2021 GMC SIERRA 1500 Complaints

2021 6.2L GMC Sierra Denali. Has the L87 engine that is recalled but yet my truck doesn’t fall under the recall although the recall is for 2021-2024 engines. Everything that the engine recall states is the issue with my truck, I have service report from dealership stating that there is wear/breakage of cam shaft/crank shaft amongst other things including cylinder 3 and 5 misfiring , bearings broken , filings in the oil , banging in the engine and safety lights on. My local GMC dealership recommended that the only acceptable action was to replace the engine at my cost of course. This is unacceptable of a supposed reputable large corporation not caring about the “little guy”. The truck only has 136000 kms on it and I was only going 60 km/hr when this happened. Please help as I feel GM knows this engine is faulty but somehow has managed to escape a recall on my vin number

A small drip started approximately 18 months ago from top middle of left side window in rear slider. It was first mistaken as blow by from car wash. Leaking slowly progressed to dripping down middle of both side windows in rear sliders. Leaking progressed to drops coming from under headliner then dropping on side portions of rear slider. It then would drip onto seat or behind seats. Leakage was consistent with TSB 18-NA-383 as well as 20-NA-142 and 24-NA-103. In discussing with dealership, they recommended likely microfractures and sealant process called for in bulletins would likely resolve matter. As due diligence, spoke with independent glass shop to confirm. Glass shop indicated would not know until physically checked cracks/source of leak and looked for damage but based upon photos it appeared to be several frame fractures consistent with bulletins. I arranged rear slider replacement through independent shop. Upon pulling OEM slider, numerous stress cracks and fractures were noted. These included stain marks from water intrusion. Photos included showing original leaking as well as sample of cracks in original OEM plastic frame portion.

The contact owns a 2021 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the transmission was shuddering, especially while driving uphill. The dealer was contacted, and the vehicle was diagnosed and determined to have a failure associated with a GM TSB for the incorrect transmission fluid inside the transmission reservoir. The vehicle was not yet repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 38,875.

Engine temp rises way above mid-level and will stay there for several minutes before cooling back down to normal temps. 2 different mechanic shops have told me it's the coolant control valve, but want $2500 to fix it. This service bulletin is for the same year, make, model, and motor as my truck, but the dealership said it wasn't covered.

P1010 and P2B86 engine code, constant cooling fan on engine. Confirmed by dealership, quoted for coolant control valve. VIN not included in special coverage N252508341 for this known issue. Limited engine power alert, unable to maintain speed on highway. Dangerous condition traveling under speed limit.

2021 Harley Davidson Sierra 4WD, 6.2L L87. Started the truck in the morning and immediately heard intermittent, very loud banging noise coming from engine. Shut truck down quickly and had it towed to dealer. Diagnosis was bent pushrods & failed lifters which were replaced under warranty. Factory warranty expired only 4 months after this failure, and the recall does not include my VIN so I did not get an extended warranty or any other protection. GM has yet to even reimburse the tow bill. Completely unacceptable for a truck that was well over $100k when new.

CORRODED GROUNDING STRAP FAILED CYLINDER 5 GLOW PLUG CIRCUIT CRACKED AND SEPARATED EXHAUST BACKPRESSURE VALVE

The contact owns a 2021 GMC Sierra 1500. The contact stated that while driving approximately 70 MPH, the vehicle suddenly lost motive power, decelerated, and failed to properly accelerate while depressing the accelerator pedal. The check engine warning light was illuminated. After exiting the freeway, the vehicle stalled. The vehicle was towed to the residence and then later towed to the dealer for assistance. The contact was informed that there were metal shavings inside the engine oil. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The manufacturer was not yet contacted. The failure mileage was 149,000.

The vehicle has about 38000. The warrantee expired about 6 months ago. About three weeks ago I started the engine, it sounded like a cement mixer filled with rocks. I had it taken to my dealer. They investigated the problem and determined that it has bad lifters and bent push rods. The dealer told me that it is a known problem but it is not covered by the current 6.2l engine recall

Vehicle: 2021 GMC Sierra SLT | VIN: [XXX] Dealership: Carl Black GMC Roswell, GA (11225 Alpharetta Hwy, 30076) | Invoice #[XXX] | Service Date: [XXX] Paragraph 1 – Suspension Hazard: Dealership diagnosed a worn left upper ball joint (popping sound on left turns) and installed Rough Country aftermarket upper control arms on my stock-height Sierra SLT. These arms are designed for lifted suspension and alter factory caster/camber geometry, placing extreme stress on ball joints. This can cause sudden ball joint separation, wheel collapse, and total loss of steering control at speed. The dealership admitted on the invoice they "could not find branding" on original parts and chose non-OEM lift components without my consent or any safety disclosure. Paragraph 2 – Brake Failure & No Safety Warning: The same service included a full front/rear brake job (pads + resurfaced rotors) using their certified technicians and parts. After pickup, the brakes failed to operate properly. When I returned, the service manager refused to correct their own workmanship and instead quoted $1,900 to repair the very brakes they just serviced. Most critically, at vehicle pickup they issued no written or verbal safety warning—no "do not drive" instruction—despite the brakes being knowingly compromised, endangering me and the public. Paragraph 3 – Requested Action: The service manager was unprofessional, condescending, and refused accountability. I request an immediate NHTSA investigation into Carl Black GMC's unauthorized use of lift-kit suspension parts on stock vehicles, failure to warranty their own brake service, and reckless omission of safety warnings at delivery. This dealership pattern poses an imminent public risk. Please escalate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)