2018 FORD TRANSIT Complaints

I was driving on a rural highway 55 mph when I heard a pop! I lost control and veered into oncoming traffic! I slowed down by tapping brakes and ended up back on the right side in the shoulder/ditch. The shoulder had new gravel so it slowed me down and grabbed a hold of what was left. Found the wheel out in the ditch a good ways from the car and also three lug nuts with bolts still attached and broken at the base in the stretch from the turn off to where the car stopped. Also found my brake pad near a lug nut in the median! Bolts completely broken at the base with lug nuts still attached. Wheel completely fine just not on car. Inside rim gouged out from riding on it after the bolts broke. Found a recall on Ford Transit for the 2019 version of this vehicle for the exact same problem. But since this is a 2018 Ford will not honor it. Cause appears to be a weakness in the alloy used which warps over time and then without warning causing the bolts to brake at the base and separate wheel from vehicle.

The contact owns a 2018 Ford Transit Connect. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted, with the traction and ABS warning lights illuminated. The vehicle was able to be restarted; however, the failure recurred. The contact also stated that while the vehicle was parked, the contact became aware that transmission fluid was leaking from the transmission. The dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 114,000. The VIN was not available.

The contact owns a 2018 Ford Transit. The contact stated that while driving at various speeds, an abnormal squeaking sound would be emitted from the vehicle without warning. The contact stated that the sound went away upon the depression of the brake pedal. Since owning the vehicle, the contact had taken the vehicle to the dealer for an oil change, each time, the contact was informed that both the brake pads and rotors needed to be replaced. The contact stated that the clips needed to keep the brake pads in place fractured approximately 20-50 miles after being replaced. The contact stated that the brake pads and rotors had been replaced several times due to the failure. The manufacturer was notified of the failure and acknowledged the failure; however, no assistance was provided. The vehicle was not repaired. The failure mileage was approximately 160,000.

The transmission is having a shuddering issue, and looking online there on tons and tons of people having the same issue and stating it’s the torque converter and this is over many different years and variants of my vehicle… how is this not a recall yet?? People are having this issue right after purchase?

With this vehicle when driving on highway or interstate once you go past about 40 miles the transmission begins to overheat and when it reaches a temperature of approximately 245° it will kick down into limp mode causing the vehicle to suddenly slow down in front of other traffic. You have to get over to the side of the road and let the transmission cool down before you can continue at a safe pace. This vehicle has been taken multiple times the transmission has been replaced twice. They have replaced the transmission cooler, they have an auxiliary cooler, and the problems still persist. This is very dangerous to be operating when it kicks down tent mode and gears down suddenly. It has been in Fords service shop for over seven months now and we just got it back with the new auxiliary cooler on it and it is still having the same problem.

The contact owns a 2018 Ford Transit. The contact stated while driving at various speeds, the vehicle made an abnormal whistling sound. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where an unknown sensor was replaced, and the check engine warning light was no longer illuminated. Additionally, the contact stated while driving 60 MPH with her husband and 5 children in the vehicle, they all started having severe headaches, were dizzy and her daughter 's ears were ringing. The contact stated that she pulled to the side of the road for a moment. Then she rolled down the windows and drove to the residence. The contact stated that her 5 years old and 8 years old vomited upon arriving at the residence. The contact and her family did not seek medical assistance. The contact stated that they were able to recover after 24 hours. The vehicle was taken to an independent mechanic, where it was diagnosed that the exhaust manifold bolts were fractured, causing carbon monoxide to leak inside the cabin of the vehicle. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that they aware of the failure and that an improved part had been made. The manufacturer referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 110,000.

The contact's company owns a 2018 Ford Transit. The contact stated while driving 60 MPH, the vehicle lost motive power. The contact was able to veer to the side of the road. The vehicle was towed to the tow company mechanic, where it was diagnosed that coolant intrusion in the engine had caused the engine to seize. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact to tow the vehicle to the dealer for diagnostic testing. Additionally, the manufacturer referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 90,000.

The vehicle goes into "limp" mode at random and without warning. The driver loses the ability to accelerate even though the engine remains on. This poses a serious safety risk to the driver, passenger and all other drivers on the highway when the driver has lost mechanical control and has to coast to the side of the road out of traffic. This began happening only after 37,000 miles. The throttle body was replaced, however, this is a reoccurring issue on other vehicles of the same type in my fleet posing a major safety threat to my employees and bystanders.

Hi, I bought this Ford 150 transit brand new back in 2018. About 6 months ago my rear camera is not working properly, sometimes the screen is dark or the view is real fuzzy hard to see cars when backing up. I called Ford corporation to see if this has a recall , but no such luck. They did file a complaint form of the issue. Will let me know when there is a recall. I'm worried that someday i'm going to back up and hit a car or a person, Also i do use this van for work to transport people. Its hard to see with a large full size transit van. I think this should be a recall for these transit vans its decently a safety problem. Please let me know. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

We was going to a week long camp.The individual in the front passenger seat said to the driver that he was not feeling good and told the driver that he was going to take a nap. Before he laid back he looked in the back of the van to check on the kids. As he looked back one kid appeared to be having a seizure. So the driver immediately pulled over. I was following in another van. So I pulled over and went up to the van to see what the issue was and opened the side door. The kids was all hanging there heads sick and vomiting.We hurried and called 911 for help.When the medics got there they informed us of carbon monoxide poisoning. So we took the van to the next town and dropped the van off at the dealership and had to rent another van to go on with our trip. So on our way back home we picked the van back up from the dealership. It was after hours so we called ahead and paid for the repair. They replaced the rear door seal. How ever before we picked it up we purchased a co detector to put in the van. We went a very short distance and the alarm went off. so we had to travel the rest of the way home with the windows down approximately 10 hours. We now have the van at another dealership back closer to home. the dealership is now telling us there is a plug missing under the van and that we need to buy a tail pipe extension that ford has designed to get the exhaust fumes out from under the van. they are also telling us that the vehicle will not pass a state safety inspection with it dumping the exhaust fumes under the van and this will be repaired at our expense. Now my question is if there was not a design flaw why did Ford design a tail pipe extension? Also as i drive down the road I notice all the newer van have an extended tail pipe. Also would the tail pie not be part of the emissions and if it is why would this not be covered by the 8 year 80000 mile emissions warranty? this is a very serious situation. As we talked to a phyishion she said we was minutes from death