2001 GMC SIERRA 1500 Complaints

A SECOND BRAKE LINE RUPTURED AS A RESULT OF RUST CORROSION CAUSING THE BRAKES TO FAIL AT 76,158 ORIGINAL MILES. I NARROWLY AVOIDED A REAR END COLLISION INTO ANOTHER VEHICLE CARRYING A FAMILY WITH CHILDREN. THE VEHICLE WAS TOWED TO A GM DEALER WHERE IT WAS DIAGNOSED. THE COST ESTIMATE FROM THE GM DEALER TO REPLACE ALL OF THE RUSTED BRAKE PARTS IS $5,125.00 THIS IS THE SECOND INCIDENT OF BRAKE FAILURE AS A RESULT OF RUSTED OUT BRAKE LINES. THE FIRST INCIDENT OCCURRED AT 73,870 ORIGINAL MILES. A CALL WAS MADE TO GMC IN AN EFFORT TO SEEK ASSISTANCE WITH THE REPAIR AMOUNT AND THEY ADAMANTLY REFUSED ANY ASSISTANCE. *TR

TL* THE CONTACT OWNS A 2001 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, HE APPLIED THE BRAKES AND THE PEDAL DEPRESSED TO THE FLOOR. THE VEHICLE COASTED TO A STOP. THE CONTACT EXAMINED THE MASTER CYLINDER AND NOTICED THAT ALL THE BRAKE FLUID LEAKED FROM THE VEHICLE. THE CONTACT ALSO NOTICED THAT THE BRAKE LINES WERE FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. IN ADDITION, THE CONTACT STATED THAT HE REPLACED THE FUEL LINES AND PUMPS IN THE PAST DUE TO CORROSION. THE FAILURE AND CURRENT MILEAGES WERE 150,000.

THE MASTER CYLINDER BRAKE LINE RUSTED THROUGH CAUSING THE BRAKES TO FAIL. THE TRUCK WAS TOWED BY AAA EMERGENCY SERVICE WHERE THE BRAKE FAILURE WAS DIAGNOSED. THE COST TO REPLACE THE FAILED BRAKE LINE WAS $270.79 THE REST OF THE UNDER-CARRIAGE OF THE TRUCK IS BADLY RUSTED AS WELL. *KB

STOPPED IN FRONT OF HOUSE AND WHEN ALMOST STOPPED THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD NO BRAKES EXCEPT FOR A VERY SLIGHT "DRAG". I STOPPED AND LOOKED UNDER THE TRUCK AND SAW FLUID COMING FROM UNDER THE FRONT OF VEHICLE. IT APPEARED TO BE BRAKE FLUID AND IT WAS TRACED TO A METAL BRAKE RUNNING ACROSS THE FRONT FRAME MEMBER TO THE BRAKE ON THE FRONT PASSENGER WHEEL. THE LINE WAS EXTREMELY RUSTY AND LEAKING PROFUSELY. UPON FURTHER INSPECTION ALL METAL BRAKE LINES ARE SEVERELY RUSTED AND NEED REPLACED. I HAVE SEEN MANY VEHICLES BUT NONE WITH THIS AMOUNT OF RUST ON EVERY PART OF ALL LINES AND THE FRAME. THIS TRUCK IS 10 YRS OLD AND IS NOW UNSAFE TO DRIVE UNTIL ALL BRAKE LINES ARE REPLACED AT SUBSTANTIAL COST AND EFFORT. AS YOU WOULD EXPECT I AM NOT PLEASED BUT CONSIDER MYSELF VERY LUCKY. I COULD HAVE KILLED SOMEONE OR MYSELF. PLEASE WARN OTHERS THIS HAZARD EXISTS. *TR

TL* THE CONTACT OWNS A 2001 GMC SIERRA 1500. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND NOTICED THE FUEL GAUGE INDICATOR FLUCTUATED ERRATICALLY. THE FAILURE OCCURRED AT ANY SPEED THE VEHICLE WAS BEING DRIVEN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE FUEL PUMP WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MECHANIC ALSO EXPRESSED THAT THE CONSTANT MALFUNCTION WAS A COMMON ISSUE WITH HIS VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

TL* THE CONTACT OWNS A 2001 GMC SIERRA 1500 HD. THE CONTACT STATED THAT THE BRAKE PEDAL WAS ABNORMALLY DEPRESSED INTO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER DIAGNOSED THAT FOUR BRAKE LINES WERE RUSTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 88,154.

TL* THE CONTACT OWNS A 2001 GMC SIERRA 1500. THE CONTACT STATED THAT THE FUEL GAUGE MALFUNCTIONED AND PROVIDED ERRONEOUS READINGS. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE SENDING UNIT INSIDE OF THE FUEL TANK WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 83,000.

I HAVE A 200 GMC SIERRA AND HAVE FOUND NOW THAT ALL THE BRAKE LINES HAVE RUSTED THROUGH, AND THE FRAME IS SO BADLY RUSTY IT IS NOT SAFE TO DRIVE. AS I REVIEW THE INTERNET THERE ARE HUNDREDS AND HUNDREDS OF SIMILAR PROBLEMS, MANY RESULTING IN CRASHES. YOU MUST MAKE GMC FACE UP TO THIS PROBLEM AND GET THESE DANGEROUS VEHICLES OFF THE ROAD. *TR

WHILE BLEEDING THE REAR DISK BRAKE CALIPERS IN THE DRIVEWAY, THE STEEL HYDRAULIC TUBING FROM THE BRAKE MASTER CYLINDER TO THE REAR BRAKE CALIPERS BURST DUE TO EXCESSIVE RUST. THE RESULT WAS A QUICK LOSS OF HYDRAULIC BRAKE FLUID. HAD THIS HAPPENED ON THE HIGHWAY, ALL BRAKING WOULD HAVE BEEN LOST DUE TO THE FACT THAT THE HYDRAULIC FLUID RESERVOIR IS NOT DIVIDED INTO FRONT/REAR COMPARTMENTS. AFTER THE LEAK, THE BRAKE PEDAL WENT RIGHT TO THE FLOOR. *KB

WHILE SLOWING DOWN AT MY NEIGHBORHOOD ELEMENTARY SCHOOL I APPLIED THE BRAKES AT THE STOP SIGN. THE BRAKE PEDAL BEGAN TO PULSE. I DROVE AROUND THE BLOCK TO MY HOUSE. UPON INVESTIGATION, A 12" SECTION OF THE INSIDE OF MY LEFT REAR BRAKE ROTOR BROKE OFF. WHEN THE ROTOR CONTINUED TO TURN, THE REMAINING SECTION OF THE BRAKE ROTOR CAUGHT THE CALIPER PISTON AND SHEARED IT OFF. LUCKILY, I WAS ONLY DRIVING AT 18 MPH. IF I HAD BEEN ON THE HIGHWAY DRIVING 55-65 MPH, THE LOSS OF BRAKING WOULD HAVE BEEN CATASTROPHIC. THE PIECE THAT BROKE OFF WAS COVERED WITH RUST ON THE INSIDE - THE SIDE MANUFACTURED WITH COOLING OPENINGS WHICH ARE LOCATED BETWEEN THE INSIDE AND OUTSIDE OF THE BRAKE ROTOR. *KB