1996 FORD WINDSTAR Complaints

INTERIOR LIGHTS STAY ON AFTER OPENING HATCH AND NOW SIDE DOOR. DOOR AJAR LIGHT STAYS ON ALWAYS. *JB

DT*: THE CONTACT STATED THAT THE ENGINE DIED AT 21,000 MILES. THE CONTACT EXPRESSED THE ENGINE SHOULD NOT HAVE DIED AT 21000 MILES. THERE WERE NO FAILURES THAT LEAD TO THIS INCIDENT. THE PROBLEM HAS NOT BEEN REPAIRED.

DT*: THE CONTACT STATED WHILE DRIVING ON NORMAL ROAD CONDITIONS AT ANY SPEED THE TRANSMISSION SLIPPED CONTINOUSLY AND WOULD NOT GO INTO OVERDRIVE WHEN GAS WAS APPLIED WHILE TRYING TO PASS OTHER VEHICLES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO ADVISED THE CONTACT TO TAKE THE VEHICLE TO A REPUTABLE TRANSMISION SERVICE. THE CONTACT DISREGARDED THE OPTION BECAUSE IT WAS TOO FAR AND THE TOWING TOO EXPENSIVE. A TIRE WAS ALSO PUNCTURED WHILE REPAIRING A COIL SPRING. AFTER THE TIRE WAS REPLACED WITHOUT BEING BALANCED THE VEHICLE LOST ITS ALIGMENT.

WE OWN A 1996 FORD WINDSTAR. IN DECEMBER OF 2005 THE VAN WAS PARKED IN OUR DRIVEWAY WITH THE ENGINE OFF. WHILE MY WIFE AND I WORKED IN THE FRONT YARD, THE VAN SPONTANEOUSLY STARTED. I GOT IN, PUT IT IN GEAR AND IT DIED. IT RAN FINE FOR A TIME AFTER THAT. WE SPOKE TO OUR INDEPENDENT MECHANIC WHO HAD NEVER HEARD OF SUCH A THING. WE BASICALLY FORGOT ABOUT IT UNTIL MAY 30, 2006. THIS TIME IT HAPPENED IN THE GARAGE WITH ALL OF THE DOORS SHUT. MY DAUGHTER CAME IN THE HOUSE ASKING WHY THE VAN WAS RUNNING. WE DID THE SAME THING TO AGAIN MAKE IT STOP. THE GARAGE WAS FILLED WITH EXHAUST AND A BLACK EXHAUST STAIN ON THE FLOOR. THIS TIME WE BROUGHT IT TO OUR LOCAL FORD DEALER. HE DIAGNOSED IT AS A FAULTY TRANSMISSION RANGE SWITCH. CHARGE FOR THE REPAIR FOR PARTS AND LABOR WAS $175. THE DEALERSHIP WOULD NOT HELP BECAUSE THERE HAD NOT BEEN A RECALL OF THE ITEM AND IT WAS NO LONGER UNDER WARRANTY. I CALLED FORD'S CUSTOMER SERVICE DEPARTMENT AND THEY WOULD NOT HELP CITING THE SAME EXCUSE AS THE DEALER. I FEEL THIS IS A SIGNIFICANT SAFETY ISSUE. HAD WE NOT CAUGHT IT IN TIME WE COULD HAVE EXPERIENCED SIGNIFICANT CARBON MONOXIDE POISONING OR EVEN DEATH OF OUR PETS IN THE GARAGE OR FAMILY MEMBERS IN THE HOUSE. WE'VE BEEN VERY DISAPPOINTED WITH FORD THROUGH THE YEARS. WE HAVE HAD GASKET PROBLEMS WITH OUR VAN, YET THE RECALL FOR THAT ITEM EXTENDS ONLY THROUGH 1995 AND THEY HAVE NOT STOOD BEHIND THE 96'S. *NM

I HAVE A 1996 FORD WINDSTAR THAT HAS DEVELOPED A LEAK IN ITS BRAKE LINE. I WENT ON THE INTERNET TO FIND A BRAKE LINE FOR THE CAR AND I FOUND OUT THAT THIS IS A CHRONIC PROBLEM WITH THIS VEHICLE. THERE WAS A RECALL FOR THIS EXACT PROBLEM FROM FORD. I CONTACTED FORD AND TOLD THEM OF THE PROBLEM AND THEY STATED TO ME THAT MY VEHICLE WAS SEEN BY A FORD DEALER FOR THE RECALL IN 2002. THEY THEN TOLD ME TO CONTACT MY LOCAL DEALER AND FIND OUT IF THIS WOULD BE COVERED BY FORD. I CONTACTED MY LOCAL DEALER AND THEY TOLD ME THAT IF THE CAR WAS ALREADY RECALLED FOR THIS PROBLEM THAT IT WOULD HAVE TO BE PAID FOR BY ME. I LOOKED AT THE BRAKE LINE AND IT DOES NOT LOOK LIKE IT WAS EVER REPLACED. THE RECALL # IS 02V101000 . *NM

