2001 GMC SIERRA 1500 Complaints

THIS PROBLEM CONCERNS MY 2001 GMC SIERRA AND GM'S RECALL NUMBER 05068. THE RECALL CONCERNS THE ABS AND A RUST PROBLEM. I HAD THE RECALL PERFORMED ON OCT. 19, 2005 AND THERE WAS 47,249 MILES ON THE ODOMETER. I NOTICED A BRAKING PROBLEM LAST WEEK WITH MY TRUCK. AFTER DOING A SEARCH ON THE INTERNET, I DECIDED IT WAS PROBABLY A ABS SENSOR PROBLEM. I TOOK IT TO THE SAME DEALER THAT DID THE ORIGINAL RECALL. THEY CHECKED WITH GM REGIONAL MANAGER AND SAID IT WAS ALREADY COVERED ONCE AND WOULDN'T COVER IT A SECOND TIME. I HAD THE REPAIR DONE AT THE DEALERSHIP ON DEC. 8, 2010 AND THE MILEAGE WAS 65,849. SO THE EFFECT OF THE RECALL ONLY LASTED 18,600 MILES. I KNOW 5 YEARS HAVE PAST, BUT THE SAME ISSUE IN THAT FEW MILES? I SENT AN EMAIL TO GM ON DEC. 9 AND THEY PHONED ME THIS MORNING. SAID THE VEHICLE AGE WAS SUCH THAT THEY WOULDN'T DO ANYTHING. IF I HAD 150,000 MILES OR SO ON THE TRUCK, I WOULDN'T THINK THAT MUCH ABOUT THIS. HOWEVER, THIS IS A PROBLEM THAT GM ISSUED A RECALL ON AND FROM WHAT A UNDERSTAND, THE ORIGINAL RECALL DID NOTHING BUT REMOVE RUST FROM THE SENSOR AND TREAT THE SURFACE. I WOULD THINK A RECALL WOULD LAST MORE THAT 18,600 MILES. I DON'T KNOW IF YOU HAVE HAD ANY OTHER PEOPLE WITH THE SAME CONCERN ABOUT THE RECALL ONLY STALLING A PROBLEM LATER ON DOWN THE ROAD, BUT WANTED TO MAKE YOU AWARE OF THE CONCERN I HAVE. THE BRAKES WILL FAIL AT LOW SPEEDS WHEN THEY ARE APPLIED AND THE MESSAGE CENTER IN THE DASH DOES NOT GIVE ANY MESSAGE. THANK YOU. *TR

EXHAUST MANIFOLD BOLT BREAKAGE,I'M WRITING IN REGARDS TO MY 2001 GMC SIERRA W/5.3 LITER MOTOR,I HAVE RECENTLY DISCOVERED A BOLT BROKEN OFF ON MY HEAD THAT MOUNTS MY EXHAUST MANIFOLD IS A DEFECTIVE OR INFERIOR PRODUCT USED BY GMC THIS REPAIR SHOULD NOT BE NECESSARY FOR ANY VEHICLE IF THE PROPER MATERIALS WERE USED DURING ORIGINAL ASSEMBLY OF THE VEHICLE BY GMC OR ANY OTHER COMPANY IN THAT REGARD,THIS REPAIR IS A VERY EXPENSIVE ACCORDING TO MY MECHANIC TO THE SUM OF $760+TAX TO REPAIR AND IF IT IS NOT FIXED IT CAN LEAD TO CATALYTIC CONVERTER FAILURE AMONGST OTHER EMISSION FAILURES AS WELL AND POSSIBLY FIRE IN THE ENGINE COMPARTMENT AS WELL DUE TO EXCESSIVE HOT EXHAUST HEAT ESCAPING FROM THE BROKEN BOLT AREA INTO ENGINE COMPARTMENT,AS FOR THIS COMPLAINT I HAVE DONE SOME RESEARCH ON THIS MATTER AND HAVE FOUND A LARGE MAJORITY OF OTHER GMC OWNERS WITH THIS SAME PROBLEM AND ARE NOT VERY HAPPY WITH GMC'S INABILITY TO OWN UP TO RESPONSIBILITY AS A MANUFACTURER TO FIX THIS OBVIOUS AND EXPENSIVE DEFECT DUE TO INFERIOR OR IMPROPER MATERIAL USED ON THESE VEHICLES,SO ANY HELP WITH THIS MATTER WOULD BE GREATLY APPRECIATED BY ALL GMC OWNERS AFFECTED BY THIS CONSISTENT PROBLEM.. *TR

THE FUEL GAUGE BEGAN JUMPING FROM FULL TO EMPTY REGARLESS OF THE ACTUAL AMOUNT OF FUEL IN THE TANK. I TOOK GM'S RECOMMENDATION TO PUT THEIR FUEL SYSTEM CLEANER INTO THE GAS TANK TO CLEAN THE CONTACTS ON THE FUEL SENDING UNIT. APPROXIMATELY 6 MONTHS LATER, THE CATALYTIC CONVERTER PLUGGED TO THE POINT THAT THE VEHICLE WOULD NOT RUN AND IT HAD TO BE REPLACED. NOW TOLD THAT ONLY WAY TO FIX THE FUEL GAUGE IS TO PULL THE GAS TANK AND REPLACE THE SENDING UNIT. SHOULD BE A RECALL FOR THIS FAULTY SENDING UNIT AND THE "QUICK FIX" THAT MANY PEOPLE PROBABLY TRY. APPROXIMATELY $400 TO FIX SENDING UNIT BECAUSE IT'S BUILT INTO THE GAS TANK, AND APPROXIMATELY $1000 TO REPLACE THE CATALYTIC CONVERTER.

