2016 FORD TRANSIT Complaints

The contact owns a 2016 Ford Transit. The contact received notification of NHTSA Campaign Number: 19V767000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at various speeds, there was abnormal sound of a lose part underneath the vehicle near the front driver’s side seat and front passenger’s side seat. The dealer was contacted, and it was determined that the failure was related to a driveshaft failure. The manufacturer was made aware of the issue. The failure mileage was 120,000. Parts distribution disconnect.

Instrument panel turns off on and on during driving. No ability to see speed, acceleration, engine heat, fuel, or any lights at all (unable to see warning lights like engine light or airbag or tire pressure and not even able to use blinkers or high lights). Problem occurs during driving (will even turn off and on many times within same driving session) but will also happen while car is sitting just with ignition on. Took to dealer and they couldnt find the problem, told me to (and I quote) “continue driving until it gets worse” so they could find the problem later on. Romano Ford in Fayetteville NY told us to continue using the vehicle while the instrument panels contiously turns off and on, disregarding the safety issues of not being able to monitor anything while driving (speed, heat, fuel, warnings, blinkers or anything!). When we scanned the vehicle for DTCs it comes up as the instrument panel is losing connection to every single module in the vehicle, and they for some reason do not see this as dangerous.

The contact owns a 2016 Ford Transit. The contact received notification of NHTSA Campaign Number: 19V767000 (Power Train). The contact stated while driving 35 MPH, the vehicle began shaking violently. The vehicle was steered to the side of the road and restarted. The vehicle was towed to the office and then towed to a dealer to be diagnosed. The contact was informed that the driveshaft, brakes, and fuel lines needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 142,612.

The contact owns a 2016 Ford Transit Connect. The contact stated that while initially starting the vehicle and while driving at various speeds, the main computer screen displayed the “Hill Stop Assist Not Available" and "Parking Assist Not Available" messages. The check engine and ABS warning lights were illuminated. The speedometer, power steering, and several other unknown messages were displayed intermittently. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to the dealer after the original failure and was diagnosed and determined that the front passenger’s side wheel position sensor had failed and needed to be replaced. The vehicle was taken to an independent mechanic after the second failure, and it was determined that the same front passenger’s and driver’s side wheel position sensors had failed and needed to be replaced. The contact was informed that the steering wheel position sensor had failed and needed to be replaced. The vehicle was not repaired. The manufacturer had not been made aware of the failure. The approximate failure mileage was 70,000.

Going down highway at 70 mph, no power all of a sudden. No warning. Made it to the side, stranded. Transmission needs to be replaced, 83000 miles

The contact owns a 2016 Ford Transit Connect. The contact stated that cracks had formed in both taillights which lead to water accumulation inside the taillight housing. The vehicle was taken to a dealer and the contact was informed that moisture had leaked into the taillight wiring harness and both taillight sensors and sensor harnesses need to be replaced. In addition, the taillight wiring had begun to hang from the rear of the vehicle, causing the exhaust pipe to melt the wiring harness. The dealer informed the contact that the taillight sensor could not be repaired due to the part being on backorder. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 55,000.

My ford van has vibrations between 20-40 miles. Many other ford transits has recalls for this. The issues is with the drive shaft and the drive shaft yoke.

On 17 November, 2023, at approximately 12 PM, I was traveling down the highway at approximately 55 mph. I suddenly heard a loud pop coming from directly under the cab and a subsequent rattling. It lasted for about 15 seconds, went away, and then lasted for another five seconds before completely stopping. Upon parking the vehicle, I crawled underneath and noticed that the flex coupling between the transmission and drive axle was missing two big chunks, and it appeared that a part of that material was lodged into the fire wall above the transmission underneath the floorboard. Also, present was a lot of strands of fiberglass from the coupling material. I immediately searched the Internet for some information regarding this and came upon an active recall that was published in 2019 for certain Ford transits manufactured 2015 to 2017. My vehicle is a 2016 Ford transit 250. It is my belief that this coupling issue that Ford published for recalls was not caught on my vehicle, and I have a concern that my vehicle may have fallen under that safety recall. Would like to know if an inspection could be done and some research to determine if my vehicle, in fact, falls within that recall.

Vehicle goes into "limp" mode while on highway losing the ability to control the acceleration. The van has to coast to a stop, turn off the engine, then restart. The throttle body was replaced twice (3/2/21 and 11/21/22). This causes a major safety risk for the driver, passenger and all other drivers on the road. Losing control of the vehicle mechanically without warning and in such a sporadic fashion is unacceptable at this age and mileage. 170,245 miles & 219,118 miles.

Freeway driving at rush hour, engine light came on suddenly, no other previous warning, with catastrophic engine failure, pull over immediately. I was able to coast to shoulder. No injuries. Could have caused an accident. Van is now at dealer, diagnosis unknown.