2005 GMC SIERRA Complaints

WENT TO STOP AT STOP SIGN, BRAKES FELT SPONGY. STOPPED UP THE ROAD ABOUT 2 MILES AT MY MOMS HOUSE TO GET MY KIDS, LOOKED UNDER THE TRUCK AND SAW BRAKE FLUID DRIPPING DOWN ON THE LEFT SIDE OF THE FRAME BEHIND THE LEFT FRONT WHEEL.I HAVE TO REPLACE ALL OF MY BRAKE LINES NOW DUE TO RUST. *TR

TL* THE CONTACT OWNS A 2005 GMC SIERRA. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG DEPLOYED WHEN THE VEHICLE WAS SHUT OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

WHEN TRYING TO EXIT HIGHWAY OFFRAMP BRAKES COMPLETELY FAILED DUE TO BRAKE LINES RUSTING THROUGH. VEHICLE WAS BROUGHT TO A STOP WITH PARKING BRAKE. *TR

I WAS TRAVELING AT 35 MPH AND APPROACHED A STOP LIGHT. THE BRAKES FAILED AND I WENT THROUGH THE RED LIGHT. I NEARLY WAS HIT BY ONCOMING TRAFFIC. THE BRAKE LINE HAS A SEVER LEAK AT A RUSTED AREA IN THE LINE. *TR

AROUND THE MIDDLE OF DECEMBER 2014 THE "SERVICE BRAKE SYSTEM" MESSAGE APPEARED ON MY 2005 GMC 1500 SIERRA SLE. I CHECKED THE BRAKE FLUID RESERVOIR AND IT WAS NEARLY EMPTY. I COULD NOT FIND WHERE THE FLUID HAD LEAKED FROM SO I SERVICED THE RESERVOIR WITH 12 OUNCES BRAKE FLUID TO THE FULL MARK. FROM ABOUT DECEMBER 15, 2014 UNTIL 28 DECEMBER 2014, I LOST ABOUT 7 OUNCES OF BRAKE FLUID. NO TRACE OF BRAKE FLUID CAN BE FOUND ON THE DRIVEWAY. I CRAWLED UNDER THE TRUCK AND HAD MY WIFE PRESS THE BRAKES WHILE I LOOKED FOR A LEAK. I FOUND THE LEAK NEAR THE LEFT REAR WHEEL AREA ON A VERY CORRODED BRACKET. IT APPEARS TO BE A VERY SMALL HOLE BECAUSE THE FLUID COMES OUT AS A FINE MIST AND NOT A STREAM. THE RIGID BRAKE LINE CONNECTS TO A FLEXIBLE BRAKE LINE AT THE BRACKET AND THERE IS A LOT OF RUST AT THE CONNECTION AS WELL AS THE BRAKE LINE. I HAVE FOUND RUST FORMING ON OTHER BRAKE LINES AS WELL. *TR

ENGINE HAS LOSE OF ENGINE COOLANT OVER TIME WITH NO EVIDENCE OF LEAKS FOUND. WE BROUGHT THE TRUCK TO A GM DEALER WHICH TOLD US THIS WAS A KNOWN DEFECT ISSUE. THEY PROVIDED US WITH BULLETIN # 06-06-01-019B DOCUMENT ID 1986750 WHICH CLEARLY STATE THIS WAS DEFECT IN THE CASTING OF THE CASTECH HEADS. THE COST WITH PARTS AND LABOR IS $3,100.00 DOLLARS. CLEARLY, GM SHOULD COVER THIS COST SINCE THIS OBVIOUSLY IS A KNOWN DEFECT. SEARCHING THE INTERNET YOU CAN SEE A LARGE NUMBER OF PEOPLE EXPERIENCING THIS ISSUE WITH LITTLE OR NO HELP FROM GM. *TR

