1996 FORD THUNDERBIRD Complaints

WITHOUT WARNING, AND AT SPEED, HIGH BEAM HEADLAMPS FAILED LEAVING NO FORWARD VISIBILITY. PREVIOUSLY REPLACED THE COLUMN MOUNTED MULTI-FUNCTION SWITCH TO CORRECT THE SAME PROBLEM. SUSPECT DESIGN/ENGINEERING FLAW WITH SWITCH. *AK

THE PLASTIC FUEL LINE LOCATED ON THE PASSENGER SIDE IN FRONT OF THE RIGHT REAR WHEEL RUBS ON THE UNDERBODY OF THE CAR CAUSING A LARGE FUEL LEAK. THESE PLASIC LINES CONNECT THE METAL LINES FROM THE UNDERBODY TO THE FUEL TANK. I HAVE HEARD OF OTHER THUNDERBIRDS HAVING THIS PROBLEM FROM THE YAHOO THUNDERBIRD CLUB. I HAVE PICTURES I CAN EMAIL TO YOU IF YOU ARE INTERESTED. *AK

TRANSMISSION SLIPS AT TAKEOFF, CAUSING CAR TO STOP IN LANE OF ONCOMING TRAFFIC. *AK

THE VEHICLE STALLS DURING RAIN STORMS, CONSUMER STATED THAT THIS IS A VERY DANGEROUS SITUATION BECAUSE THE SUDDEN LOSS OF POWER CAUSES LOSS OF POWER BRAKES AND POWER STEERING, CONSUMER IS ASKING FOR REIMBURSEMENT FOR REPAIRS. *YH

CLIMATE CONTROL BLOWER SOMETIMES BLOWS ERRACTICALLY ON HIGH, AND SOMETIMES IT DOESN'T BLOW AT ALL. THIS PROBLEM WAS DISCUSSED IN RECALL 96V007000/ MANUFACTURER'S RECALL 95S32. CONSUMER HAS CONTACTED MANUFACTURER REGARDING RECALL. THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO VIN. PLEASE PROVIDE ANY FURTHER DETAILS.*AK

WHEN DRIVING AT 25 MPH AND WITHOUT ANY PRIOR WARNING VEHICLE WILL SHUT COMPLETELY OFF, CAUSING LOSS OF ALL POWER. ALSO, AFTER ATTEMPTING TO RESTART, VEHICLE WILL RESTARTEASILY. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER DETAILS.*AK

HEAD GASKETS FAILED ON 1996 FORD THUNDERBIRD 3.8 LITER, V6 ENGINE. CAR UNDER 5 YEARS OLD WITH LESS THAN 50,000 MILES. FORD WOULD NOT COVER FULL COST OF REPAIR EVEN THOUGH AN EXTENDED WARRANTY HAS BEEN ISSUED FOR THE SAME ENGINE/SAME PROBLEM IN OTHER MODELS.*AK

WHILE DRIVING CONSUMER WENT TO PRESS ON BRAKES AND PEDAL WENT TO FLOOR. BRAKES WOULD NOT STOP VEHICLE.CONTACTED DEALER, AND DEALER STATED HOSE WAS OFF BRAKES. *AK

SHIFT INTERLOCK ENGAGED - TOTAL LOSS OF USE. SHIFT INTERLOCK REQUIRES BYPASS BY TURNING IGNITION TO JUST BEFORE ACC COMES ON, SHIFTING TO NETRUAL, AND STARTING CAR. IF YOU SHIFT TO PARK REQUIRES YOU START PROCESS AGAIN. LOSS OF HIGH MOUNT BRAKE LAMP AND BOTH TAIL LIGHTS. HIGH MOUNT BULBS REPLACED, AS WELL AS THE TAIL LAMP LIGHTS, TO NO AVAIL.*AK

THE FRONT SPRINGS ARE DEFECTIVE AND BREAK THUS COLLASPSING THE STRUTS AND MAKING THE VEHICLE HARD TO HANDLE. THE PLASTIC INTAKE MANIFILD COOLANT CHANNEL WALLS ARE TO THIN AND TEND TO BLOW-OUT. FINALLY, THE BACKLIT REAR REFLECTOR TENDS TO BURNOUT TO OFTER FOR A INTEGRATED PART. THE VEHICLE WILL NOT PASS INSPECTION BECAUSE THE REFLECTOR IS AN INTEGRATED PART OF THE TAIL LIGHT ASSEMBLY. THE COST OF REPLACEMENT IS PROHIBITIVE SO THE REFLCTOR REMAINS BURNED OUT ON MANY OF THE OTHER T-BIRDS I SEE ON THE ROAD CAUSING A PROBLEM WITH THE VEHICLE'S VISIBILITY. THE ILUMENATOR IN THE REFLECTOR SHOULD BE SERVICABLE. *AK