2004 HONDA ST1300 Complaints

TL* THE CONTACT OWNS A 2004 HONDA ST1300 MOTORCYCLE. WHILE INSPECTING THE VEHICLE, THE FLUID LEVELS IN THE BRAKE FLUID RESERVOIR WERE LOW. THERE WAS NO EVIDENCE OF A FLUID LEAK. WHILE RIDING APPROXIMATELY 45 MPH, THE CONTACT HEARD A LOUD POPPING NOISE FROM THE REAR OF THE BIKE AND THE REAR BRAKES SUDDENLY BECAME INOPERABLE. UPON INSPECTION, THE CONTACT DISCOVERED THAT THERE WAS NO BRAKE FLUID PRESENT IN THE BRAKE RESERVOIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 18,000.

MOTORCYCLE DEMONSTRATED ONCE BEFORE THE BOILING OF FUEL IN FULL FUEL TANK AFTER DRIVING. A COUPLE OF WEEKENDS LATER I DECIDED THAT I WOULD REMOVE THE FUEL FROM THE TANK BECAUSE I BELIEVED THAT THE GAS MAY HAVE CONTAINED TOO MUCH ALCOHOL WHICH MAY BOIL AT A LOWER TEMPERATURE. I REMOVED ALL BUT ABOUT 2 GALLONS OUT OF THE 7.7 GALLON TANK. I RODE TO A FUEL STATION AND REFILLED TO ABOUT 3/4 OF AN INCH BELOW THE FULL MARK. I LEFT SOME EXPANSION SPACE DUE TO THE HOT WEATHER. THE OPERATING TEMPERATURE OF THE BIKE WAS NORMAL AS ALWAYS. UPON RETURNING HOME I STOPPED THE BIKE OUTSIDE OF THE ENCLOSED GARAGE JUST TO CHECK THE TANK BEFORE I BROUGHT IT IN SHOULD THERE BE ANY PROBLEMS. I WAS CONFIDENT ENOUGH TO REMAIN ON THE BIKE AND REMOVED THE KEY FROM THE IGNITION TO UNLOCK THE FUEL TANK. WHILE SITTING ON THE BIKE WITH MY HELMET, JACKET, AND SUNGLASSES STILL ON I INSERTED THE KEY INTO THE CAP AND OPENED IT. UPON UNLOCKING, THE CAP BURST FULL OPEN AND INSTANTLY FUEL SHOWERED ME AND THE INSTRUMENT PANEL OF THE BIKE AS IF A HOT RADIATOR CAP WAS OPENED. RELIEVING THE PRESSURE IN THE TANK ALLOW THE FUEL TO SPONTANEOUSLY BOIL . AFTERWARDS I WOULD ESTIMATE THAT 1.5 TO 2 GALLONS CAME OUT OF THE TANK IN A MATTER OF 1 SECOND. COVERED IN FUEL I QUICKLY JUMPED OFF THE BIKE STILL HOLDING THE KEY WHICH BROKE OFF IN MY HAND. MY CONCERN IS FOR OTHER RIDERS THAT MAY ENCOUNTER THIS PROBLEM. I TAKING THE BIKE TO GET THE TANK VENT SYSTEM REPAIRED BY A HONDA DEALER. THIS IS EXTREMELY DANGEROUS AS THE VENT SYSTEM HAS FAILED TO AN UNSAFE CONDITION. *TR

TL* THE CONTACT OWNS A 2004 HONDA ST1300 MOTOTRCYCLE. THE CONTACT STATED THAT WHILE REPLACING THE TIRES, HE NOTICED THAT THE REAR WHEEL BEARING WAS VERY ROUGH. THE CONTACT EXPRESSED CONCERN OVER THE POSSIBLE SEIZING OF THE REAR WHEEL. THE BIKE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THE CONTACT WAS INFORMED THAT THE REAR WHEEL BEARING WAS FRACTURED AND NEEDED TO BE REPLACED. THE BEARING WAS REPLACED. THE FAILURE HAD SINCE RECURRED. THE BIKE WAS TAKEN BACK TO THE DEALER AFTER EACH FAILURE, WHERE IT WAS REPAIRED. THE FAILURE MILEAGE WAS 76,895 AND THE CURRENT MILEAGE WAS 143,500. THE DRIVE HUB BEARINGS HAVE BEEN REPLACED SIX TIMES. UPDATED 11/02/11

DUNLOP ROADSMART SPORTMAX 120/70/ZR18 FRONT TIRE ON MY MOTORCYCLE. DEVELOPED A 1" X 2" X 12" BLISTER ALONG THE CENTER LINE OF THE TIRE. ONLY 7,000 MILES ON THE TIRE, STILL PLENTY OF TREAD LIFE LEFT. LUCKILY FOUND IT WHEN GOING SLOWLY ON THE COAST. *TR

