2004 GMC ENVOY XUV Complaints

TL* THE CONTACT OWNS A 2004 GMC ENCLAVE XUV. THE CONTACT STATED THAT WHILE DRIVING ABOUT 55 MPH, THE LOW BEAM LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE THE FAILURE WAS NOT DUPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE RECURRED FOUR TIMES WHILE DRIVING AT VARIOUS SPEEDS. THE DEALER WAS NOT CONTACTED. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS ABOUT 186,000.

THE THIRD BRAKE LIGHT CONNECTIONS LOCATED IN THE REAR TAILGATE ARE SEVERELY CORRODED AND WILL NOT LIGHT UP WHEN BRAKING. THIS CONDITION DOES NOT ALLOW PASSING OF STATE INSPECTION. THE ENTIRE BRAKE LIGHT ASSEMBLY AND WIRE HARNESS MUST TO REPLACED TO PASS STATE VEHICLE INSPECTION. THIS CONDITION IS CONTINUOUS, WHEN PARKED, WHEN DRIVING (WE FOLLOWED IT AROUND THE BLOCK TO SEE IF IT JIGGLED ON), I HAVE NOTHING TO UPLOAD BECAUSE THE BRAKE LIGHT WILL NOT LIGHT UP.

I WAS DOING A REAR BRAKE JOB AND SMELLED GASOLINE, SO I WENT UNDER THE VEHICLE AND OBSERVED THERE WAS A WET SPOT ON THE REAR OF THE FUEL TANK. UPON CLOSER EXAMINATION I FOUND THE INLET PART OF THE FUEL TANK WAS BROKEN AND ALLOWING FUEL TO EXIT THE TANK, CAN WE SAY FIRE RISK, SO I WENT ONLINE TO TRY TO PURCHASE A REPLACEMENT TANK AND I FOUND WHERE SEVERAL PEOPLE HAD HAD THIS SAMEPROBLEM, BUT NO RECALL IS IN PLACE ?????

CAR WAS BOUGHT IN 2004. WAS TAKEN TO THE DEALER SEVERAL TIMES TO HAVE AIRBAG LIGHT FIX BUT IT WAS NEVER RESOLVED IT WAS SAID TO BE FINE. NO HAZARD. NEVER INVOLVED IN A CAR CRASH. CARS TURNS ON AND IT PROMPT YOU TO CHECK AIRBAGS. TODAY I WAS WATCHING THE NEWS AND SOMEONE MENTIONED THIS SITE. I WANTED TO SEE IT THERE HAS BEEN A RECALL

VEHICLE HAS HAD STRONG ODOR OR RAW FUEL COMING FROM DRIVING SIDE WHEEL WELL. HAD MECHANIC CHECK THIS OUT AND I WAS TOLD THIS HAS A FUEL LEAK NEAR THE FUEL FILTER / FILLER NECK AND POSSIBLE GAS TANK ISSUE WHICH IS CLOSE TO THE EXHAUST PIPE. THIS IS A KNOWN ISSUE FROM GM OWNERS BUT RECALL HAS NOT BEEN ADVISED. INFORMED GM OF ISSUE ON 10/26 BUT THEY WILL NOT FIX. THIS WILL COST UPWARDS OF $1100-$1600 TO FIX. *TR

TL* THE CONTACT OWNS A 2004 GMC ENVOY XUV. WHILE ATTEMPTING TO UTILIZE THE LIFTGATE, IT FAILED TO OPERATE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

2004 ENVOY XUV, IMPECCABLY MAINTAINED, CAR WAS PARKED IN MY DRIVE WAY AND I STARTED IT TO GO TO THE STORE AND IT STARTED CHUGGING AND THEN ALMOST DIED, BUT THEN WENT BACK TO NORMAL BUT THE SERVICE ENGINE SOON AND REDUCED ENGINE POWER LIGHTS ILLUMINATED ON DASH.TURNED OFF ENGINE. RESTARTED, AND THE SERVICE ENGINE SOON LIGHT WAS STILL THERE SO MY HUSBAND HOOKED UP HIS CODE READER AND IT HAD THE CODE P1680 ( THROTTLE BODY POSTIONING CENSOR.) AND THIS ISN'T THE FIRST TIME IT'S DONE IT BUT THE ENGINE LIGHT HAS ALWAYS JUST FLASHED IT WOULD NEVER STAY ON SO WE COULD READ THE CODE. BUT IN ORDER TO FIX THIS YOU HAVE TO BUY A WHOLE NEW THROTTLE BODY HOUSING BECAUSE THE CENSOR IS BUILT INTO IT. AND IT ISN'T CHEAP. AT AUTOZONE IT IS $280.00. AND YOU HAVE TO ALSO BUY A GASKET FOR IT AND NEW INTAKE MANIFOLD GASKETS BECAUSE TO REMOVE THE THROTTLE BODY HOUSING WHICH IS CONNECTED TO THE MANIFOLD YOU HAVE YO REMOVE THE MANIFOLD ALSO. HOW IN THE WORLD DOES GM EXPECT US TO BE ABLE TO FIX THIS ISSUE IF IT'S ALWAYS SO MUCH MONEY FOR PARTS FOR THESE CARS. AND I ALSO HAVE ISSUES WITH MY BACK TAILGATE AND BOTH BIG WINDOW MOTORS. I HAVE REPLACED ONE BUT STILL SAVING UP TO REPLACE THE MIDDLE ONE AND I'VE ALSO HAD ISSUES WITH MY GAS TANK WHICH IS $677.00 OR MORE AT THE DEALERS FOR A NEW GAS TANK BECAUSE U CAN'T JUST FIX THE FILLER HOSE. SUCH FAILURES WILL EVENTUALLY KILL SOMEONE. SO I THINK GMC NEEDS TO TAKE A LONGER LOOK AT THESE GMC ENVOY XUVS AND GET SOME RECALLS OUT TO FIX THESE DANGEROUS PROBLEMS. AND HONOR ALL CARS THAT COME IN NO MATTER WHAT. BECAUSE WE HAD TO FIX THE GAS TANK ISSUE OURSELVES BECAUSE WE COULD NOT AFFORD TO BUY A NEW GAS TANK.

