2011 GMC SIERRA 1500 Complaints

The main body frame is completely rusting through from under the drivers side door back past the fuel tank. It is rusting through on the passenger side as well. The large amounts of rust have caused other issues throughout the entire body of the truck as well as rusting of other components. The frame of this truck will need to be replaced as there is no way to repair it or the vehicle becomes scrap. This vehicle is available for inspection. These issues were not visible when purchased from the dealer. This issue gradually became visible after the rust and undercoating wore away that had been applied previous to our purchase from a known dealership.

Just noticed that the Frame is rusting badly. It is available for inspection upon request. I see that the Chevy Silverado has the same problem and that a recall exists for it, but not for the GMC Sierra, which is virtually the same truck. My safety or the safety of others can be put at risk if the frame were to fail. The problem has not been reproduced or confirmed by a dealer or independent service center. The vehicle or component has not been inspected by the manufacturer, police, insurance representatives or others. Unknown about any warning lamps, messages or other symptoms of the problem. No failure yet.

I have a 2011 GMC Sierra Standard Cab pickup truck. I’m a disabled veteran and have this as my primary vehicle. The frame has a huge hole that developed and will need repair. The frame is rotted and soon will not pass inspection. The truck looks brand new but Engin compartment, frame and tow parts have rotted. I had the leaf spring separated from rotted frame on the highway. I swerved and almost died. GMC must replace the frame to make this right. Soon I will have no truck after giving GMC so much money. It’s criminal what they have done.

11/2022 shift cable separated from shift lever; preventing ability to put vehicle Into park. Retaining clip deteriorated allowing separation. Fortunately it happened when leaving parking garage and not moving fast. Was able to refasten using zip-tie until new retaining clip arrived at auto parts store.

Dashboard has completely cracked and fallen apart. I fear safety if airbag were to deploy, that there would be plastic pieces that could directly damage passengers in the car. I am also very disappointed at the cost to repair the dash and the value that is lost from the truck because of the cracked dash issue.

Takata recall. The contact owns a 2011 GMC Sierra 1500. The contact received notification of NHTSA Campaign Number: 21V054000 (Air Bags) however, the part to do the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I towed a U-Haul trailer for four hours from Winter Springs, FL to Tallahassee, FL 08/18/2022. On the way back to Winter Springs, FL on 08/21/2022, I began to hear the dings and a message to service the trailer brake system. I had the vehicle looked at to determine the problem. The fuse was determined to be good, the ground wire was secure and not damaged, and the relay was functioning. I have been told that it may be a defective wire harness which could lead to other safety issues while operating the vehicle. The constant dinging and the blocking of vital messaging by the warning is a distraction and safety issue. A recall should be issued to correct this safety defect.

Frame rusting away and cracking. On left side in front of EVAP canister. Noticed it on 8/14/22.

The contact owns a 2011 GMC Sierra 1500. The contact stated that the air bag warning light was illuminated. The contact later received notification of NHTSA Campaign Number: 21V054000 (Air Bags). The vehicle was taken to the dealer where the front passenger's side air bag was replaced; however, the air bag warning light remained illuminated. The dealer informed the contact that the failure could be associated with the front driver's side air bag; however, there was no recall for the front driver's side air bag. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 72,000.

The contact owns a 2011 GMC Sierra 1500 equipped with Goodyear Tires, Tire Line: Wrangler 12th Grade Pro, Tire Size: 265/70/R17, DOT Number: PJAH35HV3518. The contact stated while her friend was driving approximately 40-45 MPH with her seated in the passenger’s side seat, the passenger's side front tire experienced tread separation. The passenger's side curtain airbags, the driver's side curtain airbags, and the airbag located at the edge of the driver's seat deployed. The emergency fuel shut-off valve failed to engage. There were no warning lights illuminated. The contact sustained injuries on her right arm, and her friend sustained injuries to the face. Medical assistance was not needed. The driver veered to the side of the roadway. The driver was able to drive the vehicle to the nearby hotel as the tire was not totally deflated. The contact stated that only the outer layer of the tire had separated. Upon attempting to use both the front driver's seat belt and the front passenger's seat belt the next morning, the contact noticed that they had seized and would not retract nor extend. The vehicle was not diagnosed or repaired. The dealer and manufacturer were not notified of the failure. The tire dealer and manufacturer were not notified of the failure. The tire was replaced with a spare tire. The tire was a replacement tire. The vehicle failure mileage was approximately 302,984. The tire failure mileage was approximately 15,000.