1996 FORD THUNDERBIRD Complaints

1996 FORD THUNDERBIRD 4.6L 281CID V8 MOTOR FAILURE OF PLASTIC INTAKE MANIFOLD. DRIVING HOME UNDER NORMAL CONDITIONS AND CHECK COOLANT LIGHT CAME ON. WIFE SAID SHE HAD THOUGHT SHE SMELLED BURNING COOLANT FOR SEVERAL DAYS PRIOR. TOOK TO MECHANIC AND HE POINTED OUT THE CRACK IN THE INTAKE MANIFOLD. SAID THIS WAS A VERY COMMON PROBLEM WITH THIS MOTOR. PAID OVER $800.00 TO HAVE REPAIRED WITH UPGRADED PART. FORD MOTOR CO. HAS BEEN AWARE OF PROBLEM FOR YEARS AND ISSUED A RECALL FOR TAXIS AND POLICE VEHICLES BUT RECALL DOES NOT COVER PRIVATELY OWNED VEHICLES. CAR HAS APPROXIMATELY 114,000 MILES.

CLIMATE CONTROL MODULE FAILED, AS A RESULT, DEFROSTER AND DEFOGGER FAILED, CAUSING IMPAIRED VISION. *BF THE CONSUMER'S VEHICLE EXHIBITED THE SAME SYMPTOMS STATED IN RECALL 96V-007000, BUT IS NOT INCLUDE IN THE RECALL DUE TO VIN. *NM

I WAS TOLD THAT THEIR IS A RECALL ON MY 1996 FORD THUNDERBIRD FOR A FAULTY INTAKE COOLING MANIFOLD. CAN YOU PLEASE CONFIRM THIS. I DO NOT SEE IT ON YOUR RECALL LIST. *JB

WHILE DRIVING CONSUMER NOTICED SMOKE COMING FROM THE FRONT OF THE VEHICLE. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO A BODY SHOP. MECHANIC DETERMINED THAT THE INTAKE MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. *AK

THE CLIMATE CONTROL MODULE FAILED. AS A RESULT, THE DEFROSTER AND DEFOGGER FAILED, CAUSING IMPAIRED VISION. RECALL 96V007000) WAS ISSUED, HOWEVER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

VEHICLE'S INTAKE MANIFOLD CRACKED ON 1996 FORD THUNDERBIRD.*MR THE VEHICLE INTAKE MANIFOLD FAILED AND WAS REPLACED UNDER RECALL. ABOUT ONE YEAR AFTER THE INTAKE MANIFOLD WAS REPLACED THE CONSUMER STARTED SMELLING ANTIFREEZE INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE SHOP WHERE THE CONSUMER WAS TOLD THAT DROPS OF ANTIFREEZE COULD BE SEEN BY THE WATER PUMP AND THAT IT NEEDED TO BE REPLACED. AFTER IT WAS REPLACED THE CONSUMER CONTINUED TO SMELL ANTIFREEZE. IT WAS LATER DETERMINED THAT THE MANIFOLD CRACKED AGAIN AND THAT THE ANTIFREEZE HAD SOAKED THE FIRST TWO CYLINDERS CAUSING THEM TO MISFIRE. THE CONSUMER WAS RESPONSIBLE FOR REPLACING THIS MANIFOLD. *NM

PROBLEMS WITH THE INTAKE MANIFOLD ON 1996 FORD THUNDERBIRD.*MR THE VEHICLE'S INTAKE MANIFOLD CRACKED. THE MANIFOLD WAS REPLACED, FREE OF CHARGE, WITH ANOTHER PLASTIC MANIFOLD DUE TO A RECALL. APPROXIMATELY A YEAR AFTER THE MANIFOLD WAS REPLACED THE CONSUMER STARTED SMELLING ANTI-FREEZE INSIDE THE VEHICLE. IT WAS LATER DETERMINED THAT MANIFOLD CRACKED AGAIN AND ANTI-FREEZE SOAKED THE FIRST TWO CYLINDERS WHICH CAUSED THEM TO MISFIRE. THE CONSUMER IS SEEKING REIMBURSEMENT. *NM