STARTED SMELLING GAS, STARTED DRIPPING FUEL. AFTER INVESTIGATING THE FUEL LINES COMING OUT OF THE FUEL PUMP WERE SEVERELY CORRODED AT THE TOP OF THE GAS TANK. DRIPPING GAS COULD HAVE CAUGHT FIRE. LEARNED THERE WAS A TSB ON THIS AND EXTENDED WARRENTY DUE TO CORROSION OF FUEL LINES. THE WARRENTY WAS FOR 10 YEARS OR 150K. THE VEHICLE IS NOW 11 YEARS OLD. I HAVE LIVED IN THE SAME HOUSE FOR EIGHT YEARS AND NEVER RECEIVED A RECALL OR TSB NOTICE FROM GMC. OVER 800$ FOR A NEW FUEL PUMP AND TO DROP GAS TANK FOR REPAIRS. WHILE THE VEHICLE IS A 2004 IT ONLY HAS 67K ON IT.

ABOUT 9-10 MONTHS AGO STARTED NOTICING A FUEL SMELL AROUND BACK OF TRUCK. REPLACED GAS CAP, BUT THE ODOR CONTINUED. INQUIRED AT LOCAL DEALER, BUT WAS TOLD THEY COULD NOT DETERMINE THE CAUSE. TRIED A LOCAL MECHANIC THAT I HAD USED BEFORE, BUT AT THAT TIME, THEY CLAIMED THEY FOUND NO CAUSE EITHER. ON MY THIRD TRIP TO LOCAL MECHANIC, WAS INFORMED THAT THERE IS A CRACK IN MY FILLER/GAS TANK CAUSING THE SMELL. FINALLY THEY FOUND THE CAUSE ONLY TO INFORM ME THAT NOW MY TRUCK IS BEYOND THE MILEAGE AND/OR DATE OF THE 'RECALL' THAT I WAS NEVER INFORMED ABOUT BY GMC ABOUT MY GAS TANK, AND IT WILL ONLY COST "ABOUT" $1200 TO REPLACE MY GAS TANK. I'VE RESIDED IN THE SAME HOME WELL LONGER THAN I'VE OWNED MY TRUCK, SO MY HOME ADDRESS, PHONE NUMBER AND EMAIL ARE ALL STILL THE SAME AS THEY WERE THEN, AND HAD NO NOTIFICATION THAT THEIR WAS ANY TYPE OF RECALL ON MY TRUCK. HAVE TRIED EMAILING AND SNAIL MAILING GMC ON MANY NUMEROUS OCCASIONS TO SEE IF I COULD GET ANY HELP WITH THE UNKNOWN OF RECALL, BUT HAVE YET TO RECEIVE ANY ANSWER WHAT'S SO EVER FROM THEM AT ALL. OBVIOUSLY, IF I HAD THE DISPOSABLE INCOME, I WOULD NOT BE PURSUING ANOTHER SOLUTION, BUT LIKE MANY, I CONTINUE TO LIVE PAYCHECK TO PAYCHECK AND MY TRUCK IS THE MAIN LIFELINE TO MAINTAIN WHAT LITTLE I CAN PROVIDE. IF YOU COULD PASS ALONG ANY INFORMATION ABOUT POSSIBLE RECALL ASSISTANCE I CAN RECEIVE, IT WOULD BE GREATLY APPRECIATED. THANK YOU *TR

TL* THE CONTACT OWNS A 2004 GMC ENVOY XUV. WHILE DRIVING, THE CONTACT SMELLED FUEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP WAS CORRODED AND THE ODOR WAS A RESULT OF A FUEL LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.