2022 GMC SIERRA 1500 Complaints

The contact owns a 2022 GMC Sierra 1500. The contact stated while driving at approximately 65 MPH, the vehicle stalled, and there was smoke coming from the engine compartment. Additionally, the contact stated that the vehicle was experiencing excessive oil consumption. The messages "Put Vehicle in Neutral" and "Check Oil" were displayed. The failure occurred on several different occasions. The contact stated that the vehicle was serviced under an unknown NHTSA Campaign Number; however, the failure recurred. The vehicle was towed to a dealer, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was towed back to the dealer, where it was determined that the engine needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 28,000.

I own a 2022 GMC Sierra 1500 AT4. The vehicle developed a clear engine knocking noise. I first brought the vehicle to the dealership while under 150,000 miles for inspection related to a recall. The dealership only performed a computer scan and oil change and stated no issue was found. No mechanical inspection was performed despite the noise. The issue continued and worsened. I returned to the dealership and the vehicle was kept for three days. During that time, the dealership again denied the existence of the noise and stated the vehicle was operating normally. When I picked up the vehicle, I immediately noticed the same noise and requested the technician to inspect it again. At that time, the technician acknowledged the noise and confirmed it was related to the recall. Despite this acknowledgment, General Motors declined to repair the engine and closed the case, offering only partial assistance toward purchasing a new vehicle instead of fixing the defect. The failure to properly diagnose the issue during the initial visit and the subsequent denial during the second inspection allowed a safety-related mechanical defect to worsen. This condition may result in engine failure or sudden loss of power while driving, creating a serious safety risk. The engine noise indicates a potential internal failure which could lead to sudden loss of power while driving, creating a safety risk. The initial failure to properly diagnose the issue may have allowed a safety-related defect to worsen beyond repair. Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

our truck has the GM 6.2L V8 engine in it. We had the “recall” done where they recommended thicker oil. Despite that recall work we still had catastrophic engine failure and GM’s solution is terrible. A new engine that can have the same issue?

My 2022 GMC Sierra 1500 AT4X experienced an engine failure requiring full replacement under warranty. The vehicle was out of service for approximately 46 days. After replacement, the vehicle experienced additional electrical issues and unsafe operating conditions. The replacement engine has now failed again in under 8,000 miles. A dealership performed diagnostic testing (Pico scope) which failed immediately and recommended another full engine replacement. I have been advised not to drive the vehicle due to safety concerns. This appears to be a repeat defect that was not corrected by the initial repair.

Engine seized while driving on my local interstate hwy. No warning lights came up. Towed to the dealer and they confirmed the engine was locked up. Engine needed to be replaced.

I am reporting two separate stall/loss of propulsion events on my 2022 GMC Sierra 1500 Denali Limited (VIN: [XXX] ), which is subject to NHTSA Recall #25V274000 and GM Special Coverage XXX (L87 Engine Loss of Propulsion). INCIDENT 1 — April 16, 2026: While decelerating off a highway exit ramp, the vehicle stalled without warning. The dashboard prompted me to shift to neutral and restart. I performed a rolling restart successfully and continued driving. This stall occurred while decelerating on a highway exit ramp with vehicles traveling at highway speeds behind me. The sudden and unexpected loss of propulsion created a significant rear-end collision risk. INCIDENT 2 — April 17, 2026 (next day): While traveling at approximately 40 MPH and climbing a hill under load, the vehicle stalled a second time. The dashboard again prompted a neutral restart. This time the vehicle would not restart. All I heard was a single click from the starter, followed by a complete dash reboot. The vehicle lost all power repeatedly upon restart attempts. I was stranded on a narrow, high-speed rural road in Standish, Maine during rush hour, with vehicles passing at speed. I was in serious danger. The vehicle was towed to Weirs GMC in Arundel, Maine (the selling dealer), where it currently remains for diagnosis under RO# XXX. Both stall concerns are documented as Warranty Pay. Additional concern: Since the day after purchase (March 28, 2026), I have noticed a pronounced cold-start tick originating from the bottom end of the engine, confirmed by an independent mechanic as coming from inside the engine. This vehicle passed a Recall #25V274000 inspection on December 28, 2025 at 98,233 miles. The tick and stall events began after that inspection. I am requesting this be formally documented as a safety complaint tied to Recall #25V274000 and Special Coverage XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2022 GMC Sierra Denali 6.2 L Engine failure at 32,000 miles/924 Hours on 9/2024. Was driving truck dashboard lit up, popped into neutral entering a main road. Thankfully my son wasn’t hit by oncoming traffic. Vehicle would not start called Police, tow truck and was found to be total catastrophic engine failure. New engine was replaced. New engine has roughly 22,000 trouble free miles.

4/02/26 Truck bug jumped hard and shifted down causing me to fishtail and almost hit a car. Scared the crap out of me and the driver of the other car. Low power mode. 20 mph. No reverse. Towed to dealership. Diagnosis valve body spacer. This is our first GMC. Barely had it over a year. 78k miles. No warning lamps prior to failure.

I was exiting a main highway and when I let off the accelerator the engine died unexpectedly with no prior signs of failure and would not turn over to restart, luckily I was able to coast onto a side street out of the way of moderate traffic. I called GM roadside assistance and had the vehicle towed to my local dealership. The service department confirmed that the engine was seized and needed replaced. My vehicle went through the L87 recall and passed inspection last fall at 29,400 miles, had another oil change at around 33,500 miles. The engine failed at 37,800 miles. I am the original owner and have always maintained the vehicle to GM standards. I feel that the recall is not solving this problem, because the engines are failing anyway. At this time my vehicle has been at the dealership service department for three and a half weeks, and is waiting on the replacement engine. The dealership has provided a loaner vehicle.

Vehicle Fire. Total Loss. While driving, vehicle began to smoke from under the hood. Fire grew rapidly and vehicle is totaled. No warning signs leading up to the incident.