2015 FORD TRANSIT CONNECT Complaints

The contact owns a 2015 Ford Transit Connect. The contact stated that while attempting to close the driver's side door, the door failed to latch securely. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V502000 (Latches/Locks/Linkage). The VIN was included but parts were not yet available. The manufacturer was not notified of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2015 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 23V502000 (Latches/Locks/Linkages) however, the part to do the repair was unavailable. The contact stated that when he went to shut the driver's side door during the morning start of the vehicle, the door would not close and lock. The contact drove the vehicle to a dealer who advised that they had not been authorized to perform a repair by the manufacturer. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 151,000. VIN tool confirms parts not yet available.

The contact owns a 2015 Ford Transit Connect. The contact stated while driving at an undisclosed speed and turning into a parking lot, the front driver's side door inadvertently opened. The contact stated that the failure had been recurring while driving. The contact stated that he had applied tape to the door to keep the door closed. The contact later received notification of NHTSA Campaign Number: 23V502000 (Latches/Locks/Linkages) however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed nor repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 134,100. VIN tool confirms parts not available.

The detent designed to hold the passenger side sliding door open has malfunctioned due to what the dealership describes as a manufacturing defect commonly found in the 2015 Ford Transit Connect XLT/LWB. Dealer states dealer is unable to correct. When parked on an incline, the sliding door can violently slide forward with a significant potential for injury to a passenger, especially a young child, entering or exiting the vehicle. Dealer suggests taking the vehicle to a body shop to correct this defect at owner's expense.

2015 Ford transit connect 150: while driving on the freeway 60-65 mph, the brakes seem to lock up without depressing the pedal, slowing to 40 mph and shaking uncontrollably. putting on the brake to exit the flow of traffic, braking caused the vehicle to shake even more finally by pumping the accelerator, the speed increased again. finally getting off of the freeway the brake pedal went to the floor. i had to pump the brake pedal until it finally reacted. less than a week later, getting on the freeway almost the exact thing happened. luckily i was a bit more prepared when i felt the shaking. today, driving the van back to our warehouse approx 15 miles on regular streets (not freeway driving) the brakes again went to the floor. master cylinder not leaking, brakes seem to be in good shape...but something is wrong we brought the vehicle to Sawgrass Ford in Sunrise Florida. they had it for over a month. they were unable to determine the problem and only made suggestions to completely change out all the brake components for $5-$6,000.00 but also said that they could not guarantee that this would fix the problem. the brakes were serviced approximately 6-7 months prior to these incidents I called Corporate Ford office. was told that the 2016 ford transit connect had Brake Hydrolic Control Unit recalls, but the 2015 doesn't have the recall listed. I also looking on manywebsites to verify any other2015/2016 problems with the brakes "locking up" or vehicle going into safe mode (another possibility) there were numerous complaints and concerns regarding 2016 & even 2017 situations very similar to what i went through. ford told me that model DV6Z2C405D BRAKE HYDROLIC CONTROL UNIT did not have an official recall. but that Ford stopped using that model and started using model EK4Z2C405A which was recalled and then replaced the recall with FK4Z2C405C. Seems like there may have been a problem with the 2015 model which caused the to change and with the 2016 model as well

The vehicle receives a considerable amount of water through the windshield when it rains (it can be more than a liter depends of the time on the road) it runs down through the glass and also falls on the dash. It can cause visibility problems while driving because the water run on the the driver's side of the glass too.

Steering knuckle developed a crack through what appears to be defective casting of the part. Crack was noticed prior to separation of steering assembly. This could have created and extreme hazard if not noticed prior to total failure.

The fuse associated with the rearview camera of this vehicle has consistently blown over the last few years leaving the backup camera inoperable with no image on the dashboard display. The lack of a functioning backup camera results in the loss of a view directly behind the vehicle which could result in an accident. A warning stating that "rear view camera is unavailable" and a dark display occur when the fuse is blown. The rearview camera fuse blows often typically only after a few vehicle trips. After diagnosing the blown fuse issue, chafing of a wiring harness was found behind a grommet where wires pass between the vehicle body and the rear liftgate. The damaged wiring harness is in the vehicle and available for inspection. This issue has also been documented by others as was discovered by searching for information on the internet.

The steering rack is not moving freely. Struts, tie rods and U joint are moving freezing but the steering rack is not. This is a huge safety concern because if the steering rack were to lock up and then allow me, the driver, to turn the wheel, that would absolutely cause me to crash. My local automotive service has diagnosed the problem

The contact owns a 2015 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 16V643000 (Latches/Locks/Linkages) and 21V376000 (Power Train). The contact stated that while reversing the vehicle, the gear shifter seized and the vehicle rolled forward, crashing into a brick wall and damaging the front driver side. The failure recurred after the contact had unloaded the vehicle and the emergency brake was engaged. The contact disengaged the emergency brake and tried to shift gear when the gear shifter seized and the vehicle rolled down the driveway. The contact had to reapply the emergency brake to stop the vehicle. The contact was awaiting a tow. The rear passenger sliding door would also detach from the sliding base. The dealer was made aware of the failure and scheduled an upcoming appointment. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 115,000.