FREIGHTLINER Complaints

CARBON MONOXIDE LEAKAGE INTO CAB FROM HEATER/AIR CONDITIONING SYSTEM ON FREIGHTLINER COLUMBIA TRUCKS WITH DETROIT EGR (EPA COMPLIANT) ENGINES ABOUT 2003 AND NEWER. CARBON MONOXIDE RESULTED IN ELEVATED BLOOD PRESSURE, NAUSEA, FLU LIKE SYMPTOMS, HEADACHES, TIREDNESS, ETC.. TRUCK HAS BEEN WORKED ON 5 TIMES FOR THIS PROBLEM, NUMEROUS PARTS HAVE BEEN REPLACED. HAS NOT CORRECTED THE PROBLEM, OR ONLY FOR A SHORT WHILE. PROBLEM EXISTS IN SEVERAL AREAS AND IS NOT READILY APPARENT WHEN DOING IN SHOP TESTING, REPAIR AND REPLACEMENT. SOME PROBLEMS ARE RELATED TO FREIGHTLINER AND SOME TO DETROIT DIESEL. HAVE BEEN ADVISED IS NOT UNCOMMON. *JB

CONSUMER COMPLAINT REQUESTING RECALL PARTS TO HAVE RECALL COMPLETED ON VEHICLE. *TS RECALL#00V357000. THE CONSUMER ALSO HAS TWO OTHER VOLVO TRUCKS RELATED TO THE RECALL. *JB

DT: THE CONSUMER STATED THAT THE DRIVER'S SEAT BELT LOCK FELL APART. THIS HAPPENED WITHOUT WARNING. ALSO THE VALVE ON THE KNOB ON THE DASHBORD LEAKED AIR AND WOULD NOT RELEASE THE BRAKES. THIS STARTED IN SEPTEMBER 2005. THE DEALER SAID THAT THEY COULD NOT FIX THE PROBLEM AT THERE EXPENSE. THE MANUFACTURER WOULD NOT TAKE THE COMPLAINT BECAUSE OF THE AGE OF THE VEHICLE. MODEL FL112. *AK (11/17/05) *SC

DT: 2000 FREIGHTLINER MT45. THE CONTACT STATED THE FUEL PUMP FAILED ON FEBRUARY 25, 2003. THE VEHICLE LOST POWER FROM 75-35 MPH. ON A SEVEN MILE DRIVE THE VEHICLE VARIED WITH FREQUENT SPEED VARIATIONS, EVERY 10- 15 SECONDS, THE ENTIRE SEVEN MILES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP; THEY CHECKED THE ENGINE FOR STALLING INTERMITTENTLY. THE DEALERSHIP FOUND 299 COUNTS OF FAULT CODE 364. THEY REPLACED THE FUEL PUMP. THIS CORRECTED THE PROBLEM, BUT THE DEALERSHIP DID NOT WARRANTY THE PROBLEM *AK

DT: 2000 FREIGHTLINER MT45. THE CONTACT STATED THE FUEL INJECTION PUMP FAILED. THIS HAPPENED ON AUGUST 31, 2005. THE VEHICLE HAS NOT BEEN TO TAKEN TO THE DEALERSHIP. THE CONTACT INSTALLED A LIFT PUMP AND A LIFT PUMP INDICATOR FAILURE LIGHT. HE NOTICED SUDDEN AND UNANNOUNCED ENGINE FAILURE WHILE DRIVING ON MAIN STREET TRAFFIC. THE CONTACT IMMEDIATELY PULLED OVER WITH A DEAD ENGINE. THE VEHICLE WAS THEN TOWED TO THE CONSUMER'S RESIDENCE. THE CONTACT CONTACTED FREIGHTLINER, AND THEY TOLD HIM THERE WAS NO WARRANTY COVERAGE. ALSO CONTACTED CUMMINS, AND THEY STATED THERE WAS NO WARRANTY COVERAGE . *AK

BROKEN FRAME ON 1999 FREIGHTLINER SCHOOL BUS/THOMAS BODY OVER RIGHT REAR AIR RIDE AT TORSION BAR MOUNT. VEHICLE IS CURRENTLY UNDERGOING FRAME REPLACEMENT AT BODY SHOP. *NM

ENGINE FAN DOES COME ON WHEN IT SHOULD CAUSING ENGINE TO OVERHEAT. THIS HAS RESULTED IN SOME VERY UNSAFE HIGHWAY PULL-OFFS WHILE WAITING FOR ENGINE TO COOL. *JB

DT: 2005 FREIGHTLINER COLUMBIA. THE FRONT HUB BROKE, THE CASTING CAME COMPLETELY APART. THE NEW HUB IS A DIFFERENT STYLE THAN THE ORIGINAL. THE CONSUMER BROKE A BONE IN HIS NECK, AND HAS TWO BAD DISCS IN BOTH SHOULDERS. THERE WAS NO WRECK WHEN THIS HAPPENED. THE CONSUMER WAS ABLE TO CONTROL THE VEHICLE. HE WAS DRIVING BETWEEN 50-55 MPH WHEN THIS HAPPENED ON JULY 19, 2005. HE COULD NOT GET AN ANSWER FROM FREIGHTLINER WHY THIS HAPPENED. THE CONSUMER WANTED TO KNOW WHY THERE WAS A DIFFERENT HUB, AND IF HE SHOULD REPLACE THE OTHER ONE AS WELL. THE DOCTOR HAS YET TO RELEASE HIM FOR WORK. THE CONSUMER STATED THE FRONT AXLE, BRAKE DRUM, WHEEL, TIRE, THE ABS VALVE, AND I-BEAM NEEDED TO BE REPLACED AS A RESULT OF THIS.*AK UPDATED

HAD TRUCK TOWED TO SHOP,TRUCK WILL NOT GO INTO GEAR, CHECK FOUND THE CLUTCH HAD CAME APART, REPLACE CLUTCH. *NM

CLUTCH MAKING NOISE AND HARD TO GET INTO GEAR. HAD CLUTCH REPLACED , KNOWING WHAT HAPPENS NEXT WE DID NOT WAIT, KNOW CLUTCH IS GOING TO COME APART. TRUCK WORKS GREAT NOW. *NM