2018 FORD TRANSIT Complaints

LOUD NOISE W/VIBRATION AND FOUL ODOR COMING FROM HEATER BLOWER. DEALERSHIP DISCOVERED A RODENT'S NEST IN THE CLIMATE CONTROL BLOWER MOTOR. DEALERSHIP INDICATED THAT THERE IS NO REMEDY TO PREVENT RECURRENCE. DEALERSHIP ALSO MENTIONED THAT THE FORD ESCAPE HAS A HISTORY OF THE SAME PROBLEM. SEE FORD'S TSB 17-0034, PUBLISHED 3/21/17 RE FORD'S RECOMMENDED PREVENTION: "...INSTALL THE NEW INLET DUCT GASKET WITH SCREEN..." (EMPHASIS ADDED).

REGARDING 2018 FORD TRANSIT XLT 15 PASSENGER WITH ECOBOOST ENGINE. THE FACTORY INSTALLED AIR CONDITIONING SYSTEM DOES NOT HAVE THE CAPACITY TO COOL DOWN THE VAN'S CABIN, IN SOUTHERN STATES LIKE SOUTH FLORIDA, WHERE THE AMBIENT TEMPERATURE REACHES 85+ DEGREES FAHRENHEIT DURING A SUNNY DAY THROUGH MOST OF THE YEAR, THE VEHICLE'S A/C SYSTEM SIMPLY FAILS TO PROPERLY COOL DOWN THE CABIN. SEVERAL CASES HAVE BEEN OPENED WITH FORD MOTOR COMPANY, AND THE SERVICE DEPARTMENT AT THE FORD DEALERSHIPS FAIL TO EVEN ACKNOWLEDGE THE PROBLEM. THEY RUN THEIR DIAGNOSTICS TOOLS, AND ALL THE COMPONENTS ON THE SYSTEM ARE WORKING AS INTENDED, EXCEPT THAT IT DOES NOT PROVIDES SUFFICIENT COLD AIR TO MAKE THE PASSENGERS SAFELY AND COMFORTABLY RIDE THE VAN. UN FORTUNATELY, THIS IS AN ISSUE THAT THE OWNERS DON'T DISCOVER UNTIL AFTER THEY HAVE PURCHASED THE VEHICLE AND DRIVEN IT FOR A WHILE. FORD IS NOT PROVIDING ANY SOLUTION WHATSOEVER TO THE PROBLEM. AND THIS ISSUE MAY BE AFFECTING ALL OWNERS OF THE SAME VEHICLE WITH SIMILAR TRIMS AND SPECS. ADDITIONAL TESTING AND CERTIFICATION OF THE ISSUE BY INDEPENDENT CERTIFIED VEHICLE A/C TECHNICIANS AND ENGINEERS ARE BEING GATHERED. FURTHER LEGAL ACTION MAY FOLLOW.

TL* THE CONTACT OWNS A 2018 FORD TRANSIT. WHEN IT RAINED, WATER LEAKED INSIDE THE ENGINE COMPARTMENT AND DAMAGED THE COMPONENTS. WHEN THE CONTACT STARTED THE VEHICLE, HE HEARD AN ABNORMAL KNOCKING NOISE. THE CONTACT ALSO NOTICED THAT THE SEPARATOR FROM THE TOP OF THE HOOD TO THE WINDSHIELD HAD SEPARATED, ALLOWING WATER TO FLOW INTO THE ENGINE COMPARTMENT. THE CONTACT EVEN NOTICED THAT THE ROOF INSIDE THE DRIVER'S SIDE OF THE VEHICLE WAS WET AND THERE WAS WATER ON THE FLOOR. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 32,000.

CHECK ENGINE LIGHT TURNED ON AND ENDED UP BEING MALFUNCTIONING CATYLYTIC CONVERTER. FORD TRANSIT ECOBOOST 3.5 350XLT 21000 MILES APPROX. NOT SURE WHY OR HOW BUT FORD DEALERSHIP REPLACING PARTS.

