2008 GMC SIERRA 1500 Complaints

I was driving in a parking structure at low speed when a loud bang went off inside the cab. The hazard lights went off, there was an acrid electrical smell, and fine dust was coming from the steering wheel area. I stopped the truck and got out to look for a collision, but there was none. When I restarted the truck, the air bag light came on and I noticed that the seatbelts were retracted and no longer functional. I was not injured, but I believe that if this had happened in traffic or on the highway, I and my passenger could have been seriously hurt. The vehicle was towed to the GMC dealership, where they identified an error with the module that sends a signal to the airbags and seatbelts to deploy. Prior to this occurrence, I had no indication that the airbag/seatbelt system was faulty or in need of service.

No accident happened as the wheel was never installed due to not meeting the load weight capacity rating of the vehicle. The wheel is marked max load 1150kg (2230 per axle) and the vehicle weight loading label shows the rear axle capacity at 2706kg. The wheel is also marked as SAE J2530 compliant but does not meet J2530 section 3.5 due to the low load capacity. These wheels are widely available in the aftermarket and list most of the 2000-2010 GM 2500HD/3500 pickups as the application but do not meet load capacity on any of them. Please note that the VIN is for a typical 2008 Sierra 2500HD pickup in a scrap yard. I do not own that vehicle. It is a weight label photo from Hollander parts finder on that pickup.

The contact owns a 2008 GMC Sierra 1500. The contact stated that after the dealer repaired the vehicle under NHTSA Campaign Number: 21V050000 (Air Bags) and GM's Emission Recall: N140581 (Carbon Monoxide Emissions), the vehicle nearly caught on fire. The contact stated that while driving at an undisclosed speed, the contact turned on the A/C, and the vehicle started shaking abnormally. Additionally, the vehicle made abnormal sounds, jerked, and stalled while driving. The vehicle was taken back to the dealer, and there was smoke coming from under the hood. Upon inspection, the dealer discovered that the catalytic convertor was extremely hot and glowing red. The dealer determined that the exhaust system and catalytic convertor needed to be replaced. The vehicle was then towed to the residence. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 151,071.

The contact owns a 2008 GMC Sierra 1500. The contact stated that while driving at 60 MPH, the spare tire detached from underneath. After a visual inspection of the underneath of the vehicle, he observed that the spare tire hoist and frame were severely corroded, potentially compromising the structural integrity of the vehicle. No warning lights were illuminated. The vehicle was not repaired. The manufacturer was not notified of the failure. The VIN was not available. The failure mileage was 197,000.

The contact owns a 2008 GMC Sierra 1500. The contact stated that while the vehicle was parked and turned off at the residence, the front windshield cracked. Upon inspection, the contact noticed that the front driver's and passenger's side air bags had deployed without impact. The vehicle was towed to the dealer, where it was diagnosed, and it was determined that a short circuit was caused by water damage in the air bag modules underneath the front driver's and passenger's side seats. The vehicle was then towed to a body shop for the air bags to be replaced; however, the replacement parts were on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 38,000.

The contact owns a 2008 GMC Sierra 1500. The contact stated that while driving approximately 75 mph when another vehicle suddenly got in front of their vehicle causing them to depress the brake pedal. The brake pedal failed to press downward. The contact had to continue to press the brakes a total of 8 times. The trailer brakes would cause the vehicle to decelerate but it would continue to accelerate and increase in speed. By the 8th attempt and with the trailer brakes activated the vehicle eventually decelerated and came to a stop. The tire pressure warning had been illuminated. The contact had not taken the vehicle to the dealer. The manufacturer was not made aware of the failure. The approximate failure mileage was 116,000.

Tire sizes: 245/70r17. Three tires went bad between November 2022 and March 9th 2023. First tire, the front right, replaced because its outside tread was going bad really quickly. I could see the metal sticking out of it. Two tires need replacing because they are bulging. The back left tire bulged so bad my car was shaking up and down until I took it off. Thought everything was fine but the back right began to shake the car two days later.

left side frame is defective, I have welded 4 patches on frame.from the bend by wheel well and fuel tank to front wheel well all by were frame has bracket welded and bottom of inside of frame . if hit on left side can cause frame to crumble and fuel tank to explode. it needs to be looked at for recall. i have spoken to many oweners of 2007 to 2009 gm trucks. and all have same problem. my truck only has around 112 thousand on it this is 3rd year i had to repair.

Cranked my truck yesterday and put it in drive. Slowly drove about 300 feet and the pretensioner’s discharged in my seatbelts. I fortunately did not have it on yet, but the seatbelts are now unusable.

UNKNOWN. Front side passenger safety belt won't buckle, the latch appears to be blocking the buckle when in the open, unlatched position.