THE VEHICLE WAS PURCHASED NEW AND HAS BEEN REGULARLY MAINTAINED. THE BRAKE LINES AND FRAME ARE HEAVILY CORRODED. WHILE PULLING OUT OF A PARKING SPOT ON 10/26/14 BRAKES WERE APPLIED ABRUPTLY WHICH CAUSED A RUPTURE OF THE CORRODED BRAKE LINES. ALL BRAKE LINES WILL NEED TO BE REPLACED IN ORDER TO SAFELY RETURN THE VEHICLE TO SERVICE. OTHER FAMILY MEMBERS HAVE 2004 CHEVY YUKON AND 1994 GMC 2500, BOTH VEHICLES HAD BRAKE LINES FAIL DUE TO CORROSION AND REQUIRED COMPLETE REPLACEMENT IN ORDER TO SAFELY RETURN THE VEHICLES TO SERVICE. THIS IS A SERIOUS SAFETY CONCERN AND THESE BRAKE LINE FAILURES ARE NOT NORMAL WEAR AND TEAR. I HAVE HAD SEVERAL VEHICLES MUCH OLDER THAN THIS VEHICLE WHICH STILL HAVE STOCK BRAKE LINES WITH NO CORROSION. *TR

MY SPEEDOMETER RECENTLY MALFUNCTIONED AT AROUND 77,000 MILES AND I BROUGHT IT TO THE ATTENTION OF THE DEALERSHIP'S SERVICE MANAGER, JEFF BEVINGTON, AT RALLY GMC AUTO GROUP IN PALMDALE, CA (WHERE I PURCHASED THE VEHICLE NEW IN 2005). I WAS GIVEN SERVICE BULLETIN #07187C - SPECIAL COVERAGE ADJUSTMENT INSTRUMENT PANEL CLUSTER GAUGE NEEDLE FUNCTION (MARCH 20, 2009), WHICH INDICATES THE FOLLOWING: THIS BULLETIN IS BEING REVISED TO INCLUDE CERTAIN 2005 MODEL YEAR VEHICLES IN THE U.S. ADDITIONALLY, FOR U.S. 2003-2005 MODEL YEAR VEHICLES, GM WILL PROVIDE THE INSTRUMENT PANEL CLUSTER (IPC) ONLY, AT NO CHARGE TO THE CUSTOMER FOR VERIFIED FAILURES BETWEEN 70,001 MILES (110,001 KM) AND 80,000 MILES (130,000 KM). ANY ADDITIONAL COSTS, INCLUDING LABOR TO REPLACE THE INSTRUMENT PANEL CLUSTER, WILL BE THE RESPONSIBILITY OF THE CUSTOMER. DEALERS WILL BE RESPONSIBLE FOR THE RETURN OF THE CUSTOMER'S IPC BACK TO THE ELECTRONIC SERVICE CENTER. PLEASE DISCARD ALL COPIES OF BULLETIN 01787B, ISSUED SEPTEMBER 2008. THE VIN BREAKOUTS OF VEHICLES INVOLVED IN THE BULLETIN INCLUDE 2005 GMC SIERRA BETWEEN 51100001 AND 51347001. HOWEVER, JEFF BEVINGTON TOLD ME THAT SINCE MY VEHICLE IS OLDER THAN 7 YEARS AND OVER 70,000 MILES, IT IS NOT COVERED??? HE SUGGESTED I CALL THE GM TOLL FREE NUMBER (800) 222-1020 AND ASK IF THEY CAN HELP. I CALLED AND SPOKE TO DONTES WHO TOLD ME THAT GM HAS NO RECORD OF THE SERVICE BULLETIN MENTIONED ABOVE??? *TR

POWER STEERING STOPS WORKING ON SLOW RIGHT HAND TURNS. I SOMETIMES NEED TO BACK UP IN ORDER TO COMPLETE THE TURN. I ALSO END UP CROSSING INTO ONCOMING LANES IF NO TRAFFIC IS COMEING TOWARDS ME. IF THERE IS TRAFFIC I NEED TO STOP IN THE MIDDLE OF THE TURN UNTIL THE TRAFFIC CLEARS. THE "CHECK AIRBAG" LIGHT CAME ON AT 85000 MILES AFTER THE BATTERY DISCHARGED FROM THE VEHICLE SITTING TO LONG WITHOUT BEING DRIVEN. *TR

AT ANY RATE OF SPEED TRUCK WILL GO INTO REDUCED ENGINE POWER MUST PULL OVER OUT OF TRAFFIC AND KILL ENGINE WAIT A COUPLE OF MINUTES AND THEN RESTART SOMETIMES YOU CAN GO 1 MILE TILL HAPPENS AGAIN SOMETIMES 50 MILES VERY DANGEROUS SITUATION IN HEAVY TRAFFIC. *TR