setting the heat is too high. It gets very hot in the vehicle and I have to turn the heat off. The vehicle will fog up when the heater is turned off. There's also a smell like something's burning or overheating and there are clicking noises coming from behind the radio/ heater area. Also If the AC is turned on only the passenger side gets cold, and the driver side blows very hot air. The heat is on even in AC mode, very frustrating.

The contact owns a 2019 Ford Ranger. The contact stated while driving at an undisclosed speed, the air conditioner was activated. The air conditioner made a ticking sound. In addition, the A/C started blowing out hot air. The contact stated that the failure occurred when the temperature was 100 degrees. The contact stated that because of health issues, the air conditioner was required during the heated temperatures. The vehicle was taken to an independent mechanic where it was diagnosed with a failed A/C blower motor. The contact was informed that the A/C blower motor needed to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.

2019 Ford Rangers were shipped without an engine cover to protect the engine from water intrusion.  This, along with the design of the plastic cowl at the base of the windshield being a 2 piece design with a seam directly over the engine bay, allows water to drain into the engine bay during periods of heavy rain. Water will drain from the windshield into the top of the engine, and begin filling the spark plug wells under the ignition coil boots and into the engine head.  This water intrusion can cause engine misfire codes as well as a loss of power while driving, and on multiple instances while merging into traffic, the engine would bog down.  It wasn't until the most recent occurrence that a check engine light came on.  I immediately pulled into a shop and they found the plug wells were rusted, corroded and full of water from this happening since the day it rolled off the lot in 2019.  I have had an independent mechanic assess the damage as well as had the vehicle towed to a local Ford dealer and they found the same condition- with the only solution to replace the engine head as they are unable to remove the plugs due to the damage caused by the water intrusion. An owner should not have to be concerned with parking or driving a vehicle in the rain and whether it will suddenly lose power while driving at highway speeds.  This is a safety issue that Ford should be forced to take care of.  They are aware of the issue and have been as they have issued multiple service bulletins with a solution for misfires to change plugs and install an engine cover.  An engine cover has no bearing on an engine misfire but it shows Ford knows water is getting into engines and causing these problems. Engine/plugs/coils failed, it is available for inspection. Mine and public safety was at risk when driving as it lost power merging into traffic.   Problem has been confirmed by dealer and independent mechanic.   Last instance (2/9/24) was first time a CEL came on while driving

Heater box went out due to a defective heater door. This caused the front windshield to ice over and not being able to see other traffic. No warm air would come out of the vents .Heater box was replaced by the Dealer at the cost to owner.

Known issue with 2019 Ford Rangers where they've issued a safety recall on SOME, but not ALL Rangers in that year. Related to SSM [XXX]: 2019-2020 Ranger - Climate Control Temperature Will Not Adjust With Clicking/Snapping Noise From The Dash - Built On Or Before 30-Jul-2020. Related to recall 19S34. There is an online thread with over 20 pages on [XXX] [XXX] ) where numerous people have reported this issue where one side no longer has A/C. This is dangerous as A/C is required in the winter to help dehumidify the air before it goes across the heater core to defrost the windshield. Ford does not want to issue a recall for all models because it's a labor intensive costly repair to replace the HVAC Distribution Box. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Ford Ranger. The contact stated while driving from a complete stop, the vehicle was jerking, and the transmission was slipping and shifting hard. There was no warning light illuminated. The contact stated that the failure mostly occurred while driving from 0-20 MPH. The vehicle was taken to the dealer, where it was diagnosed, and the dealer determined that the transmission needed to be replaced. The dealer informed the contact the manufacturer was contacted and offered to partially cover the cost of the repair. The vehicle was not repaired. The failure mileage was approximately 67,800.

The steering wheel is loose. I tried to get my truck aligned and was told they weren’t able to do it because of the steering wheel being loose