2001 GMC SIERRA 1500 Complaints

Truck has just over 150k miles. Maintained well and garaged when possible. 1) Noticed a fuel smell from the driver side door area and after parking for a long weekend, a small pool of liquid formed in front of the driver side rear wheel. It was fuel dripping from the line leaving the evap canister that had rusted through. Resulted in a $600 repair to replace all rusted fuel lines so as to eliminate the risk of fire. 2) When approaching an intersection to make a left turn and slowing down the brake pedal pushes to the floor with no stopping power at all. Used the engine/trans in manual mode to slow the truck down and avoid an accident. Driver side brake lines are blown out in multiple spots near the ABS module due to corrosion. Potential cost based on research is in the $1000 ballpark. This level of rust on critical vehicle components is irresponsible and potentially deadly. GM needs to take this more seriously and realize that their cost-cutting measures are putting people and their families in grave danger.

MY ANTI LOCK KEEP KICKING IN, THE PANHEAD BY GAS TANK IS COMPLETELY SHOT AND THERE IS A BOX BY THE GAS TANK FOR EMISSIONS AND NOT ABLE TO GET 1 AND THE FRAME IN THE FRONT IS SHOT ALSO ALONG WITH THE BODY THAT'S COMPLETELY SHOT AND THE GAS GAUGE KEEPS TELLING EMPTY 1 TIME AND THEN IT GOES TO FULL TO EMPTY EVEN AFTER I FILL IT UP...

THE ABS AND BREAK SYSTEM WARNING LIGHT HAS BEEN COMING ON AND STAYING ON. I LOST MY BREAKS LEAVING A PARKING SPOT AT MY LOCAL WALMART AS I WAS PULLING OUT OF A PARKING SPOT! WE THEN MADE APPOINTMENT FOR THE BREAK SYSTEM TO BE CHECKED/REPAIRED. THE ABS CONTROL SYSTEM LIGHT WENT OFF FOR AWHILE BUT THEN COMES BACK ON EVEN AFTER THE REPAIR OF SAID REPAIR TO BREAK LINES. MY TRUCK ALSO HAS NO FUEL GAUGE THAT DOES NOT WORK. WITH THESE ISSUES ON MY VEHICLE MAKES IT VERY SCARY TO DRIVE AND MAKES DRIVING LIMITED. I AM NOT ABLE TO DRIVE MY TRUCK LONG DISTANCES DUE TO CONCERNS OF SAFETY AND POSSIBLY OF ABS WARNING LIGHT, BREAK ISSUES, AND FUEL GAUGE! I WAS DRIVING MY TRUCK TO PICK ONE OF MY DAUGHTERS UP FROM SCHOOL TO LOSE POWER WHILE PUSHING ON GAS THEN SOME JERKING AND A FOUL SMELL OF RUBBER BURNING COMING FROM THE FRONT RIGHT TIRE AREA. I THEN HAD SOMEONE LOOK AT THE TRUCK AND WAS TOLD THAT WHAT EVER IT WAS HAPPENING THAT EVERYTHING LOOKED OKAY AND IT WAS POSSIBLE JUST A BREAK STICKING. IT HAS HAPPENED 3 DIFFERENT TIMES. MY TRUCK STILL HAS APPROXIMATELY 98,000 OR SO MILES ON IT. THIS TRUCK ALSO HAS BAD CORROSION ON BOTTOM BASEBOARDS OF THE TRUCK. I SAW BELOW THAT I AM ASKED FOR SPECIFIC DATE OF ISSUES. I CAN NOT PROVIDE SPECIFIC DATES SINCE THERE HAS BEEN SO MANY THINGS WRONG WHICH HAS HAPPENED AT DIFFERENT TIMES.

ABS MESSAGE LIGHT CAME ON CONSISTENTLY AND DUE TO THE SAFETY ISSUE EXPLAINED BY MY MECHANIC SHOP, I HAD THE WHEEL SPEED SENSOR CHANGED AND NOW ABOUT 6 MONTHS LATER THE ABS MESSAGE LIGHT IS NOW APPEARING IN THE MESSAGE BOARD AGAIN INTERMINTENTLY. I READ WHERE GMC STARTED A RECALL ON SEPTEMBER 22,2005 FOR THIS SAME PROBLEM WHICH CALLED( GM RECALL # 05068) BUT ONLY FOR "SALT BELT STATES" "SERVICE BRAKES, HYDRAULIC:ANTILOCK".INTERESTINGLY MY STATE WAS LEFT OFF OF THE LIST. I CALLED GMC AND THEY INDICATE THERE WAS NO SUCH RECALL AND SUGGESTED I CALL NHTSA. I HAVE NOW NOTICED THAT MY BRAKES LOCK UP AND DO NOT HAVE THE ANTILOCK SYSTEM OPERATING.

