1999 HONDA PASSPORT Complaints

LAST YEAR I NOTICED RUST THAT HAD BECOME A GAPING HOLE IN THE UPPER PART OF MY HONDA PASSPORT'S UPPER FRAME. THEN I NOTICED THERE WERE RUST LOCATIONS AT VARIOUS PARTS OF THE ROOF AND REAR. THIS CAR HAS BEEN DRIVEN SOLELY ON OAHU, SO THERE IS NO ISSUE OF DEICER OR ROAD SALT HAVING CAUSED THIS, AND I LIVE MILES FROM THE OCEAN. THE GAPING HOLE IS GROWING AND THIS PROBLEM MAY BE A SAFETY HAZARD AND IT MAKES THE CAR IMPOSSIBLE TO SELL, WHICH IS SOMETHING I'D INTENDED TO DO SOON, AS MY GIRLFRIEND WILL ALSO START DRIVING "OUR" VEHICLE AND SHE'S UNCOMFORTABLE WITH A LARGER CAR. I LOOKED ONLINE AND FOUND THAT A NUMBER OF SITES HAVE NOTED THAT THE HONDA PASSPORT AND THE ISUZU RODEO (BOTH THE SAME CAR FROM THE SAME PLANT IN INDIANA) HAVE SPECIAL PROBLEMS WITH RUSTY FRAMES, BUT I THOUGHT I SHOULD REPORT MINE, TOO. *TR

TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION OIL GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 148,000. ..UPDATED 07-17-13 *BF THE BALL JOINTS, EXHAUST, TIE ROD END, ENGINE GASKETS, SWAY BAR LINKS AND TIMING BELT ALL NEEDED TO BE REPLACED.

TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE FRAME WAS SEVERELY CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN ADVISED THAT THE VEHICLE WAS NOT REPAIRABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,000. *TR

TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE REAR SUSPENSION LOWER LINK BRACKET WAS FRACTURED DUE TO EXCESSIVE CORROSION. IN ADDITION, THE MECHANIC STATED THAT THE VEHICLE WAS NOT REPAIRABLE BECAUSE THE FRAME WAS ALSO CORRODED AND THE BRACKET COULD NOT BE WELDED BACK ONTO THE FRAME. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 154,000. ..UPDATED 04/18/13 *BF THE CONSUMER STATED HE FINALLY FOUND A FRAME RESTORATION SHOP. THEY CUT OUT ALL OF THE RUSTED FRAME AREAS ON THE REAR DRIVER SIDE AND MADE A NEW END FOR THE LOWER LINK BRACKET. THE CONSUMER ALSO STATED THE CATALYTIC CONVERTER BECAME CLOGGED AND RUINED THE ENGINE. THE FRONT AXLES WERE REPLACED TWICE. THE VEHICLE HAD AN OIL LEAK AND TRANSMISSION LEAK. UPDATED 04/23/13

WELL IN JULY 2012 I WAS DRIVING MY HONDA WHEN I HEARD NOISE (SOUNDED LIKE A MUFFLER LEAK) HIT A SMALL DIP IN THE ROAD THEN A POP AND THEN LOUD NOISE COMING FROM ENGINE. I TOOK IT IMMEDIATELY TO THE REPAIR SHOP AND THEY SAID THE CATALYTIC CONVERTER HAD BLOWN A HOLE IN IT SELF. THEY SAID THEY HAD NEVER SEEN ANYTHING LIKE IT. WELL HERE IT IS JANUARY 2013 AND JUST LAST WEEK THE OTHER SIDE (MY CAR HAS TWO CONVERTERS, LUCKY ME) DID THE EXACT SAME THING. THIS IS JUST THE WEIRDEST THING EVER AND SO VERY EXPENSIVE TO FIX. IS THIS NORMAL? I DON'T THINK SO AND NO ONE CAN GIVE ME AN EXPLANATION ON WHY THIS IS HAPPENING. I NEED SOME HELP PLEASE. *TR

TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, SHE NOTICED THAT THERE WERE HOLES AND RUST ON THE REAR SUSPENSION. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION:REAR) WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 137,000 AND THE CURRENT MILEAGE WAS 138,000.

TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED HIS WIFE HIT A POT HOLE, AND THEN THERE WAS A NOISE COMING FROM THE REAR END OF THE VEHICLE. THE NEXT THE DAY, AS THE CONTACT DROVE THE VEHICLE TO HIS MECHANIC, THE REAR STRUT CAME OFF AND IT WAS HANGING DOWN. THE VEHICLE WAS THEN TOWED TO THE DEALER WHERE HE WAS INFORMED. THE REAR PASSENGER SIDE STRUT WAS SEVERELY RUSTED, WHICH CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 10V436000 (SUSPENSION:REAR). THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE. UPDATED 11/14/12*LJ UPDATED 11/15/15

TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN OIL CHANGE WHO NOTIFIED HIM THAT THE REAR COIL SPRINGS WERE FAULTY. THE COIL SPRING ON THE REAR PASSENGER SIDE BROKE OFF THE FRAME AND WAS VISIBLE FROM THE INSIDE OF THE VEHICLE. ALSO, THE ENTIRE FRAME WAS RUSTED OUT AND WAS DEEMED UNSAFE TO DRIVE. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT AND OFFERED NO OTHER ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 127,000. UPDATED 10/15/12 *CN UPDATED 10/24/2012 *JS

I HAD MY VEHICLE INSPECTED DURING A ROUTINE OIL CHANGE. THE MECHANICS SHOWED ME EXTENSIVE CORROSION ON THE FRAME OF MY VEHICLE. THEY SAID IT WAS UNSAFE TO DRIVE. AFTER DOING RESEARCH ONLINE I FOUND OUT A RECALL FOR A SUSPENSION BRACKET EXPIRED. BUT I ALSO FOUND OUT SEVERAL OTHER OWNERS HAD EXTENSIVE CORROSION AND HONDA WAS WORKING WITH THEM ON THE FRAME CORROSION WHICH WAS IDENTIFIED DURING THE RECALL BUT WAS NOT PART OF THE RECALL. I CALLED HONDA AND THE DEALERSHIP AND THEY SAID SINCE THE RECALL EXPIRED THEY WOULD NOT DO ANYTHING. AGAIN, IT APPEARS HONDA KNOWS OF MORE THAN USUAL/SEVERE CORROSION OF THE FRAME ON THIS VEHICLE AND HAS DEALT WITH A FEW CONSUMERS ON IT. BUT WHEN I ASK THEY SAY THERE IS NOTHING THEY CAN DO. I NEED HELP. IT APPEARS THERE IS A BIGGER PROBLEM THAN WHAT THEY INITIALLY STARTED THE RECALL FOR. *TR

TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE WHEN THE MECHANIC ADVISED THAT THE REAR SUSPENSION LOWER LINK BRACKET NEEDED REPLACING. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS INCLUDED IN A RECALL (NHTSA CAMPAIGN ID NUMBER: 10V436000- SUSPENSION) HOWEVER, THE RECALL CAMPAIGN WAS EXPIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 141,000. ....UPDATED 10/11/12 *BF UPDATED 10/16/12