2016 FORD TRANSIT CONNECT Complaints

The contact owns a 2016 Ford Transit Connect. The contact stated that the ABS warning light was illuminated. The contact stated while driving at undisclosed speeds, the vehicle stalled. There was smoke coming from the rear of the vehicle. The vehicle was taken to an independent mechanic, who determined that the brakes and calipers needed to be replaced. While the mechanic was test driving the vehicle, the vehicle stalled. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact called another local dealer, Wayne Ford (444 US-46, Wayne, NJ 07470); but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 33,000.

The vehicles front driver side wheel brakes keeps receiving too much pressure causing the brake pads to stick and the wheel to get hot and to shake the steering wheel. I have had the caliper replaced twice, the flex bake hose replaced as well, replaced brake pads and rotor and after the most recent diagnosis, I was told that the issue is the HCU. Ford has had issues with this model and you can see under campaigns 16C10/16V482 where this exact issues was happening was being experienced. I believe that they failed to fix the issue when they produced the car I have and are refusing to fix it. When I first experienced the issue my rotor was smoking and the wheel was extremely hot which is an extreme hazard that ford should be made responsible for.

The contact owns a 2016 Ford Transit Connect. The contact stated while driving 65 MPH, the transmission downshifted to 1st gear without warning. The contact continued driving and while coming to a stop light the failure recurred. The contact attempted to accelerate when the light turned green, and the vehicle inadvertently shifted into neutral, and the contact nearly crashed into another vehicle. The contact pulled the vehicle over at a gas station and had the vehicle towed to a local dealer where the cable shifter bushing was replaced. The vehicle was repaired. The manufacturer was notified of the failure; however, no assistance was provided. The failure mileage was approximately 80,000.

The contact owns a 2016 Ford Transit Connect. The contact stated that while her husband was operating the vehicle, the front driver side door failed to shut closed. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed that the door latch needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V502000 (Latches/Locks/Linkages). The dealer informed the contact that the recall was expired. The manufacturer was made aware of the failure and confirmed that the recall had expired. The failure mileage was approximately 200,000.

While driving on the highway, the Panoramic Roof Window started lifting up along the leading edge of the glass panel. I was to slow down and get off the highway before the panel came completely out of the recessed window frame. Ford has told me that my VIN shows the recall repair on the roof was performed already by Ford for a previous owner. A local Ford dealership looked into redoing the repair under a replacement warrenty, but was told it is not covered because the recall work was down more than 2 years ago. This seems a problem to me. The panoramic window is a fixed glass pane. Recall repair for this should last for the life of the car, not two years. I beleive the repair of the window does not actually solve the documented recall problem effectively.

Ford Transit Connect passenger van with a panoramic view roof window. Driving on the highway, when air starting rushing into the cabin via the glass roof. I was able to pull over before the whole panel blew off. The Front (leading) edge of the glass roof panel is now loose. I can push up on the glass panel and the front edge comes up at least a 1/2 inch now. Ford has a recall listed on the roof panel aleady, but they say my car is not covered by the recall. Campaign/NHTSA# 20S22/20V260 Issue Date 2020-05-08 Description On your vehicle, the panoramic roof glass panel may not be properly bonded to the vehicle, which may result in wind noise, water leaks, and in some cases, separation from the vehicle. Safety Risk This may result in separation of the entire panoramic roof panel from the vehicle while driving increasing the risk of a crash or injury. Remedy Parts are now available to repair your vehicles. Ford Motor Company has authorized your dealer to remove, clean, and reinstall the panoramic roof glass free of charge (parts and labor).

The contact owns a 2016 Ford Transit Connect. The contact stated that while driving 65 MPH, the vehicle lost motive power. The accelerator pedal was depressed but the vehicle was slow to move. The engine HOT message was displayed. There was an unknown running sound detected. The vehicle was towed to an independent mechanic, and an unknown repair was performed. The vehicle was towed to the local dealer, where it was diagnosed that water had leaked into the engine from the front windshield. The vehicle was repaired. Additionally, the contact stated that the window was replaced but was installed incorrectly. The weather strip was detached. The manufacturer was contacted, and informed the contact that there was no warranty coverage on the vehicle. The failure mileage was approximately 73,000.

The contact owns a 2016 Ford Transit Connect. The contact stated that while initially starting the vehicle and while driving at various speeds, the main computer screen displayed the “Hill Stop Assist Not Available" and "Parking Assist Not Available" messages. The check engine and ABS warning lights were illuminated. The speedometer, power steering, and several other unknown messages were displayed intermittently. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to the dealer after the original failure and was diagnosed and determined that the front passenger’s side wheel position sensor had failed and needed to be replaced. The vehicle was taken to an independent mechanic after the second failure, and it was determined that the same front passenger’s and driver’s side wheel position sensors had failed and needed to be replaced. The contact was informed that the steering wheel position sensor had failed and needed to be replaced. The vehicle was not repaired. The manufacturer had not been made aware of the failure. The approximate failure mileage was 70,000.

Going down highway at 70 mph, no power all of a sudden. No warning. Made it to the side, stranded. Transmission needs to be replaced, 83000 miles

The contact owns a 2016 Ford Transit Connect. The contact stated that cracks had formed in both taillights which lead to water accumulation inside the taillight housing. The vehicle was taken to a dealer and the contact was informed that moisture had leaked into the taillight wiring harness and both taillight sensors and sensor harnesses need to be replaced. In addition, the taillight wiring had begun to hang from the rear of the vehicle, causing the exhaust pipe to melt the wiring harness. The dealer informed the contact that the taillight sensor could not be repaired due to the part being on backorder. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 55,000.