BRAKE LINES RUSTED OUT UNDER DRIVERS SIDE CAB. TRUCK STUCK IN DRIVEWAY. LUCKY IT DID NOT HAPPEN ON HIGHWAY WILL COST ALMOST AS MUSH AS TRUCK IS WORTH TO HAVE ALL NEW BRAKE LINES INSTALLED

RUSTED OUT FUEL LINES. HAD TO REPLACE ALL FUEL LINES. RUSTED OUT BRAKE LINES. BRAKES GAVE OUT WHILE DRIVING. LUCKLY NO ACCIDENT. HAD TO REPLACE ALL BRAKE LINES.

TL* THE CONTACT OWNS A 2001 GMC SIERRA 800 (NA). ON SEVERAL OCCASIONS, THE CONTACT NOTICED FLUID LEAKING FROM THE STEERING GEAR ASSEMBLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HILEY BUICK GMC (3535 W LOOP 820 S, FORT WORTH, TX 76116 (817) 632-8800 WHERE IT WAS DIAGNOSED THAT THE STEERING GEAR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. ON ANOTHER OCCASION, THE CONTACT NOTICED THAT THE LEAKAGE FROM THE STEERING GEAR ASSEMBLY FAILED AGAIN. THE VEHICLE WAS TAKEN BACK TO HILEY BUICK GMC WHERE IT WAS THEN DIAGNOSED THAT THE STEERING GEAR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. DURING THE THIRD FAILURE, THE CONTACT PARKED THE VEHICLE IN HIS GARAGE AND NOTICED A TRAIL OF FLUID ON THE GROUND. UPON FURTHER INSPECTION, HE NOTICED FLUID COMING FROM THE STEERING AGAIN. THE VEHICLE WAS THEN TAKEN BACK TO HILEY BUICK GMC WHERE IT WAS DIAGNOSED THAT THE STEERING GEAR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT WITH A DIFFERENT PART NUMBER (19330428). THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 146,650.

LOST ALL BRAKES ON MY 01' GMC SIERRA 1500 SLE 4X4 WHILE BRAKING ON AN OFF RAMP, PEDAL WENT ALL THE WAY TO THE FLOOR. BRAKE LINES APPEAR TO BE COMPLETELY RUSTED OUT, WHICH DOESN'T MAKE SENSE WHEN I HAVE A 5 YEAR OLDER HONDA CIVIC, WITH 110K MORE MILES ON IT, AND THE BRAKE LIKES DO NOT LOOK NEAR AS BAD. BOTH SPENT THEIR LIVES IN MINNESOTA / WISCONSIN. AFTER DOING SOME GOOGLING, IT APPEARS THIS IS EXTREMELY COMMON WITH 2000-2003 GM TRUCKS. IF THIS WASN'T A MANUFACTURING DEFECT, WOULDN'T ALL UNCOATED BRAKE LINES RUST OUT AT SIMILAR RATES, IN THE SAME CONDITIONS? MIND BOGGLING THAT GM IS ABLE TO GET AWAY WITH NOT HAVING TO SPEND THE CASH TO CORRECT THIS PROBLEM. AS IF THAT MONEY IS WORTH MORE THEN THE PERSONS LIFE. *TR

MANIFOLD BOLT(S) BROKEN. HEARD IT'S A COMMON THING. REALLY DISAPPOINTS ME ABOUT MY TRUST IN GM.

WAS ON MY WAY HOME, WHEN I WENT TO TURN LEFT ONTO MY ROAD. MY BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I HAD TO ACCELERATE ACROSS A MAIN ROAD BECAUSE A VEHICLE CAME UP OVER THE HILL AT ME AND I COULD NOT STOP THE TRUCK. I COASTED DOWN A HILL UNTIL THE TRUCK STOPPED ROLLING. WHEN IT WAS TOWED TO A SERVICE STATION THE MECHANIC NOTED A RUSTED OUT HOLE IN MY BRAKE LINE. THIS IS THE 2ND TIME THIS HAS HAPPENED. THE LAST TIME WAS IN 2013. YET THE MANUFACTURER DOES NOTHING TO ADDRESS THIS!!!!!!!