1991 FORD THUNDERBIRD Complaints

I AM IN A CLUB OF OVER 5,000 OWNERS OF IDENTICAL CARS AND FAILURES HAVE BEEN SEEN AS LOW AS 18,000 MILES TO MY KNOWLEDGE, AND NUMEROUS IN THE 60000 MILE RANGE ON WELL MAINTAINED CARS OF HEADGASKET FAILURE WHICH OFTEN CAUSES COMPLETE ENGINE FAILURE, IN MY CASE IT CAUSED TWO CONNECTING RODS TO FAIL, A CRANKSHAFT BEARING DUE TO OIL CONTAMINATION AND THE CRANKSHAFT AS A RESULT. THIS IS THE THIRD FAILURE ON MY VEHICLE, ONCE I WAS STRANDED ON A DANGEROUS DARK STRETCH OF I-95, ONCE IN THE RAIN AND AS A RESULT OF LOSS OF HEAT (HEADGASKET FAILURE SYMPTOM) I RAN A RED LIGHT AND PROCEDED THE WRONG WAY ON A ONE WAY STREET. *AK

IT LOOKS LIKE DUE TO THE WEIGHT OF THE INDEPENDANT REAR SUSPENSION THE REAR WHEELWELL WELDS AND FLOOR PAN APPEAR TO BE TEARING AWAY FROM THE CAR. *AK

THIS AUTO WAS A LATE BUILD THUNDERBIRD 5-91 IT HAS SOME 92 THUNDERBIRD SYSTEMS INCLUDING RECALLED FUEL LINES OF THE 1992 THUNDERBIRD. *AK

HEAD GASKET BLEWOUT WITH ANY WARNING OR PRIOR PROBLEM. VEHICLE HAS LOW MILEAGE, BUT MANUFACTURER IS NOT COVERING COST. *AK

AIR CONDITIONER GETS A COOLANT-TYPE SMELL AND THEN BEGINS TO BLOW HOT AIR. I HAVE TAKEN IT TO THE DEALER SEVERAL TIMES WITH THE SAME COMPLAINT, THE FIRST TIME BEING IN 1996. MOST OF THE TIME THEY CANNOT FIND ANYTHING WRONG. SOMETIMES, THEY REPLACE "O" RINGS, GASKETS, FREON, ETC. BUT IT STILL DOES NOT SOLVE THE PROBLEM. *AK

ANTIFREEZE IS LEAKING THROUGH OUT EXHAUST SYSTEM CAUSED BY BAD HEAD GASKETS. ENGINE OVERHEATED, BLEW A HEAD GASKET, AND LOST ANTIFREEZE IMMEDIATELY. FORD DEALER IS DENYING ANY PROBLEMS THEY MAY HAVE WITH THE GASKETS.*AK

WINDSHIELD WIPERS FREEZE UP WHEN THEY ARE TURNED ON HIGH. THIS IS A SIMILAR DEFECT TO THE "NHTSA CAMPAIGN ID NUMBER: 91V076000" PROBLEM. *AK

ANTI-LOCK BRAKES AND BRAKE SYSTEM WARNING LIGHTS ON DASHBOARD COME ON. WHEN CONSUMER ATTEMPTS TO SLOW/STOP VEHICLE, THERE IS NO RESISTANCE BEHIND THE BRAKE PEDAL, AND IT GOES TO THE FLOOR. THIS HAS OCCURRED THREE TIMES; AT 15-20 MPH RANGE/ 20-30 MPH RANGE, AND AT 40-50 MPH RANGE. A PRIVATE MECHANIC STATED THAT ON A PREVIOUS VEHICLE WITH SAME DEFECT OCCURRED. THEY RAN A DIAGNOSTIC ON BRAKE SYSTEM AND FOUND NO DEFECTS, BUT REPLACED BRAKE SYSTEM WHICH REPAIRED DEFECT. CONSUMER HAS NOT DETERMINED WHETHER OR NOT HE WILL HAVE THIS DONE. *AK *SLC

ENGINE HEAD GASKETS HAVE BLOWN. DEALER HAS BEEN NOTIFIED.*AK NEW CYLINDER HEAD GASKET WAS INSTALLED AT CONSUMER'S EXPENSE. *YH

DRIVER'S SIDE SEATBELT STOPPED WORKING, CONSUMER IS NOT ABLE TO BE PROPERLY RESTRAINED.*AK