2000 FORD RANGER Complaints

TL* THE CONTACT OWNS A 2000 FORD RANGER. THE CONTACT STATED THAT THE SEAT BELT STRAP WAS LOOSE AND THE BUCKLE WOULD NOT LOCK. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 00V228001 (SEAT BELTS) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 04/22/14 MA UPDATED 04/24/14

I HAVE A 2000 FORD RANGER 4X4. THE FRAME IS ROTTING AWAY TOWARDS THE BACK END OF THE TRUCK. IN 2011, THE REAR BUMPER WAS FALLING OFF. I HAD TO REMOVE IT BEFORE IT COMPLETELY CAME OFF. I WAS AFRAID IT WOULD FALL OFF WHILE I WAS DRIVING. IN 2008 I TOWED A CAR A COUPLE OF HUNDRED MILES ON THE HIGHWAY. I SHUDDER TO THINK HOW WEAK THAT BUMPER WAS AND WHAT COULD HAVE HAPPENED IF THE CAR I TOWED WAS A BIT HEAVIER. AROUND THE SAME TIME I HAD TO REMOVE THE SPARE TIRE FROM ITS HOLDER UNDER THE TRUCK BED - THE SPARE TIRE AND BRACKETRY WAS SLOWLY SAGGING TO THE GROUND. AGAIN, IT WAS REMOVED BEFORE IT COMPLETELY FELL OFF. MOST RECENTLY BOTH REAR LEAF SPRINGS AND THEIR BRACKETS COMPLETELY RUSTED AWAY FROM THE FRAME. THE WHOLE REAR END OF THE FRAME NEEDS TO BE REPLACED. THIS TRUCK HAS BECOME UNSAFE TO DRIVE - IT ONLY HAS 135,000 OR SO MILES ON IT. THE REST OF THE TRUCK IS IN EXCELLENT CONDITION - NO RUST ON THE BODY. THE ENGINE RUNS FINE. JUST THE REAR 1/4 OR SO OF THE FRAME IS DISINTEGRATING. *TR

I HAVE A 2000 RANGER AND WAS TOLD BY A REPAIR SHOP THAT IS NOT SAFE TO DRIVE DUE TO THE REAR SHACKLES AND LEAF SPRING HANGERS BEING COMPLETELY ROTTED OFF THE FRAME. THE WHOLE REAR FRAME IS ROTTED ALSO AND BARELY HOLDING THE REAR BUMPER ON. I RESEARCHED THIS PROBLEM AND FOUND THAT ALMOST EVERY RANGER LIKE MINE HAS THIS PROBLEM, BOTH OLDER AND NEWER YEARS. THIS ISSUE IS SO BAD THAT AUTO PARTS STORES ARE KEEPING THESE PARTS IN STOCK. THESE TRUCKS ARE NOT SAFE AND SHOULD BE RECALLED ESPECIALLY IN STATES WHICH DO NOT HAVE ANNUAL INSPECTIONS LIKE MINE, MICHIGAN. *TR

REAR RIGHT FRAME RAIL ROTTED OFF OF TRUCK BUMPER SAGGING. RUST INCURSION INTO LEAF SPRING SHACKLE AFFECTING LEAF SPRING MOUNT. *TR

TL* THE CONTACT OWNS A 2000 FORD RANGER. THE CONTACT STATED THAT THE UPPER AND LOWER BALL JOINTS WERE DETERIORATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE UPPER AND LOWER BALL JOINT ON BOTH SIDES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2000 FORD RANGER. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CAUGHT ON FIRE. NO INJURIES WERE REPORTED. THE CONTACT CALLED THE FIRE DEPARTMENT, WHO INSPECTED THE VEHICLE AND STATED THAT THE FIRE WAS CAUSED BY THE CRUISE CONTROL FUNCTION. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2000 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE ENTIRE FRAME WAS CORRODED FROM RUST. THE VEHICLE WAS DAMAGED BEYOND REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

BRAKES FAIL AT SLOW SPEEDS. SOMETIMES THEY WORK, SOME TIMES THEY START WORKING AND QUIT AND THE TRUCK SLIDES. NO ABS LIGHTS COMING ON AND THE ABS DOESN'T PUMP. SLID INTO PARKING CURB STOP, ALMOST STRUCK OREILLY AUTO PARTS BUILDING IN ATCHISON AND JAMMED MY NECK. HAD BRAKES CHECKED, MASTER CYLINDER REPLACED AND BRAKES WERE BLED WITH NEW FLUID. EVERY THING IN GOOD SHAPE, BUT BRAKES ARE STILL FAILING. MECHANIC IN ATCHISON SAID THIS IS THE SECOND RANGER HE SEEN WITH THIS PROBLEM; ON THE OTHER RANGER THEY REMOVED THE ABS FUSE AND BRAKES FUNCTIONED FINE. WAS TOLD THERE WERE NO CODES OR ABS LIGHTS ON VEHICLE UNTIL FUSE WAS PULLED. WITH NO CODES BEING SET, UNABLE TO FIGURE OUT THIS PROBLEM. FORD NOT WILLING TO INSTRUCT AS TO WHAT IS GOING ON WITHOUT CHARGING $80 AN HOUR FOR REPAIRS. HAVE LIMITED INCOME, CAN NOT AFFORD TO TAKE VEHICLE TO FORD. VEHICLE IS DANGEROUS IS GOING TO CAUSE A COLLISION. PLEASE HELP. *TR

