1996 FORD WINDSTAR Complaints

THE K FRAME RUSTED OUT WHERE THE CONTROL ARMS MOUNT TO THE FRAME AND THE FRONT DRIVER'S SIDE COIL SPRING BROKE WHILE DRIVING AT 65 MILES PER HOUR ON THE INTERSTATE

TL* THE CONTACT OWNS A 1996 FORD WINDSTAR. THE CONTACT STATED THAT THERE WAS A VERY STRONG FUEL ODOR INSIDE AND OUTSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 240,000.

TL* THE CONTACT OWNS A 1996 FORD WINDSTAR. WHILE AT A STOP LIGHT, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE ABOVE 20 MPH. THE SERVICE BRAKE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

ABS LIGHT ON DASHBOARD COMES ON INTERMITTENTLY, AFTER 5 MINUTES OF OPERATION LIGHT WILL COME ON, THEN STAY ON, BUT AFTER SHUT OFF VEHICLE AND START AGAIN LIGHT IS FFF AND COMES BACK ON AFTER FEW MINUTES OF TRAVEL. *TR

THIS IS A SECOND CALL FOR HELP FORD CORPORATE WILL NOT EMAIL ME BACK. WILL NOT VERIFY IF PCM HAS BEEN UPDATED. THE VAN ONLY HAS UNDER 59,000 MILES ON IT . IT SHOULD NOT BREAK THIS BAD THIS SOON MAKES ME TELL ANYONE ON SOCIAL MEDIA AND OUR LOCAL NEWS MEDIA AND CLARK HOWARDS TEAM. I DO NOT WANT TO CALL FORD UNLESS IT IS AGREED THE PHONE WILL BE RECORDED FOR COURT PURPOSES. I EVEN ASKED IS THE WOULD LET ME USE THE UPDATER. I SURE DO NOT WANT DON RICH FORD IN VILLA RICA EVER AGAIN. THEY STRIPPED THE SCREW. THAT SET MIN CLEARANCE ON THROTTLE PLATE. NO SHIFTS FUNNY AND SPUTTERS AND TERRIBLE NOISE IN OIL PAN AREA. ROD S KNOCKING. INTERNET HAS TONS OF COMPLAINTS OF PISTONS EXITING ENGINE OIL PAN. *TR

DEAR FORD MY MOTHER AND I HAVE BEEN TRYING TO GET ANSWERS FROM THE DEALER AND SINCE THEY GAVE UP. BECAUSE THEY COULD NOT FIX IT RIGHT THE FIRST TIME. EVEN THE SECOND OR THIRD TIME. THE VAN A 1996 WINDSTAR WITH 59,000 MILES ON IT AND IT STARTED THE ENGINE STARTED STALLING, WHEN MAKING SLOW TURNS NOT TOUCHING THE GAS PEDAL LOSES POWER STEERING. MY MOM ALMOST WENT INTO A DITCH TO AVOID A COLLISION WITH ANOTHER CAR. WITH LITTLE INTERNET SEARCHING FOUND HUNDREDS OF VANS WITH SAME PROBLEMS, AND APPEARS THERE IS NOT ONE RESOLVED. AND SINCE THIS HAS GONE ON FOR OVER A MONTH. THE LAST VISIT TO THE FORD DEALER IN AN ATTEMPT TO FIX THE STALLING. . THE IDLE AIR CONTROL VALVE IS NEW, AND MASS AIR FLOW IS CLEAN SUPPOSED TO HAVE BEEN REPLACED ALSO. I CHECKED THE AIR FILTER WAS CLEAN, THE FUEL FILTER IS ORIGINAL SO I REPLACED IT. I STARTED LOOKING AT THE THROTTLE BODY, AND NOTICED THAT THE THROTTLE PLATE SCREW WAS ALL GOUGED UP. WHILE I WAS SITTING IN DRIVE WAY WITH ENGINE RUNNING AND UNLESS FORD ENGINES ARE ONLY GOOD FOR 60,000 MILES, WITH ALL THE STALLING AND LOW ENGINE IDLE THAT KEEPS OIL PRESSURE IN THE ENGINE LUBRICATING THE CRANK SHAFT.!! SO WHEN ENGINE STALLED AT VERY LOW IDLE THERE WAS NO OIL GETTING THROUGH THE ENGINE. THIS ENGINE NOW HAS LOWER END KNOCK, WHICH I VERIFIED BY PULLING VAN ONTO FLOOR RAMPS, TEST DROVE AND CONFIRMED THE PROBLEM, IS CRITICAL. EACH TIME I SLOWED DOWN TO TURN ENGINE STALLED EVERY TIME, LOST POWER STEERING AND BRAKES. I COULD HAVE BEEN KILLED BECAUSE FORD IS IGNORING THIS PROBLEM.. AND THIS ALSO ANSWERS WHY OTHER COMPLAINTS WERE ABOUT ENGINE FAILURES AND VERY EXPENSIVE REPAIRS. THIS LETTER WILL BE PUT ON ALL SOCIAL NETWORKS, TO WARN OTHERS THIS COULD HAPPEN TO THEM BE AWARE. THEY SAID THE ECU/PCM COMPUTER WAS UPDATED. COULD NOT FIND UPDATE ON INVOICES, OR IN HISTORY I CAN ACCESS. *TR

