2006 GMC CANYON Complaints

The Passlock System intermittently fails and prevents the fuel pump from pumping fuel to the engine. Even after paying GMC to repair the truck, the problem persists.

Frame is severely rusting, especially on the driver’s side. Vehicle has only approximately 75,000 miles and has been well maintained. Purchased new by my Father and when he died, it was passed on to me. I feel it may becoming unsafe to drive.

My ABS on Rightside of my truck is not working that is what they said anyways not sure what is wrong

The contact owns a 2006 GMC Canyon. The contact stated that the rear sub-frame was rusted. The vehicle was taken to an independent mechanic however, the vehicle was not diagnosed nor repaired. The local dealer was not contacted. The manufacturer was notified of the failure. The failure mileage was 135,000.

TL* THE CONTACT OWNS A 2006 GMC CANYON. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE VEHICLE FAILED TO START-UP. THE SECURITY WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT AFTER WAITING AN HOUR, THE VEHICLE RESTARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A SECURITY SYSTEM FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE PERSISTED. THE LOCAL DEALER WAS NOT MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 264,124.

I HAVE A 2006 GMC CANYON AND THE ISSUE IS THE CAR SWITCHES INTO SECURITY MODE A FOR NO REASON VEHICLE WILL NOT START OR WON'T CRANK AT ALL AND IT ONLY GETS WORSE THERE ARE A FEW YOUTUBE VIDEOS SHOWING HOW TO BYPASS SECURITY SYSTEM , BUT I FEEL GM SHOULD SEND OUT NOTICES TO CUSTOMERS ON HOW TO FIX OR DISABLE THIS PROBLEM

I LIFTED THE TRUCK ON A HYDRAULIC LIFT TO FIND THE SOURCE OF A RATTLE THATS USUALLY A HEAT SHIELD THAT HAS COME LOOSE BUT TO MY SURPRISE I ALSO FOUND THE FRAME OF THIS TRUCK HAS LITERAL HOLES ROTTED THROUGH WITH THE RESPECTIVE SUPPORT STRUCTURES FOR THE TRANSMISSION/TRANSFER CASE, FUEL TANK AND FRONT LEAF SPRING ATTACHMENT POINTS. IN SOME PLACES THE FRAME HAS ROTTED AWAY TO MAYBE 40% OF THE FRAME IS STILL INTACT. VERY DANGEROUS. THE AFFECTED AREAS ARE NOT VISIBLE FROM OUTSIDE THE VEHICLE THE DAMAGE IS ONLY VISIBLE FROM UNDERNEATH. FROM OUTSIDE IT LOOKS LIKE TYPICAL SURFACE RUST COMING THROUGH THE UNDERCOATING. BUT THIS IS FAR FROM TYPICAL

ABS FAULT LIGHT IS ON TO INFORM THAT THERE IS A PROBLEM. THIS OF COURSE DISABLES THE ABS BRAKE SYSTEM. THE COMPUTER READS ABS WHEEL SPEED SENSOR. THEY HAVE BEEN REPLACED AND THE LIGHT IS STILL ON. THERE ARE SEVERAL PEOPLE WITH THIS SAME PROBLEM ALL OVER THE INTERNET AND NO ONE HAS FOUND A FIX YET. IS THERE A NEW RECALL ON THIS ISSUE OR IS THERE A WAY TO FIX IT? THANK YOU *TR

TL* THE CONTACT OWNS A 2006 GMC CANYON. THE CONTACT STATED THAT THE VEHICLE'S CHASSIS WAS SEVERELY RUSTED AND CREATED HOLES IN THE FRAME. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 61,000.

CRANKS BUT NO START INTERMITTENTLY. GMC DEALER STATES THAT THERE IS NOT PROBLEM. MUST WAIT 10 MINTURES, THEN TRY AND IT ALWAYS STARTS. NOT ISOLATED...GOOGLE, 2006 CANYON WON'T START AND THERE ARE MULTIPLE DESCRIPTIONS OF THE SAME PROBLEM. SOME HAVE SPECULATED THAT IT IS A 'RELAY', PROBLEM WITH THE IGNITION SYSTEM OR THE "PASSLOCK". I AM NOT AWARE OF ANY ACCIDENT BUT IF AVOIDING AN ACCIDENT AND IT WON'T START IT IS JUST A MATTER OF TIME. THIS HAS BEEN AN ONGOING PROBLEM FOR AT LEAST 3-4 YEARS, OCCURRING AT LEAST ONCE PER MONTH. OTHERS RECORDED THE SAME HISTORY. (XXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).