1998 FORD WINDSTAR Complaints

The contact owns a 1998 Ford Windstar. The contact stated while driving at various speeds, the vehicle was shuddering significantly. The vehicle was taken to a Tire Store, where it was diagnosed that the rear axle was corroded and had fractured from the upper side to the lower side. The mechanic related the failure to NHTSA Campaign Number: 10V385000 (Suspension). The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

We woke up this morning to the driver's side completely burned and melted. It had been parked sinced Monday. Fire inspector said it was definitely an electrical issue coming from the seat.

TL* THE CONTACT OWNS A 1998 FORD WINDSTAR. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT HEARD A HISSING SOUND COMING FROM THE VEHICLE, BUT COULD NOT IDENTIFY WHERE THE SOUND ORIGINATED. THE CONTACT ALSO BEGAN TO SMELL A BURNING RUBBER ODOR. THE CONTACT PULLED INTO A NEARBY DRIVEWAY AND PLACED THE VEHICLE IN PARK. THE CONTACT WAS UNABLE TO IDENTIFY ANY FAILURES WITH THE VEHICLE. THE CONTACT CALLED A CERTIFIED MECHANIC; HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE FAILURES WERE SIMILAR TO NHTSA CAMPAIGN NUMBER: 10V385000 (SUSPENSION). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

SUBFRAME RUSTED ON LEFT FRONT PASSENGER SIDE. 1998 FORD WINDSTAR. I HAD A POPPING NOISE WHEN I MADE A LEFT TURN AND LOUD CRUNCHING NOISE AND STEERING WHEEL PULLED TO LEFT. I HAD TAKEN IT TO A AUTO SHOP AND THEY REPLACED STRUTS.SWAY BARS AND BRAKES . NO ONE TOLD ME ABOUT THE RUST ISSUE WITH THE SUB FRAME. I DROVE IT HOME FROM SHOP. SAME PROBLEM. RETURNED THE VEHICLE TO SAME REPAIR SHOP AND THE HAD A WELDER ATTACH STEEL BRACKET TO HOLD UP SUB FRAME. 2 DAYS LATER WORSE. I HAD A SECOND MECHANIC LOOK AT IT AND HE TOLD ME THE FIRST REPAIR SHOULD NOT HAVE ASKED ME TO REPAIR ANYTHING ON THE VAN. SUB FRAME IS FAILED AT 128,436 MILES. I NOTIFIED FORD MOTOR CO . OF THE FAILURE, WAS GIVIN A CASE NUMBER. ENGINE WILL FALL OUT OF BOTTOM WITH CORROSION OF SUB FRAME. VEHICLE IS NOT SAFE TO DRIVE

MY REAR AXLE BROKE AND THEN MY DOOR AJAR CONSTANTLY GOES OFF EVEN WHEN DOORS ARE CLOSED. THE AXLE BROKE REAR DRIVERS SIDE LEAVING ME STRANDED. I WAS DRIVING IN TOWN 20 MPH.

MY FRONT CRADLE AT STEERING AREA HAS COMPLETELY RUSTED INTO FROM AC LEAK AND ROAD SALT VAN WAS SOLD IN VERMONT NOW IS LOCATED IN VIRGINIA UNSAFE ALMOST UNDRIVABLE TO FORD DEALER FOR A REAR AXLE RECALL FOR AXLE BRACES PLEASE INVESTIGATE THIS

MY MINI VAN LIGHTS WOULD FLICKER WHILE I'M DRIVING AND EVEN AFTER REPLACING THE STARTER IN THE CAR, IT STILL TURNS OFF WHILE I'M DRIVING. THERE'S RUST COMING FROM UNDER THE CAR, I SMELL A BURNT SMELL WHEN I'M DRIVING. I'M HAVING ELECTRICAL ISSUES, MY CAR STOPS WHEN IT WANTS TO IN THE MIDDLE OF THE HIGHWAY, .. IT MAKES NOISES WHEN I'M TURNING, I HAVE RUST COMING FROM UNDER MY CAR. THE SIGNAL LIGHTS FLICKER. WHILE DRIVING THE WINDSHIELD WASHER, SEAT BELT, AND DOOR AJAR WARNING LIGHTS FLASH ON AND OFF. WHILE THIS IS HAPPENING THE WIPER BLADES STOP WORKING, FRONT BRAKE ROTORS IS CAUSING STEERING WHEEL TO SHIMMY WHEN THE BRAKES ARE APPLIED. NOW WHEN I TURN MY WHEEL TO THE LEFT, IT MAKES THIS LOUD NOSE. WHAT IS THAT?!

ABS DASHBOARD LIGHT STAYS ON VIBRATION WHEN BRAKING WHILE IN MOTION VIBRATION IS PROPORTIONAL TO SPEED

REGARDING FORD MOTOR COMPANY SAFETY RECALL NOTICE 15S27: FORD MOTOR COMPANY IS REFUSING TO REPAIR MY REAR AXLE WHICH FRACTURED DUE TO A POORLY DESIGNED AXLE THAT HAS BEEN THE SUBJECT OF NUMEROUS RECALLS, INCLUDING THE INSTALLATION OF AXLE REINFORCEMENT BRACKETS (WHICH HAD BEEN DONE AND LATER INSPECTED AT PHIL'S FORD IN PORT JERVIS, NY - WINTER OF 2015). I WAS TOLD THE BRACKET REINFORCEMENT REPAIR HAD BEEN PROPERLY INSTALLED, HOWEVER THE AXLE STILL BROKE ON 8/17/17 WHILE I WAS DRIVING AT 65 MPH ON THE INTERSTATE - AN INCREDIBLY DANGEROUS SITUATION! THE BREAK OCCURRED AT AND WITHIN THE REINFORCEMENT BRACKET. EVENTUALLY, SOMEONE WILL BE HURT OR KILLED BECAUSE OF FORD'S NEGLECT TO FIX THIS PROBLEM. THE MORE I SEE OF FORD'S RESISTANCE TO TAKE CARE OF THIS SAFETY ISSUE THE GREATER MY CONCERN IS FOR OTHER DRIVERS (OF A VAN DESIGNED FOR FAMILIES WITH CHILDREN) WHO ARE UNAWARE OF THE DANGER THEY ARE IN DUE TO THE COMPANY'S NEGLECT. THEY ARE TELLING PEOPLE THAT THEIR WINDSTAR VANS ARE SAFE TO DRIVE AFTER THE BRACKET REINFORCEMENT REPAIR. THEY ARE NOT SAFE TO DRIVE. MY LOCAL FORD DEALERSHIP (HEALEY BROTHERS FORD IN GOSHEN, NY) IS REFUSING TO HONOR THE EARLIER RECALL, FORD MOTOR COMPANY CUSTOMER RELATIONS IS REFUSING TO HONOR THE EARLIER RECALL CLAIMING THAT THE OFFER TO REPAIR MY VEHICLE HAS EXPIRED.

TL* THE CONTACT OWNS A 1998 FORD WINDSTAR. WHILE DRIVING, THE STEERING WHEEL SHOOK AND THE VEHICLE PULLED TO THE LEFT AND RIGHT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT DRIVER SIDE SUBFRAME WAS RUSTED DUE TO CORROSION AND THE SUBFRAME NEEDED TO BE REPLACED. THE CONTACT CALLED JOHN KENNEDY FORD- POTTSTOWN AT (800) 790-8132 (LOCATED AT 3189 W RIDGE PIKE, POTTSTOWN, PA 19464) WHERE THE DEALER REFERENCED NHTSA CAMPAIGN NUMBER: 10V385000 (SUSPENSION), BUT NOT FOR THE SUBFRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 100,197.