FORD RECALL LETTER DATED DECEMBER 2011 RECALL NUMBER 09 S 09 SPEED CONTROL SYSTEM MODIFICATION. I RECENTLY TOOK MY FORD WINDSTAR ON JANURARY 3, 2013 FOR A RECALL. ABOUT A MONTH LATER I DROVE OVER RAILROAD TRACKS AND NOW THE VEHICLE IS SLOW AND WON'T PICK UP SPEED IT MAKES A PUT PUT SOUND AND HAS ALMOST NO POWER. I CALLED THE DEALER TO REPORT THE ISSUE AND THEY WANT $90.00 JUST TO LOOK AT IT EVEN THOUGH IT WAS JUST IN THE SHOP FOR THE RECALL. I CALLED FORD CUSTOMER COMPLAINT AND ALL THEY SAY IS THEY ARE NOT RESPONSIBLE FOR THE FORD DEALER ACTIONS OR INACTIONS. THE LETTER FROM FORD WAS THE MAIN REASON I TOOK THE VAN IN BECAUSE IT SAYS THERE IS A FIRE HAZARD BUT NOW THE VAN IS A PIECE OF JUNK. FORD REFUSES TO RECHECK THE VEHICLE AND LOCATE THE REAL CAUSE OF THE PROBLEM THE VEHICLE IS THE ONLY WAY FOR ME TO GET AROUND. THANKS FORD FOR YOUR ATTENTION AND LACK OF CONCERN. SIGNED DISSATIFIED VICTIM OF A SCAM. *TR

NOTICED FUEL LEAK WHEN RETURNED AFTER PARKING AT SLANTED PARKING SPACE. INSPECTION BY LICENSED MECHANIC IN COLUMBUS, OHIO CONFIRMED FUEL TANK LEAK. REMOVED TANK FOR FURTHER INVESTIGATION AND FOUND CRACK. REPAIRED BY SAME MECHANIC. TOTAL COST CLOSE TO $300.00. NOW NO GASOLINE LEAK. *TR

MY VAN WAS IN GREAT SHAPE AND GREAT CONDITION. I WAS DRIVING TO WORK ON MAY 6TH 2012 ABOUT 45-50 MPH ENTERED THE I-215 COLLECTOR, STARTED TO SMELL A BURNED RUBBER SMELL, I LOOKED AT THE TEMP GAUGE AND IT WAS NORMAL, THE VAN STARTED TO SPUTTER LIKE RUNNING OUT OF GAS, THE VAN WAS NOT OUT OF GAS ALMOST FULL, THE SERVICE ENGINE LIGHT STARTED TO FLASH ON AND OFF, I PULLED OVER TO THE SHOULDER AND CAME TO A COMPLETE STOP, LOOKED AT THE TEMP GAUGE AGAIN AND IT STILL WAS NORMAL, THE BURNED RUBBER SMELL GOT WORSE AND I NOTICED THEN A BLACK SMOKE COMING FROM UNDER THE HOOD. I GOT OUT OF THE VAN AND STOOD AT THE FRONT OF THE VAN TO CALL AAA AND THE ENGINE BURST INTO FLAMES UNDER THE HOOD. THERE WAS NOT INDICATOR WHAT SO EVER THAT THE VEHICLE WAS OVERHEATING. THIS ALL OCCURRED IN ABOUT 5-10 MINUTES. THE POLICE CAME AND COULD NOT PUT THE FIRE OUT WITH EXTINGUISHER. THE FIRE DEPARTMENT HAD TO PUT THE FIRE OUT. IT BURNED UP MY ENTIRE VEHICLE WITH ALL THE CONTENTS INSIDE. THE FIREMAN STATED THAT EVEN THE FRONT TIRES WERE BURNED UP AND MELTED. I DID GET PICTURES OF WHAT HAPPENED. I ONLY HAD LIABILITY INSURANCE SO I THOUGHT I WAS JUST OUT OF LUCK. A SECURITY SPECIALIST FROM WORK SAID THAT IT SOUNDED LIKE THE FIRE COULD HAVE STARTED DUE TO A FACTORY SAFETY DEFECT AND TOLD ME TO DO SOME RESEARCH. I DID FIND THAT THERE WAS A RECALL ON THE SPEED SWITCH OR CONTROL ON 1996 FORD WINDSTARS. I ALWAYS USE MY CRUISE CONTROL. I HAVE FILED A CLAIM WITH MY INSURANCE BASED ON A BURN UNDER THE ASSUMPTION THAT THE FIRE OCCURRED DUE TO THE SPEED CONTROL RECALL. PLEASE LET ME KNOW WHAT I CAN DO. I NEVER RECEIVED ANY NOTIFICATION OF THE RECALL OR I WOULD HAVE TAKEN IT IN TO BE FIXED BEFORE THIS HAPPENED. *TR

HAD CHANGED BRAKE PADS A WEEK EARLIER. DRIVING 55MPH AND THE CAR CRASHED DOWN ON IT'S AXLE AS THE TIRE AND WHEEL PASSED BY US GOING DOWN HIGHWAY, IN 37 NORTH. STUDS HAD ALL BROKEN OFF. THE DISC BRAKE IS RUINED FROM SKIDDING ON IT. TRAFFIC WAS MODERATELY HEAVY. WE SKIDDED TO A STOP ON A BRIDGE AND FEEL LUCKY NOT TO HAVE CRASHED INTO ANYONE. *TR