2019 GMC SIERRA 2500 Complaints

On 07/10/2026 at approximately 1:10 a.m., the parked and unoccupied vehicle caught fire while turned off. The vehicle had not been driven for several hours. A neighbor was awakened by the horn/alarm and popping noises, observed fire near the passenger-side cab/engine area, and called 911. The fire rapidly spread throughout the cab, engine compartment, rocker-panel areas, wheel wells, and truck bed, creating an explosion hazard and threatening a nearby occupied residence and garage. The fire department extinguished the blaze, but the vehicle was completely destroyed. Before the fire, the vehicle had experienced recurring coolant warnings, a DEF-system warning, and delayed starting associated with the main battery. No smoke, fuel odor, intentional ignition source, charging device, or known external fire source was present before the incident. Weather was calm. The exact failed component and cause remain UNKNOWN. A firefighter stated that the apparent fire origin was near the passenger side of the vehicle. The remains are available for inspection, subject to coordination with the vehicle owner and insurer. The incident has been reported to the fire department, insurer, manufacturer, and NHTSA.

UI Bulletin #161b is for years 2020 and beyond. But my 2019 is having the same exact issue and the GM dealer will not cover the work as stated in the UI Bulletin #161b

The contact owned a 2019 GMC Sierra 2500. The contact stated that on several occasions while driving at undisclosed speeds, the vehicle lost motive power. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the rear fuel tank had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 65,580.

My center console wires for the charging pad broke and shorted out causing wires to burn and short the whole system out

The contact owns a 2019 GMC Sierra 2500. The contact stated that while her husband was driving 30 MPH and depressing the accelerator pedal, there was an abnormal sound coming from the front of the vehicle, and the vehicle lost power unexpectedly. The contact stated that her husband was able to pull over to the right side of the road while waiting for tow truck assistance. The vehicle was towed to the residence. The vehicle was not towed an independent mechanic or dealer to be diagnosed. The engine was replaced, and the vehicle was repaired. The contact related the failure to NHTSA Campaign Number: 23V047000 (FUEL SYSTEM, DIESEL); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 143,000.

Emissions Code showed up on the dash display. Tried to fix the fuel filter and cleaned a sensor off and it still shows the emissions code.

While merging into highway traffic the truck surged with RPM going to 5,000. Shortly after this event there was a grinding or rattling noise in the transmission bell housing along with unusual shifting behavior and a repeatble vibration + rotational noise between 50 and 60 MPH. The vehicle was brought to the dealer for inspection at least 4 times with claims they could not hear the obvious noise that did not go away. On the last drop off, I picked up the vehicle and the noise was gone but the shifting behavior and the constant vibration from the transmission still persists. The dealer said GMC would replace the transmission for approximately $10,000 but I would need to cover 50% of the cost. Vehicle had 35,700 miles on it and was 4 months beyond the 5yr warranty. Still unrepaired. No warning lamps, messages, or codes. Transmission component failure is imminent based on the vehicle behavior

The manufacturer placed two 12v batteries to start the truck with one being located on the passenger side just in front of the cowl of the cab. The factory OEM batteries are known to overheat when charging which is exactly what mine did and as the battery boils over with sulfuric acid, the acid is vaporized and ingested into the cabin. It’s a diesel so it’s common for me to take my dog in the rear crew cab with me and leave the engine running so the cabin will stay cool in the summer while I work my contractor job. When I let the engine idle with windows up and AC on the overcharged battery introduced the vaporized sulfuric acid into the cabin and rendered the interior deadly toxic. Luckily I was only gone from the truck for about 10 minutes but in this amount of time the acid was very bad and caused burns in my dogs throat and mine while driving home. I can only imagine if this scenario were to take place with kids left in the truck for many reasons to stay cool but could easily turn into a deadly situation. PLEASE look into this before someone or some poor animal is fatally injured or killed.

The antilock braking system is not functioning properly. The sensor for the anti-lock brake control pump module is defective

The contact owns a 2019 GMC Sierra 2500. The contact stated while driving 10 MPH, the vehicle lost motive power and stalled and shut off independently. The vehicle was towed to a dealer and was diagnosed, and it was determined that the fuel pump control module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 33,000.