BRAKING SYSTEM BEGAN FAILING AT LOW SPEEDS (< 10 MPH), ALMOST CAUSING ME TO REAR END VEHICLES WHEN TRYING TO STOP. TOOK THE VEHICLE TO A DEALER, WHO CLEANED THE WHEEL SPEED SENSORS AT A COST OF $110. ONE MONTH LATER, THE BRAKES BEGAN FAILING AGAIN AND AFTER RESEARCHING ON-LINE, FOUND A GM RECALL FOR 1999-2002 GMC SIERRAS. CONTACTED GM BUT WAS INFORMED ONLY VEHICLES WITH CERTAIN VIN #'S ARE INCLUDED, AND MINE IS NOT ONE OF THEM. I HAVE CHILDREN AND FREQUENTLY DRIVE IN SCHOOL ZONES AROUND SCHOOL BUSES AND CHILDREN AT LOW SPEEDS (<15 MPH). THIS IS A VERY DANGEROUS SITUATION BECAUSE THE VEHICLE WILL NOT STOP.

DRIVING AT APPROXIMATELY 35 MPH, APPLIED BRAKES WHEN APPROACHING A RED LIGHT. BRAKE PEDAL WENT DOWN TO THE FLOOR, TRUCK WENT INTO THE INTERSECTION AND FINALLY CAME TO A STOP. THERE WERE NO INDICATION OF PROBLEM BEFORE THIS OCCURRED. TRUCK TAKEN TO A REPAIR SHOP. ALL BRAKE LINES WERE RUSTED AND WERE REPLACED. I REQUESTED THAT THE SERVICE STATION SAVE THE RUSTED PARTS WHICH ARE NOW IN MY GARAGE. *TR

THE ABS WARNING LIGHT COMES ON INTERMITTENTLY. TROUBLESHOOTING AND RESEARCH POINTS TO THE LIKELY FAILURE OF THE ABS SENSORS IN THE HUB OF THE LEFT AND RIGHT FRONT WHEELS. THE ABS WARNING LIGHT OCCURS VERY FREQUENTLY. POTENTIAL CONSEQUENCE IS SUDDEN ABS FAILURE, HENCE SERIOUS INJURY TO OCCUPANTS. *TR

ONE OF THE BRAKE LINES FAILED WHILE I WAS STOPPED IN TRAFFIC NEARLY CAUSING A COLLISION. I WAS STOPPED WITH MY FOOT ON THE BRAKE WHEN THE PEDAL SUDDENLY WENT TO THE FLOOR AND THE TRUCK MOVED FORWARD SEVERAL FEET. I PUSHED THE PEDAL AGAIN AND THE TRUCK STOPPED BUT THE PEDAL TRAVELED NEARLY ALL THE WAY TO THE FLOOR. I LOOKED AND SAW BRAKE FLUID LEAKING FROM A HOLE IN ONE OF THE BRAKE LINES. THE LINES ARE ALL VERY RUSTY/CORRODED AND THE BLOWN LINE WAS OUTSIDE THE FRAME BELOW THE DRIVERS DOOR. *TR

2001 GMC SIERRA 1500 4X4 MAIN BRAKE LINE RUPTURE FROM CORROSION WHILE DRIVING IN TRAFFIC. *TR

I OWN A 2001 GMC SIERRA 1500. ON SEPTEMBER 7 2010 I LEFT MY HOUSE TO GO TO WORK, I STOPPED AT THE MAIL BOX AT THE END OF DRIVEWAY WITH MY FOOT ON THE BRAKE. AFTER ABOUT 15 SECONDS THE PEDAL WENT TO THE FLOOR AND THE TRUCK STARTED TO ROLL AWAY. I BACKED UP INTO MY DRIVEWAY AND NOTICED BRAKE FLUID POURING OUT FROM UNDER THE TRUCK. WHEN I LOOKED UNDER THE TRUCK I NOTICED THAT ALL THE BRAKE LINES WERE EXTREMELY CORRODED AND ONE WAS LEAKING. I THANK GOD I WAS NOT DRIVING DOWN THE INTERSTATE WHEN IT HAPPENED. SCARY UNSAFE!!! *TR

ON 8/4/10, WHILE MOVING IN REVERSE IN MY DRIVEWAY, MY 2001 GMC SIERRA'S BRAKE LINE RUPTURED CAUSING COMPLETE BRAKE FAILURE DUE TO CORROSION ON THE STEEL BRAKE LINE. THE VEHICLE IS 10 YEARS OLD AND ONLY HAS 29,000 MILES ON IT. IT WAS RARELY DRIVEN IN THE WINTER WHEN THERE WAS SNOW, ICE OR SALT PRESENT. AS OF 9/5/10 THE TRUCK REMAINS PARKED AND THE LINES HAVE NOT BEEN REPLACED. WHEN THE FAILURE HAPPENED, I CONDUCTED RESEARCH TO FIND THIS FAILURE TO BE A PENDING INVESTIGATION FOR A POSSIBLE RECALL. NHTSA ACTION NUMBER : PE10010. I ONLY WANT GMC TO TAKE RESPONSIBILITY FOR THE COST OF THE REPAIR OR REIMBURSEMENT FOR THE COST OF THE REPAIR THAT IS CAUSED BY THIS DEFECT. BUT I'M PRETTY SURE A RECALL ON 6.3 MILLION VEHICLES WILL NOT BE ISSUED WITH GM'S IPO SET TO BE RELEASED. SO, I, THE GM CONSUMER, WILL HAVE TO WAIT. *TR