2023 GMC SIERRA 1500 Complaints

I have a 2023 6.2L V8 GMC AT4. I have ~ 27,000 miles on the truck. On 2/1/2025, I was driving down the interstate going 78 mph and I lost all power to the truck. This was a MAJOR safety issue because I could only "coast" to a stop. I fortunately was able to get to the emergency lane and call a tow truck. I put others at risk because I had no choice but to move over. I had my truck towed to Brookfield Buick GMC dealership. Because I had no power, I had no HEAT. I sat for 1.5 hours before a tow truck could come to me. I was freezing because it was 20 degrees outside. The dealership told me that I had massive engine failure "seizure", which will require a NEW engine. I had no warning lamps or messages prior to the failure. This was a BIG safety issue and I'm fortunate I didn't get injured.

1) [XXX] - Was driving on the interstate at 65 - 70 mph when the truck suddenly shut off and shifted to neutral. I was in the far left lane and had to coast thru 2 lanes of high speed traffic to the right shoulder before the truck stopped coasting. Once I coasted to a stop on the right shoulder of the interstate, I tried to crank the truck up a couple of times and it finally cranked and I proceeded on to my destination. When I reached my destination and was attempting to park, the truck shut off again and would not crank after that. I then called roadside assistance to send a wrecker and take it to my local GMC dealer in Montgomery, Alabama. 2) My safety and others was put at risk when the truck, without warning, shut off and lost power while driving at 65-70 mph in heavy interstate traffic causing the truck to suddenly decrease speed and having to maneuver through traffic , without power, while coasting to the side of the road. 3) [XXX] - The service department at Mullinax GMC in Montgomery, Alabama called me about a week later to say the engine had "LOCKED UP" and that they had contacted GMC to begin the process of getting it fixed. They indicated that this was not uncommon with this model truck, and that it happens sometimes. 4) There were absolutely no warning lamps, messages, sounds or any other symptoms of the problem prior to the engine failure. I was caught completely off guard when the engine shut off. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Complete engine failure while driving on interstate. Vehicle went into neutral. After rolling to a stop on highway. Vehicle would not go into gear. Tow was unable to put vehicle into saftey mode and had to drag vehicle onto tow bed. At dealership techs were also unable to get vehicle to turn on or go into gear. Dealer advised the engine was complete seized. This happened while traveling on the highway there was no warning or signs of something being wrong. Vehicle simply lost all power and went into neutral while traveling 70mph with 37k on the odometer.

I started my truck on [XXX] and after driving less than 3 miles the check engine light came on and then light for traction control needs service came on. I stopped and notice engine was idling weird. So I called dealer and they recommended I bring in. I proceeded to drive but could not drive over 40 mph as the engine would not idle past that and started hearing clicking noises. I slowly get the vehicle into service at McKinney GMC Buick in McKinney, TX. Two days later I get a call stating that engine needs to be replaced due to bearing failure and excessive metal in oil and oil filter. Which damaged the engine and is not repairable. The service center informed that this is common with my 6.2 L V8 and there are four other trucks same issues. The engine is on back order and don't know when I will be able to get my vehicle back. This appears to be a known issue for GMC and they are not telling people who could be in danger on road at any moment without warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Valve Body failure. Truck rear wheels lockup during failure as transmission was unable to get past 6 gear, sending truck into limp mode at highway speeds. Codes P0700 & P0747, no issues before failure. Dealership has replaced the Valve Body, but the part number model MQC part# 24065353 has not been redesigned and feel this will be a continuous issues to saftey not knowing when it will fail again.

Traveling on the interstate at highway speeds of 75mph and the engine spun a bearing resulting in complete engine failure.

My engine started knocking while on vacation in Indiana (I live in TX) I took it to dealer [XXX] and it was diagnosed with bearing failure. Engine "ordered" on [XXX]. It is currently [XXX] still with no ETA for new engine. Stuck with a small/standard SUV (chevy equinox) for rental in place of my $74,845 Truck which is not a large enough vehicle for my daily usage, but no solutions or help added from GM customer service or dealership. There were no warning signs other that me hearing the noise. My GM app still states no current issues with your vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving on the interstate, my vehicle started losing speed. I pulled over to the shoulder of the interstate and put in neutral so I could coast further to the exit ramp where I would be in a safer location. My vehicle has 14037 miles on the odometer and has now gone through 2 engines. It has always been serviced by GM.

The trucks engine completely shut down while going approximately 60 MPH while merging onto the highway. The trucks dash flashed multiple times, a ticking noise was heard, it put itself in neutral, and shut the engine off. All power was lost. I did still have brakes. Safety was a concern as there was a vehicle behind me entering the highway too. Cars to my left as well passing at highway speeds. Once I got the vehicle stopped on the shoulder of the highway it put itself in park. It would not restart. The vehicle was towed to a local GMC dealer. There were no warning lights of any kind that came on. No indication that there was a problem. A couple days later I was informed that the truck would need an entire new engine upon inspection. I was also told by the dealer that the truck had no oil at all in it. The engine consumed it internally by their evaluation.

While idling, I noticed a knocking sound. Dealership found that rockers on both banks not rotating from lifter failure. Dealership replaced both lifter banks. Luckily this was caught early and was corrected for engine failure.