IN FEBRRUARY 2003, MY 1996 FORD THUNDERBIRD 4.6L STARTED SPEWING WHAT I THOUGHT WAS SMOKE FROM THE ENGINE COMPARTMENT. I WAS JUST AT MY DRIVEWAY AND PULLED IN. AFTER OPENING THE HOOD I REALIZED IT WAS NOT SMOKE BUT COOLANT THAT WAS BEING SPRAYED ALL OVER THE HOT ENGINE. I HAD THE CAR TOWED TO FRIENDLY FORD IN LAS VEGAS, NEVADA, WHERE I HAD BOUGHT THE VEHICLE, AND AFTER SOME DISCUSSION, THEY REPLACED THE INTAKE MANIFOLD UNDER A TSB. ON 6-2-04, SOME 16 MONTHS LATER, THE INTAKE IS AGAIN LEAKING. AFTER DOING SOME RESEARCH, I FOUND THAT THE PART THEY PUT ON THE CAR IS NOT THE RECOMMENDED PART AS STATED IN A LETTER FROM FORD MOTOR COMPANY IN FLINT, MICHIGAN,DATED DECEMBER 2001. THE PART WHICH FORD STATES IS THE REPLACEMENT PART IS F6AZ9424AA. THE PART LISTED ON THE REPAIR INVOICE IS F8AZ8424AAA. THE PART ACTUALLY INSTALLED ON THE CAR HAS A PART NUMBER OF AE9424CA. I TALKED TO THE SERVICE MANAGER, DENNIS EICH, AT FRIENDLY FORD ON 6-22-04, WHO STATED THAT THE PART NUMBER DOESN'T MATTER, THEY DON'T NEED TO INSTALL THE PART RECOMMENDED BY FORD IN THE LETTER, AND BECAUSE THE PART IS OUT OF WARRANTY NOW THEY WON'T FIX IT CORRECTLY. I UNFORTUNATELY AM NOT ALONE IN THIS PROBLEM. MY RESEARCH, VIA THE INTERNET, SHOWS NUMEROUS COMPLAINTS OF THE SAME PROBLEM. THIS IS A MANUFACTURERS DEFECT WHICH SHOULD BE SUBJECT TO A FULL BLOWN RECALL AND FORD SHOULD BE REQUIRED TO REPAIR THE VEHICLES WITH THE RECOMMENDED PARTS.*AK

WHILE DRIVING 40 MPH VEHICLE STALLED. THIS CAUSED LOSS OF STEERING AND BRAKES. VEHICLE WAS TOWED TO THE INDEPENDENT SHOP, AND MECHANIC DID NOT KNOW WHAT WAS WRONG WITH THE VEHICLE. *AK

CAR HAS APPARENTLY HAD A RECALL ON THE PLASTIC INTAKE MANIFOLD FOR 7 YEARS. I HAVE OWNED THE CAR FOR OVER 2 YEARS, BUT HAVE NEVER RECEIVED ANY INFORMATION ON THIS DEFECT. WHILE DRIVING THE CARE APX. 60 MILES FROM MY HOME, MY DAUGHTER AND I WERE LEFT STRANDED WHEN THE INTAKE MANIFOLD STARTED FOUNTAINING WATER AND ANTIFREEZE ALL OVER MY ENGINE. THE CRACK IS BIG ENOUGH THAT NO LIQUID WOULD STAY IN THE CAR, AND I COULD NOT BABY IT HOME. IT TOOK AN ENTIRE DAY STRANDED IN A STRANGE CITY TO FIND SOMEONE WHO WOULD HAUL THE CAR ALL THE WAY TO MY HOME. FORD MOTOR COMPANY WILL NOT HONOR RECALL BECAUSE IT EXPIRED 4 MONTHS PRIOR TO INCIDENT.*AK