2003 GMC SAVANA Complaints

TL*THE CONTACT OWNS A 2003 GMC SAVANA 3500. THE CONTACT NOTICED THAT THE HORN IN THE VEHICLE SOUNDED AUTOMATICALLY WHILE PARKED. IN AN ATTEMPT TO STOP THE NOISE, SOMEONE PRESSED THE HORN TO COUNTERACT THE FAILURE. ALMOST IMMEDIATELY, SMOKE BEGAN POURING FROM THE HOOD AND THE POLICE DEPARTMENT WAS CALLED. THE VEHICLE WENT UP IN FLAMES WITHIN A MATTER OF MINUTES. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. AT THE TIME OF THE COMPLAINT, THE CONTACT'S INSURANCE COMPANY WAS ASSESSING THE DAMAGE TO DETERMINE IF THE VEHICLE WAS DESTROYED. THE ENTIRE FRONT END WAS BURNED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 89,000.

TL*VIRGINIA TECH OWNS A 2003 GMC SAVANA. THE VEHICLE CAUGHT FIRE UNDER THE HOOD IN THE MIDDLE OF THE NIGHT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CAUSE OF THE FIRE HAS NOT YET BEEN DETERMINED. THE CURRENT AND FAILURE MILEAGES WERE 75,128. UPDATED 04/03/08. *LJ

TL*THE CONTACT OWNS A 2003 GMC SAVANA. WHILE DRIVING 65 MPH, THE ENGINE SUDDENLY STOPPED. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER FIVE MINUTES. THE DEALER WAS UNABLE TO DIAGNOSE THE PREVIOUS FAILURES. THE MOST RECENT FAILURE WAS DIAGNOSED AS THE CRANKSHAFT POSITION SENSOR. THE DEALER STATED THAT THE FAILURE IS SIMILAR TO NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 66,000 AND FAILURE MILEAGE WAS 20,000.

1. WAS DRIVING VAN ON THE HIGHWAY (DURING 1ST FAILURE OD 15,403 AND 2ND FAILURE OD 55576 ), WHEN THE TRANSMISSION WOULD NOT SHIFT IN TO HIGHER GEAR AND FAILED. WAS DRIVING VAN ON STREET WHEN VEHICLE BECAME UNDRIVEABLE (DURING 3RD FAILURE OD 56676). 2. DURING FAILURE 1 VAN WAS UNABLE TO MAINTAIN HIGHWAY SPEED AND HAD TO BE MANEUVERED TO THE SIDE OF THE FREEWAY AND TOWED TO THE DEALER. DURING FAILURE TWO VAN UNABLE TO MAINTAIN HIGHWAY SPEEDS AND WAS ABLE TO EXIT THE HIGHWAY AND DRIVE IN LOW GEAR TO THE DEALER. DURING FAILURE 3 VAN WAS UNABLE TO BE DRIVEN AT ALL AND OBSTRUCTED TRAFFIC ON A MAIN STREET UNTIL IT WAS TOWED TO A DEALER. 3. DURING FAILURE ONE SUNSHELL STRIPPED, 3-4 CLUTCHES BURNED, 2-4 BAND BURNED. SUN SHELL & GEAR REPLACED ALL CLUTCHES & 2-4 BAND REPLACED. DURING FAILURE TWO EXTENSIVE DAMAGE TO THE 4/4 CLUTCH, INPUT HOUSING, PUMP, SHAFT AND DRUM. CORE REASSEMBLED AND SRTA TRANS INSTALLED. DURING FAILURE THREE TRANSMISSION WAS SHREDDED AWAITING REPLACEMENT AT THIS TIME. *TR

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH UNDER NORMAL ROAD CONDITIONS, THE FRONT WHEEL BEARINGS FROZE UP, AND THE TIRES DID NOT TURN. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO REPLACED THE FRONT WHEEL BEARINGS AND THE BRAKE ROTORS. UPDATED 02/12/07. *JB