NOT REALLY AN INCIDENT, MORE OF A COMPLAINT. WE BOUGHT A 2000 RANGER APPROXIMATELY A YEAR AGO. THE SPARE TIRE WAS MISSING AND WE FOUND OUT WHY. THE SPARE TIRE WINCH ASSEMBLY WAS A BLOCK OF RUST AND THE SHEET METAL THAT MADE UP THE HOLDER THAT THE CARRIER WAS ATTACHED TO IS SO SEVERELY ROTTED THAT IT COULD NOT POSSIBLY EVEN HOLD A TIRE. THE SHEET METAL MENTIONED IS A STRUCTURAL PART OF THE REAR FRAME AND IT HAS MAJOR ROT AND SHOULD PROBABLY BE REPLACED. MY SON NEEDED A SPARE TIRE SO SINCE THERE WAS NO HOLDER HE PUT IT IN THE BED. WHEN HE PUT IT IN THE BED IN BOUNCED TO THE RIGHT AND PUT A LARGE HOLE IN THE SIDE OF THE BED JUST BEHIND THE CAB. WE STARTED TO CHECK OUT THE REST OF THE BED ONLY TO FIND OUT THAT IT WAS SO RUSTED THAT IT WAS LITERALLY STATING TO CRUMBLE IN SPOTS. WHILE CHECKING IT OUT WE PUT SEVERAL MORE HOLES IN THE FLOOR OF THE BED AND THE SIDES JUST BY POKING AROUND WITH A SCREWDRIVER. THE BED IS A STEPSIDE AND THERE IS NO METAL LEFT UNDER THE STEPS AT ALL, IF YOU WERE TO STEP ON EITHER SIDE YOU WOULD CRACK THE FIBERGLASS SIDES. WE ARE NOW IN THE PROCESS OF HAVING TO REPLACE THE BED. ALL OF THE BOLTS HAD TO BE CUT OUT DUE TO THE RUST. ONCE WE GOT THE BED OFF WE WERE SHOCKED TO SEE THAT THE FRAME WAS COVERED TOP TO BOTTOM WITH RUST. I HAVE RESTORED OLDER TRUCKS IN THE PAST SOME FROM THE 40'S AND I HAVE NEVER ENCOUNTERED RUST LIKE I HAVE SEEN ON THIS ONE, IT ALMOST LOOKS LIKE THERE WAS NO PAINT ON IT FROM THE FACTORY AT ALL. WE ARE STILL IN THE PROCESS OF WIRE BRUSHING THE FRAME SO WE CAN SPRAY A RUST CONVERTER AND TRY TO REPAINT THE FRAME. I HAVE READ SEVERAL OTHER COMPLAINTS REGARDING THE RUST ON THESE TRUCKS AND FIRMLY BELIEVE THAT FORD SHOULD BE HELD ACCOUNTABLE JUST LIKE TOYOTA WAS WHEN THEY HAD A SIMILAR SITUATION INVOLVING RUSTED FRAMES ON THEIR TRUCKS. TRUST ME I AM A DIE HARD FORD FAN BUT I BOUGHT THIS FOR MY SON AND I AM VERY DISAPPOINTED. *TR

SAT DOWN IN TRUCK, SEAT BROKE AWAY AND I FELL BACKWARD, NOTED 2 BROKEN BOLTS IN FLOOR, ONE LEFT SIDE ONE RIGHT SIDE,BOTH BOLTS APPEAR TO HAVE FRESHLY BROKEN. REMOVED SEAT TO SEE THE BOLTS WERE FROM THE RECLINER ASSEMBLY, REMOVED THE THREADED PART FROM THE FRAME, THE THREADS APPEARED TO BE APPROXIMATELY 1/4 INCH, ORDERED BOLTS FROM FORD AND REPLACED THE BOLTS FORD PART NUMBER F87Z-1060108-BB, PRICE APPROXIMATELY $40.00, UPON PICKING UP BOLTS ADVISED NO CHARGE. I HAVE MILD BACK STRAIN FROM THE INITIAL FALL BACKWARD. PLEASE NOTE: I AM NOT CONCERNED ABOUT MY INCIDENT, MY CONCERN IS IF I HAD BEEN DRIVING WHAT WOULD HAVE HAPPENED, AND THE NUMBER OF VEHICLES WHICH HAVE THE EXACT SEAT AND POSSIBLE DEFECTIVE BOLTS, IT APPEARS TO BE A DESIGN FLAW, SUCH SMALL BOLTS, I WILL GLADLY FORWARD THE BOLTS REMOVED UPON REQUEST