SPEEDOMETER FAILURE SPEEDOMETER FLUCTUATES ERRATICALLY STARTING AT SPEEDS OF 35 MPH GAUGE JUMPS IN INCREMENTS OF 5-10-50 SPEEDOMETER SHOWS 65-85 WHEN ACTUALLY GOING 45-50 HAZARDOUS TO DRIVER AND ALL OCCUPANTS IN VEHICLE AND OTHER DRIVERS ON ROAD WAY. *JB

DT*: THE CONTACT STATED THERE WAS AN ODOR OF FUEL IN HIS GARAGE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, BUT A DETERMINATION WAS NOT GIVEN. THERE IS A NHTSA RECALL, # 99V309000, REGARDING THE TANK ASSEMBLY; HOWEVER, IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 5/30/2006 - THE CONSUMER INSPECTED THE VEHICLE AND FOUND THAT THE FUEL TANK WAS LEAKING AT THE STRAP ON THE DRIVER'S SIDE. THE TANK BEGAN TO LEAK WHERE THE MANUFACTURER HAS APPARENTLY OVER-TIGHTENED THE SUPPORT STRAPS FOR THE TANK. THE 1995 MODEL WAS RECALLED (99V-309000), MANUFACTURER NUMBER 99R33 REGARDING THE EXACT SAME ISSUE. THE CONSUMER CONTACTED THE DEALER BUT THEY PROVIDED NO ASSISTANCE. *NM UPDATED 06/27/06. *JB

1996 FORD WINDSTAR COIL SPRING WAS FOUND BY NON-FORD DEALER MECHANIC TO BE BROKEN IN HALF AND CAUSING BANGING NOISE IN FRONT END. FORD DEALER COULD NOT FIND PROBLEM, BUT BOTH COIL SPRINGS AND STRUTS WERE EVENTUALLY REPLACED BY NON-FORD MECHANIC BEFORE I WAS NOTIFIED ABOUT FORD'S RECALL ON THE COIL SPRINGS. AM I ENTITLED FOR REIMBURSEMENT BY FORD FOR THE COST OF THE REPAIR BILL? *NM

DT*: THE CONTACT STATED AFTER EXITING THE DRIVEWAY, SMOKE WAS OBSERVED COMING FROM UNDER THE HOOD. UPON FURTHER INSPECTION, UNDER THE HOOD A FIRE WAS ALSO OBSERVED AND EXTINGUISHED. THE VEHICLE AS THEN PARKED AND HAS NOT BEEN INSPECTED BY A MECHANIC. *AK

ENGINE DIES AFTER EITHER VERY SHORT (1 SECOND OR LESS) OR NO MISFIRE. ALWAYS ON HOT AFTERNOON AFTER LONG PERIOD HIGHWAY DRIVING, TYPICALLY INTERSTATE WITH SPEED IN THE 70'S. ONLY ONCE ON A SECONDARY ROAD SPEEDS OF 45 - 50. ALL TIMES IN THE ROLLING HILLS OF UTAH, WYOMING, AND WESTERN NORTH DAKOTA. ALL SIX INCIDENTS OCCURRED DURING A CROSS COUNTRY TRIP IN JULY, 2005 WITH ODOMETER READINGS IN THE 70,000'S. TYPICALLY, WHEN IT HAPPENS, THE ENGINE SPEED AND THROTTLE ARE CONTINUALLY ADJUSTING TO MAINTAIN SPEED ACROSS THE HILLS. FIRST INDICATION OFTEN IS SIMPLY THE CAR SLOWING DOWN RATHER THAT CRUISING ALONG. ALL OTHER ELECTRICAL (AIR, RADIO, WINDOWS, ETC) NOT AFFECTED. THIS IS VERY DANGEROUS. OTHER THAN SOMETIMES A ONE SECOND MISFIRE, THERE IS NO WARNING. THE CAR MAY BE PASSING A TRUCK, IN A MIDDLE FREEWAY LANE, ON ON A ROAD WITH NO SHOULDER WHEN IT HAPPENS. WHEREVER AND WHENEVER IT HAPPENS, THE CAR SIMPLY COASTS AS THE DRIVER PULLS OFF THE ROAD TO EXTENT POSSIBLE. THE ENGINE WILL NOT RESTART FOR 15 MINUTES OR SO. THEN IT STARTS AS IF NOTHING EVER HAPPENED, AND CAR IS GOOD UNTIL THE NEXT INCIDENT. I MADE DETAILED NOTES OF EACH INCIDENT, AND CAN PROVIDE ADDITIONAL INFO ON SPECIFICS OF WHAT WAS GOING ON WITH CAR AT THE TIME. I TOOK CAR TO A FORD DEALER. THE DEALER DID DIAGNOSTICS AND COULD NOT IDENTIFY PROBLEM. I HAVE REFRAINED FROM DRIVING UNDER SIMILAR HIGHWAY CONDITIONS SINCE THEN. THE VAN WAS PURCHASED NEW IN CONNECTICUT IN FEB, 1997. *NM