1. RAIN SENSING WIPERS WORK INTERMITTENTLY BARELY WHEN DRIVING. TOLD BY SALES MANAGER THAT "THEY WORK BUT IT ISN'T A PERFECT SYSTEM" 2. A.M. LIMITED RECEPTION IN WIDE OPEN AREAS IN MULTIPLE LARGE POPULATION AREAS. SITTING OR DRIVING BOTH. TRIED TO USE FOR 530 A.M. ROAD INFORMATION & WOULDN'T WORK. 3. BODY ROOF SEAL CAME LOOSE FROM ROOF DRIVING HOME IN COLD WEATHER. 4. TIRE PRESSURE SENSOR FAULT GOES OFF AND ON WHILE DRIVING. 5. SEAT BELT HEIGHT ADJUSTMENT TAB ON FRONT PASSENGER SIDE FELL OFF. NOT COVERED BY FORD BECAUSE IT IS PLASTIC. 6. CUSTOMER CONNECTION POWER POINT ON DRIVERS SEAT PEDESTAL MISSING A MOUNTING NUT FROM FACTORY. WE HAVE BEEN TOLD THAT THE POWER POINT IS NOT FACTORY BECAUSE WE CONNECTED INTO THE PORT AS IT WAS DESIGNED FOR. STUD THREADS ARE STILL UNMARKED (NEW). THIS ALLOWS THE LOWER SECTION OF CCP TO BE SLIGHTLY LOOSE. 7. AC VENTS ON MAX BLOWING OUT 65-70 DEGREE AIR AT IDLE IN 80 DEGREE OUTSIDE AMBIENT TEMP. (KNOWN ISSUE) 8. OVERHEAD A/C LOUVERED VENTS ARE BREAKING INTERNALLY WHEN ADJUSTED. ONE ENTIRE VENT FELL OUT WHILE DRIVING DOWN THE ROAD ONTO MY CHILD'S HEAD WHO COULDN'T TOUCH IT. NOT COVERED BECAUSE THEY BROKE BUT THEY AREN'T A MECHANICAL FAILURE. DAUGHTER HAD SCRATCH ON HER FOREHEAD WHERE IT HIT HER. 10. OPENED UP HEADLAMP LENS TO UPGRADE THE LIGHTS AND THE LOW BEAM PIG TAIL ON BOTH LIGHTS ARE ALREADY DETERIORATING FROM THE LENS HEAT. LIGHTLY TOUCHED EACH OF THE LOCKING CLIPS AND WITHOUT LIFTING EITHER ONE AND THEY FELL OFF. HIGH BEAM WHICH ARE USED MUCH LESS HAVE PERFECT LOCKING TABS STILL. REQUIRED TO MAINTAIN CONTINUITY TO THESE LIGHTS. 11. LAST WEEK A PLUG IN THE DRIVERS DOOR THRESHOLD OVER FRAME BOLT TRIPPED ME WHEN IT CAME UP AS I WAS STEPPING OUT. SECOND TO FALL OUT. ALL THIS TOLD TO US UNDER THE 36K BUMPER TO BUMPER YET DEALER IS WILLING TO CHARGE ME FOR THE DEFECTIVE PARTS.

REAR BRAKES AND TIRES FOR TWO OF OUR 2018 FORD TRANSIT VEHICLES ARE NEEDING TO BE REPLACED WITH LESS THAN 10,000 MILES ON THE VEHICLES. WE ALSO SEEN THIS OCCUR WITH ONE OF OUR 2016 FORD TRANSIT -- REAR BRAKES HAVE BEEN REPLACED TWICE WITHIN 32,000

AT INTERSTATE SPEEDS OF 75 MPH WITH A 30 DEGREE CROSSWIND AND GUSTS EXCEEDING 40 MPH, THE FRONT DOOR ON THE LEE SIDE FLEXES AND THE TOP OF THE DOOR OPENS. THIS DEFORMATION OF THE DOOR INDICATES A POTENTIAL FOR THE WARPING OF DOORS OVER TIME OR IN THE WORSE CASE, THE DOOR COMPLETELY OPENING TO THE DETRIMENT OF DRIVER AND PASSENGERS. TRAVELING NORTH WITH GUSTY WINDS FROM THE SOUTHWEST THE PASSENGER FRONT DOOR FLEXED OPEN AND TRAVELING SOUTH WITH A GUSTY SOUTHWEST WINDS THE DRIVER DOOR FLEXED OPEN. (OCCURRED FEBRUARY 2019 ON A SUNDAY)

I OWN THIS CAR 3 MONTHS, AND 2 WEEKS AGO MY WILL HAB IN RATE SAIDE WAS BROKE AND AFTER 2 WEEKS MY LEFT SIDE BROKE, SO DENGER IF IS WILL GO OUT IN ROAD . PROBLEM IS MY TOO FRIEND HAVE SAME TROUBLE.

BATTERY KEPT DRAINING-FOUND OUT 2 BATTERIES UNDER THE DRIVER'S SEAT AND THE FUEL IS PUT IN AT THE DRIVER'S SEAT DOOR. THE DOOR MUST STAY OPENED DURING FUELING. ALSO, THE BATTERY DRAINING AND NUMEROUS REPLACEMENTS FOUND DUE TO INCORRECT WIRING AGAIN. THIS IS A CONVERSION VAN BY EXPLORER, AND WE'VE ALREADY HAD ANTIFREEZE LEAKAGE WHICH IS STILL A PROBLEM WITH THE SMELL. THE VEHICLE IS STILL AT REPAIR SHOP IN MILLERSVILLE FOR ANOTHER MONTH. MVA INVESTIGATOR KEVIN CHUBB DIRECTED US TO INVESTIGATE THIS FUEL SYSTEM AND BATTERY SYSTEM PLACEMENT FOR INSPECTION. HE FELT AS WE DID THAT IT IS A HEALTH AND SAFETY HAZARD.

HAVE TAKEN OUR VEHICLE TO FORD AT LEAST 12 TIMES AND HAVE THE EXTENDED WARRANTY, THEY HAVE SAID NOTHING IS WRONG WITH IT. WE BOUGHT BRAND NEW AND HAVE THREE SETS OF BRAKE PAD PLACED ON THE FRON AND TWO PAIRS ON THE REARS.. WE HAVE GONE THROUGH TWO SETS OF TIRES AND THE FRONT DRIVERS SIDE IS CLICKING... FORD HAS SAID THERE IS NOTHING WRONG.. NOT SURE WHAT ELSE TO DO BUT THE VEHICLE DOESN'T WANT TO STOP AND THE TIRES OR THE ONE ON THE FRONT IS COMPLETELY BALD AND THE VEHICLE ONLY HAS 15,000 MILES ON IT