1996 FORD WINDSTAR Complaints

WHILE PARKED, A 1996 FORD WINDSTAR CAUGHT FIRE DUE TO A DEFECTIVE SPEED CONTROL DISCONNECTION SWITCH. *JB

I HAVE A 3.8 ENGINE THAT HAS HAD TO HAVE HEADS REPAIRED/REPLACED 3 TIMES. THE LAST TIME THE ENGINE NOW REQUIRES REPLACING, IT HAS BEEN AT GARAGE FOR 2 YEARS. DUE TO COST INVOLVED IT IS NOT COST EFFECTIVE RO REPAIR. IT HAS OVERHEATED IN ALL CASES AND THE SECOND TIME IT WAS DETERMINED THAT A FAULTY FORD WATER PUMP MAY HAVE BEEN CAUSE. I HAVE NOTIFIED FORD AND DEALER MULTIPLE TIMES WITHOUT RESPONSE. *NM

DT*: THE CONTACT STATED WHILE PARKED IN A DRIVEWAY, THE VEHICLE WAS STARTED UP, AND SMOKE WAS NOTICED COMING FROM UNDER THE HOOD. THE VEHICLE WAS SHUT OFF, THE HOOD WAS OPENED, AND THE CONTACT NOTICED THE WIRES LOCATED BELOW THE MASTER CYLINDER HAD MELTED. THERE WERE NO LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AND NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO DETERMINED THAT THE VEHICLE SHOULD HAVE BEEN PART OF A RECALL. THERE WERE NO RECALLS ON THE VEHICLE. THE CONTACT PLANNED TO CONTACT THE MANUFACTURER AFTER FILING A COMPLAINT WITH THE NHTSA. *AK

THE 1996 FORD WINDSTAR HAS A FUEL TANK ON IT THAT IS IDENTICAL TO THE 1995 FORD WINDSTAR. THE 1995 WAS RECALLED FOR A LEAK ON THE UPPER PORTION OF THE TANK. THE 1996 VERSION WAS NOT RECALLED. MY 1996 LEAKS SAME PLACE AS THE 1995 RECALLED VERSION. DANGEROUS FUEL CAN SEEP DOWN TANK AND DRIP ON EXHAUST SYSTEM OR OTHER COMPONENTS TO CAUSE FIRE OR EXPLOSION. FORD DOES NOT WANT TO REPLACE TANK ON 1996. NOTHING WAS DONE BY FORD TO CORRECT THIS PROBLEM. *NM

HEAD GASKET FOR 3.8L V6 FORD ENGINE IS DEFECTIVE. FORD RECOGNIZES THIS FOR PREVIOUS MODEL YEARS (1994-1995), BUT DOES NOT FOR MY MODEL. FORD HAS TSB FOR THIS PROBLEM FOR THEIR DEALERS AND SERVICE CENTERS, AS IT IS A COMMON PROBLEM FOR THE 1996 - AND 3.8L ENGINES OF THAT TIME ACROSS THEIR PRODUCT LINE ACCORDING TO CENTER FOR AUTO SAFETY, THIS IS A PART THAT SHOULD NEVER NEED CHANGING. FURTHERMORE, ACCORDING TO A FORD DEALER SERVICE MANAGER, FORD AT 7 YEARS AND 78K MILES DO NOT WANT TO REPAIR THE DEFECT. THE DEALER I BOUGHT THIS VEHICLE FROM DID NOT DISCLOSE THAT THIS CAR WAS PAST ANY DEFECT RECALL AND WAS PAST TIME TO TAKE ACTION WITH FORD. (THERE IS ANOTHER ISSUE WITH THEIR CLIMATE CONTROLS ON THIS MINIVAN AS WELL, AS THEY CEASED TO FUNCTION - AND THAT IS ANOTHER ITEM THAT SHOULD NOT FAIL UNLESS DEFECTIVE.) IN ANY CASE, THE HEAD GASKET IS VERY EXPENSIVE TO REPAIR/REPLACE, AND SHOULD NOT NEED TO BE REPLACED DURING THE LIFETIME OF A VEHICLE. *JB

DT*: THE CONTACT STATED WHILE DRIVING 15MPH, THERE WAS A LOUD POPPING NOISE FOLLOWED BY A HISSING SOUND. THE VEHICLE WAS PARKED IN THE DRIVEWAY FOR FURTHER INSPECTION. THE ODOR OF SMOKE WAS PRESENT, THE CONTACT AND PASSENGERS EXITED THE VEHICLE IMMEDIATELY. FLAMES WERE VISIBLE FROM THE FRONT UNDER HOOD AREA. THE FLAMES PRIMARILY SURROUNDED THE TOP OF THE TRANSMISSION AND MASTER CYLINDER. THE CONTACT EXTINGUISHED THE FLAMES WITH A FIRE EXTINGUISHER. NO INJURIES WERE SUSTAINED, BUT THE VEHICLE SUSTAINED MODERATE FIRE DAMAGE. THE POLICE WERE NOT ALERTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE FIRE ORIGINATED FROM THE MASTER CYLINDER. THE MANUFACTURER WAS ALERTED. THERE WAS A NHTSA RECALL, # 05V38800, REGARDING THE VEHICLE SPEED CONTROL. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

I HAVE FORD WINDSTAR,96. WHEN I FILLED UP GAS IN THE TANK,IT STARTED LEAKING AND IS CONTINUOUSLY LEAKING. IT SEEMS THAT IT IS LEAKING FROM THE TANK. *NM

DT*: THE CONTACT STATED A PUDDLE WAS OBSERVED UNDER THE VEHICLE. A WEEK LATER, A SMALL FIRE OCCURRED UNDER THE HOOD WHICH WAS EXTINGUISHED BY THE CONTACT. THERE WAS A NHTSA RECALL, # 06V286000, REGARDING THE VEHICLE SPEED CONTROL. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

FORD WINDSTAR 1996. I HAVE SEEN THAT MANY OF THESE MODELS AND PREVIOUS YEARS AS WELL HAVE HAD SEVERE HEAD GASKET PROBLEMS. HEAD GASKET REGULARLY FAILS AT AROUND 80,000 MILES. NASA SAYS A HEAD GASKET SHOULD LAST AT LEAST 120,000. FORD DOES NOT CARE. FORD DOES NOT STAND BEHIND THEIR PRODUCT. I AM BASICALLY SCREWED BECAUSE NOW I DON'T HAVE A CAR. I STILL OWE ON IT BUT IT DOESN'T RUN. $2,000+ TO FIX IT AND IT WILL PROBABLY FAIL AGAIN. THE HEAD GASKET GOING OUT CAUSED THE UPPER 02 SENSOR TO GO BAD. IT ALSO SPRAYED THE NUMBER 2 CYLINDER CAUSING IT TO FAIL THUS ALERTING ME TO A PROBLEM, WHICH MAY HAVE RESULTED IN A BLOWN ENGINE. AT NO TIME WHILE I HAVE OWNED THIS VEHICLE HAS IT EVER OVERHEATED EVEN SLIGHTLY. HEAT WAS NOT THE CAUSE, IT WAS FAULTY FROM THE BEGINNING. CAR AUTO SAFETY HAS REPORTED 429 COMPLAINTS ABOUT THE WINDSTAR! *JB

ABS LIGHT ON, BRAKE LIGHT ON, BRAKES FAILED DUE TO BROKEN BRAKE LINE. THIS IS THE SECOND TIME THIS HAPPENED. ON 2 DIFFERENT BRAKE LINES. WE REPLACED BOTH BRAKE LINES. *JB