2019 FORD RANGER Complaints

The contact owns a 2019 Ford Ranger. The contact stated that there was a mixture of fluid and oil inside the rear passenger’s side wheel, and onto the brake calipers and the rear axle. The dealer determined that the passenger's side rear axle seal was leaking. The dealer replaced the passenger's side rear axle seal. Additionally, the contact stated while driving at various speeds, the vehicle jerked and jolted while the transmission skipped from 1st to 3rd gear. The contact also stated that the vehicle hesitated to respond and made an abnormal sound while accelerating and decelerating, and then jolted when shifting into gear. The contact stated that the failure had been recurring more increasingly. The dealer was notified of the failure and an appointment was scheduled for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 68,000.

Transmission is shifting extremely rough, lunges forward or completely disengaged in lower gears. Initially started to happen with cold starts but now continues to happen regardless of the amount of drive time. Completely unsafe when merging into traffic because transmission will either exhibit low power, shift roughly or completely disengage. Transmission has disengaged 5 times so far during initial acceleration. Issue has been confirmed by my Ford dealer. Vehicle is currently being serviced for complete transmission replacement. Dealer has told me that this a frequent complaint that they are experiencing with Ford car owners with the 10R80 transmission.

2019 Ranger went into limp mode in traffic at the worst possible time. Error code appeared and referred to transmission fault at roughly 38k. Was taken to ford and I was told PCM just needed updating. By 45k the transmission was right back to shifting rough with sudden shifts jerking the truck. Called Ford to say hey it’s not right still. It’s continuing to downshift from 10th gear at 65mph instantly down to 3rd gear nearly ripping the transmission out. Every Ford dealership within 3.5hrs from me all told me the same thing. “We are told to say it’s normal for the 10r80 to do hard shifts. Ford knows they are a problem but want issue a recall, the only thing you can do it blow up the transmission while your under 60k warranty so they have no choice but to replace it.” Now at 80k I’m screwed and have to spend nearly 8k to fix the transmission ford said was fine.

My seat belt buckle stopped working (part number KB3Z-2161203-AB) and despite the fact that my truck is less than 5 years old and has less than 60K miles on it Ford's service system says this part is not covered under the 5 year 60K mile Safety Restraint System nor the Premium Care extended warranties I have on the truck. Documentation for the warranties suggests it does but the system the Ford service techs use says no. When I've escalated to Customer Care, they claim "there is nothing they can do." Ford Protect (warranty department) says the same thing. A helpful Ford tech on the internet claims he looked into it and says the problem is that the Ford service system has the part misclassified as a "trim" part and not a "safety" part so it only recognizes it as something covered by the 3 year 36K mile bumper to bumper warranty. When I pressed and they sent me to Ford Financial Assistance for a "Goodwill Repair" I was told they would only cover 40%. I have presented pictures to Ford of their own warranty documentation that clearly states the seat belt buckles are covered and they repeatedly have pushed back saying "there is nothing we can do, it's denied." Bringing it to your attention in the hopes you can help me find the right folks at Ford to remedy this issue as anyone who has a Ford with this same base part number (2161203) is going to have this problem. I'm attaching a copy of the Ford Warranty Safety Section and a copy of the online listing for the Seat Belt Buckle.

THE TRANSMISSION "BUCKING" DURING SPEED ACCELERATION. THIS CAUSES THE VEHICLE TO DE-ACCELERATE BEFORE ACCELERATING TO DESIRE SPEED. PROBLEM: PROGRAMIMG OF THE PCM FOR THE TRANSMISSION. ACCORDING TO THE DATA COLLECTED ON THE FORD FORUM THIS PROBLEM AFFECTS ALL FORD RANGER FOR 2019 MODELS.

The contact owns a 2019 Ford Ranger. The contact stated that while driving at approximately 35 MPH, the vehicle lunged forward while shifting gear. There were no warning lights illuminated. The contact called the local dealer and scheduled an appointment. The vehicle was not yet diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 26,800.

Unintended Aceleration Veheicle experienced normal stop with no anomaly. Upon release of brakes, experienced reported Wide Open Throttle" Brakes were ineffective. Vehicle accelerate thru intersection striking guardrail with significant damage. WOT stopped by shutting of engine. Vehicle currently in repair. Reported event to local dealer service dept, Insurance Rep and Ford referencing 2010 Class Action Lawsuit for similar events, All claim no knowledge of such an event. Vehicle had no previous reports of similar events

My 2019 Ford Ranger for around 9 months occasionally has a significant loss of power and acceleration from 2nd to 3rd gear. It has become dangerous to drive due to the aforementioned. My vehicle has 54019 and is under the factory power train warranty still. The dealership told me that water had entered the EGR and damaged the sensor. They already knew by their diagnostics test it wasn’t a negligence based issue. The dealership told me at least 5 other Ford Rangers have come in with the same problem and Ford will not recall it even tho they know it’s an issue. I called Ford customer satisfaction. They stated although they say powertrain and related parts in their factory warranty and this is affecting the transmission they could not get authorization to fix the known issue. Please investigate this before people get killed.

I had expressed transmission issues with the service center for over a year. Paid for transmission servicing, reprogramming, and kept all maintenance up to date. All regular maintenance has been performed, and the truck has about 80% highway miles, and been cared for and never abused. Now, Ford is telling me, the entire transmission needs to be replaced, at a high cost, and the truck has about 80k miles on it.

I was driving over a bridge at 65 mph on a foggy morning a couple weeks ago and my windshield fogged over. I turned on the defroster and it only blew cold air. I could not see and I couldn't clear it. I had to slow down and find a safe spot to pull over. I had to try to wipe down the windshield and then start driving. It did it again and i had to pull over again and wipe and wait for it to clear to be able to drive. It was foggy the next morning and I had to do the same thing all over again. I stopped by a ford dealer and spoke to someone. He told me, oh yeah we know all about it and so does ford. The ac heater chamber in the dash breaks. Costs about 2 grand to fix. All the new rangers do it. This is a safety defect and needs to be recalled by ford. Thank you.