2020 HONDA CR-V Complaints

SRS AIR BAG PROBLEM IN THE DASHBOARD GO ON AND OFF HONDA TECHNICIAN FOUND THIS CODE AIRBAG INFLATOR

On the evening of [XXX], I started my vehicle while it was parked in my garage. Within approximately five minutes, the vehicle suddenly produced a violent and unusually loud mechanical noise, followed by visible smoke billowing from beneath the hood. Recognizing the immediate potential fire and safety hazard to both myself and my property, I immediately shut the vehicle down. The following morning, I took directly to Honda North, an authorized Honda dealership in Clovis, California, for a professional diagnostic inspection. The dealership's certified inspection determined that the A/C compressor had suffered a catastrophic internal mechanical failure and had completely seized. According to the dealership, the compressor's internal failure while the system was operating resulted in metallic debris being circulated throughout and contaminating the A/C system. This catastrophic seizure heavily strained the engine's drive belt system. The failure was a direct result of the factory compressor shaft seal leaking out all system refrigerant and lubricating oil, causing the unit to run dry and seize. As a result, the dealership determined that replacing only the failed compressor would not be sufficient to properly restore the system. The recommended repair requires a complete A/C system overhaul, including replacement of the compressor, condenser, expansion valve, and associated refrigerant lines/components. Honda has openly acknowledged this exact factory defect in Service Bulletin 23-040, extending the shaft seal warranty to 10 years. However, Honda Corporate Customer Service is refusing responsibility for the downstream consequential destruction caused by their own defective component, citing only general vehicle age and mileage, despite the vehicle having 55,782 miles and sitting well within the 10-year extended warranty window. They have refused to provide an engineering justification or written analysis for this safety-related coverage denial. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

National Highway and Traffic Safety Administration August 11, 2026. Dear Sir, Madame, I am writing regarding a safety issue with my 2020 Honda CR-V, purchased about one year ago. There is a serious issue with the steering column, and American Honda has declined assistance with repairs. I am seeking expedited assistance from NHTSA. This issue was first noted on the day I drove the vehicle to the Honda Dealership for maintenance (XXX). My daughter has been driving this vehicle, and did not report anything abnormal. I routinely schedule maintenance for her car when I have a day off. So I noticed this "sticking" of the steering wheel during my drive, especially at higher speeds and on the highway. However, I also notice a lunge during turns at lower speed. I asked the service advisor to test drive the car to assess this (and road noise - later deemed normal). The steering wheel actually gets stuck when making even minor (fine motor) adjustments during routine (straightway) driving conditions. It is a continuous problem, not intermittent, and it is easily noticeable to me and my wife. The service advisor who test-drove the CR-V with me and later provided the repair estimate is Eric Laurendeau (832). He suggested I reach out to American Honda for assistance. I reached out to Honda, who promptly declined any assistance. This CR-V has only 54,000 miles on it and is otherwise near-new. This car has been in one minor incident; the repair shop and insurance adjuster found no structural problems. This accident was the other driver's fault (not my daughter's). The estimated repair costs total $6657.41. I have a copy of the estimate. In my view this should be a safety recall, as it involves the steering column, and I do not feel comfortable allowing my [XXX] daughter to drive the car- and I cannot afford the repairs! Is there anything the NHTSA can do to help me with this??? Sincerely, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving at highway speeds, my steering wheel physically binds, catches and then suddenly jerks when trying to make normal adjustments. This creates an unpredictable control hazard. This is similar to NHTSA Recall 24V-744 and Honda TSB 24-011. The internal steering gearbox is binding due to the same design & manufacturing tolerances.

While driving at higher speeds and I turn to the left the steering wheel would stick. It would take a second to unstick to be able to move the wheel back to the right. I took it into my local Honda dealership and they said my power steering has an issue and needs to be replaced. I researched and found multiple 2020 Honda CR-V have had this issue and Honda has issued a recall from 2022 and newer CR-V and not for the 2020's. I have logged a complaint with Honda of America. My Honda is only 6 years old with 65,670 miles on it.

My vehicle exhibits a "sticky" steering column and has done so for a few years now. Honda issues a recall notice for 2022 CRV models, but mine is a 2020. The recall number is 24V-744. In June of 2023 with 25260 miles on the vehicle and while still under warranty, I took the car to my local dealer and was told they could not reproduce the issue and the steering was functioning as designed. It has done it ever since! This recall needs to be expanded to incorporate 2020 models as well.

All the safety lights came on on the dashboard suddenly the brake assist did not work. Honda tells me the brake servo is bad. This is a known defect as other 2020 crv hybrids were recalled for the same reason. It is a dangerous safety hazard.

While out of state for thanksgiving in 2025. after stopped for break, car started up with all of the warning lights and check engine lights on. Like front radar out, hybrid system fault and etc. took to Honda dealership near by immediate. Diagnosed (their words) customer states check engine light is on and flashing pulled codes had code p0562 and pOED. traction motor control module system voltage low and HV battery cell voltage sense circuit. went through honda trouble shooting and honda states to replace power control unit (PCU) and battery condition monitor module. test drove vehicle codes came back recommend replacing modules. includes reprogramming. They indicated it is not safe to drive as you may not able to start the car or it can die while running. This was at out of state and have to repair without options and get a rental car for a week. Tech said they never seen that before in hybrid. Local dealer back home said they can’t say they had issue before. Reached out to Honda Corporate before Christmas and they declined good will reimbursement request.

When driving on highway, the engine light came on and the car suddenly slowed down causing me concern about traffic around me still going at highway speed. Not understanding what the issue was and afraid the car would lose all power, I was able to shift lanes quickly to get to the breakdown lane. I was able to get the car to Honda Dealer driving at slow speed using back roads. The Honda Dealer confirmed an engine misfire caused the engine light and slowdown. The cause of the misfire was coolant leaking into engine cylinder and would require replacing the head gasket to fix the problem. The car had 75,000 miles and had been running fine until that point.

I have experienced four instances of my vehicle braking (two very extreme) when nothing was nearby or in front of my vehicle. Two of these happened when passing through an intersection, but no other vehicles were nearby. Fortunately, no one was following close behind during two occasions, or I would have been rear ended. I mentioned this today while having my car serviced at the dealership(White’s Auto Mall in Hopkinsville, KY) but they wanted to charge me 207.00 for an inspection, which I didn’t think I should be responsible for paying. I have researched and found “phantom braking” to be a problem in my vehicle make and model.