THE HEAT FROM THE ENGINE COMPARTMENT IS NOT VENTED OR ROUTED PROPERLY, CAUSING 450 DEGREE FAHRENHEIT TEMPERATURES TO VENT ACROSS THE MOTORCYCLE OPERATORS LEGS, CAUSING PAIN AND DISCOMFORT. THE TEMPERATURE IS HOT ENOUGH TO CAUSE PHYSICAL PAIN WHEN THE PLASTIC SURROUND THE LEG AREA IS TOUCHED. THIS PROBLEM IS PANDEMIC TO MOST OF THE ST1300'S ON THE ROAD. I CAN PROVIDE THE NAMES OF HUNDREDS PERHAPS THOUSANDS OF OWNERS WHO HAVE THE EXACT SAME PROBLEM I AM DESCRIBING. THE DEALERS TO INCLUDE HONDA NORTH AMERICA HAVE NO RESOLUTION FOR THIS, EXCEPT TO RECOMMEND COOLANT FLUSH, OIL CHANGE. NONE OF THESE FIXES THIS PROBLEM. *JB

TL* THE CONTACT OWNS A 2004 HONDA ST 1300 MOTORCYCLE. WHILE DRIVING 60 MPH AND ATTEMPTING TO BRAKE THE BRAKE SYSTEM LOCKED WITHOUT WARNING. THE MOTORCYCLE WENT INTO A TAIL SPIN. HOWEVER, THE DRIVER WAS ABLE TO MAINTAIN CONTROL AND STOP THE MOTORCYCLE. THE FAILURE AND CURRENT MILEAGE WERE 11500. THERE WERE NO INJURIES. *AK THE CONSUMER STATED THAT THE DEALER INFORMED HIM A REAR CALIPER BOLT HAD BECOME LODGE INTO THE BRAKE SYSTEM CAUSING THE BRAKES TO LOCK UP. THE CONSUMER STATED THE PROBLEM DID NOT REOCCUR AND THE TIRES WERE CHANGED ON THE MOTORCYCLE PRIOR TO INCIDENT. UPDATED 07/17/07 *TR

DT: 2004 HONDA ST1300. THE CONSUMER STATED THAT REAR BRAKES LOCKED. THIS PROBLEM HAS HAPPENED SEVERAL TIMES. THE CONSUMER CONTACTED THE DEALER. THE CONSUMER TOOK HONDA TO COLUMBIA SOUTH CAROLINA DEALER. VEHICLE HAS BEEN AT DEALERSHIP FOR 1 WEEK. HONDA DEALER IN COLUMBIA SOUTH CAROLINA SAID THEY FIXED BRAKES, BUT THE BRAKES FAILED AGAIN. *AK

DT: CONTACT STATES WHILE DRIVING THE MOTORCYCLE IT DOES NOT SHIFT PROPERLY. CONTACT FEELS THIS POSES A SAFETY HAZARD WHILE IN TRAFFIC. VEHICLE HAS NOT BEEN TO A SERVICE DEALER BUT THERE IS AN APPOINTMENT SCHEDULED. *AK

FACTORY RECALLS - HONDA MOTORCYCLE 2004 ST1300 I RECEIVED A RECALL FOR AN ELECTRICAL PROBLEM IN DECEMBER. I HAVE CONTACTED 3 DEALERSHIPS IN MY COUNTY & 2 ADJACENT COUNTIES. NONE OF THE DEALERSHIPS HAVE THE PARTS TO REPAIR THE PROBLEM TO DATE. ALL 3 DEALERSHIPS TELL ME THE SAME THING, THAT THEY WILL ONLY RECEIVE THE REPAIR KIT FOR THE NUMBER OF ST1300 MODELS SOLD FROM THEIR DEALERSHIP. IN ADDITION, NONE OF THE DEALERS HAVE RECEIVED THE PARTS. I HAVE RECEIVED A SECOND RECALL FOR ANOTHER BRAKE PROBLEM. I AM CONCERNED THAT I WILL HAVE A SIMILAR WAIT FOR THE SECOND RECALL. IN ADDITION, IF EITHER RECALL IS CAUSING AN UNSAFE CONDITION I HAVE BEEN UNABLE TO CORRECT THE SITUATION DUE TO LACK OF REPAIR PARTS. IT HAS BEEN 3 MONTHS NOW FOR THE 1ST RECALL.*JB

RECALL CAMPAIGN 05V010000 CONCERNING COMBINED BRAKE SYSTEM LEAK, AND RECALL 04V568000 CONCERNING POOR WIRING INSIDE BLOCK. CONSUMER WAS UNABLE TO GET BOTH RECALLS HONORED BY THE DEALER BECAUSE NO PARTS WERE AVAILABLE.*AK