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH THE TRANSMISSION FAILED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHERE PARTS IN THE TRANSMISSION WERE REPLACED. AFTER 90,000 MILES, THE TRANSMISSION CEASED TO OPERATE AGAIN. THE VEHICLE WAS TAKEN TO A DIFFERENT SERVICE DEALER WHO OFFERED TO REPLACE THE TRANSMISSION IF A WARRANTY PACKAGE WAS PURCHASED AND THE TRANSMISSION WAS REPLACED. DURING THIS VISIT TO THE 2ND DEALER, A DIAGNOSTIC TEST WAS PERFORMED WHERE THE TAIL LIGHT WAS DISCOVERED NOT TO BE WORKING. THERE WAS NO REPAIR WORK PERFORMED FOR THE TAIL LIGHT. THE CONTACT ALSO EXPRESSED THAT ONE DAY THE DRIVER SEAT BELT WOULD NOT UNLATCHED SO THE SEAT BELT WAS BROKEN TO RELEASE THE CONTACT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER FOR RECALL REMEDY #05113 PERTAINING TO THE SEAT BELT. WHILE AT THE DEALER THE REMEDY REPAIR WORK WAS PERFORMED ON THE PASSENGER SEAT BELT BUT NOT THE DRIVER'S SEAT BELT. AFTER THE REMEDY REPAIR TO THE PASSENGER SEAT BELT, IT NO LONGER WORKED PROPERLY. THE SERVICE DEALER WAS CONTACTED; HOWEVER THE SERVICE DEALER HAD TO ORDER THE PARTS FOR ADDITIONAL REPAIRS. ALSO, WHILE DRIVING 25 MPH THE LUG NUT ON THE HUB CAP DETACHED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHERE PLASTIC LUG NUTS WERE INSTALLED AND THEY DETACHED AGAIN. WHEN THE VEHICLE WAS TAKEN BACK TO THE DEALER, THE SERVICE MANAGER RECOMMENDED THE LUG NUTS BE GLUED ON. THE CONTACT TOOK THE VEHICLE TO A TIRE COMPANY WHO INSTALLED BRAND NEW TIRES AND LUG NUTS.

I HAVE SEVERAL 2003 GMC SAVANA CARGO VANS THAT ARE USED AS SERVICE VEHICLES FOR BUILDING MAINTENANCE. I HAVE RECENTLY HAD THREE INCIDENTS WHERE THE OUTER SECTION OF THE OEM WHEELS (RIMS) HAVE SEPARATED FROM THE CENTER SPOKE SECTION ALONG THE WELD LINES THAT JOIN THE TWO. THE WHEELS ON THE VEHICLES AFFECTED HAVE BEEN REPLACED AND I HAVE THE OTHERS INSPECTED FOR POSSIBLE SIGNS OF FAILURE. I HAVE ONE OF THE WHEELS THAT SPLIT IN MY OFFICE. THE MOST RECENT INCIDENT WAS 6/23/2006. *NM

ALL 4 BRAKES LOCK UP WHILE DRIVING. BRAKE PADS DRAGGING 1 DAY PRIOR TO LOCK UP. BRAKE PEDAL GOES HARD. EXTREMELY DANGEROUS. TOLD COMPUTER ERROR IS PROBLEM FIRST TIME. SECOND TIME ANSWER PENDING. TRANSMISSION DOES NOT ENGAGE IMMEDIATELY WHEN SHIFTING FROM REVERSE TO FOREWORD. BACK OUT OF DRIVEWAY ONTO PUBLIC STREET-LAG TIME, DANGEROUS. INTERMITTENT PROBLEM. NO RESOLUTION FROM DEALER. *NM

DT*: THE CONTACT STATED THE RUNNING BOARDS ARE TOO NARROW. WHILE STEPPING OUT OF THE VEHICLE THE CONTACT MISSED THE NARROW RUNNING BOARD WHICH COULD RESULT IN A FALL. ALSO, THERE ARE NO SAFETY HANDLES ON THE INSIDE OF THE VEHICLE. THE MANUFACTURER HAS BEEN CONTACTED.*AK UPDATED 01/25/06. *JB

I HAVE A 3500 SAVANA GMC VAN, WHEN OPENING THE RIGHT PASSENGER DOOR AT THE SAME TIME THAT THE SIDE DOOR IS OPEN THE SIDE DOOR HITS THE FRONT PASSENGER DOOR WHICH HAS CAUSED A DENT IN THE SIDE DOOR. THE OTHER ISSUE IS WHEN SOMEONE OPENS THE FRONT PASSENGER DOOR AND HAS THEIR HAND IN THE SAME LOCATION WHERE THE TWO DOOR MEET IT COULD CAUSE DAMAGE TO THE HAND.*JB