2002 HONDA VTX1800 Complaints

TL* THE CONTACT OWNS A 2002 HONDA VTX1800. WHILE DRIVING BETWEEN 30-40 MPH, THE MOTORCYCLE BEGAN TO WOBBLE WHEN ONE OF THE HANDLES WAS RELEASED. THE VEHICLE HAD NEW TIRES AND BRAKES DUE TO OTHER NECESSARY REPAIRS; HOWEVER, THE WOBBLING CONTINUED. THE CONTACT TOOK THE VEHICLE TO INTERSTATE CYCLES (580 SW FLORIDA GATEWAY DR, LAKE CITY, FL 32024; 386-758-2423) WHO STATED THAT THE WOBBLING ONLY OCCURRED WHILE DRIVING BETWEEN 35-40 MPH. THE FAILURE DID NOT OCCUR AT HIGHER SPEEDS. THE DEALER STATED THEY DID NOT BELIEVE THERE WAS A SAFETY ISSUE AND THE CONTACT COULD CONTINUE OPERATING THE MOTORCYCLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 27,000.

TL* THE CONTACT OWNED A 2002 HONDA VTX1800. WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKES SEIZED WITHOUT WARNING. AS A RESULT, THE CONTACT CRASHED INTO A WALL AND WAS THROWN OFF THE VEHICLE. THE PASSENGER SUSTAINED A FRACTURED ARM, A HEAD INJURY, AND A KNEE INJURY. THE DRIVER SUSTAINED A ROAD RASH OVER THE LEFT SIDE OF THE BODY. BOTH THE DRIVER AND PASSENGER REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 39,000. THE VIN WAS NOT AVAILABLE.

I HAVE REPLACED THE FINAL DRIVE FLANGE BEARINGS 3 TIMES NOW. I HEARD THAT THERE WERE SOME ISSUES WITH THIS FLANGE. FIRST TIME I REPLACED IT, I REPLACED THE WHOLE FLANGE. THE SECOND AND THIRD TIME I REPLACED THE BEARINGS ONLY. ON THE THIRD TIME I REPLACED THE WHEEL DAMPENER INSIDE THE REAR WHEEL. I NOW HAVE 96,000 MILES ON MY BIKE AND CHECK THESE BEARINGS EVERY TIME I CHANGE THE REAR TIRE. ALL THREE TIMES THE PLASTIC SEAL WAS GONE AND A FEW BALLS OUT OF THE BEARING. THE CAGE THAT HOLDS THE BALLS IN THE BEARING WAS DESTROYED ALL THREE TIMES. *TR

TL* THE CONTACT OWNS A 2002 HONDA VTX 1800. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE CRANK SHAFT HAD FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE CRANK SHAFT WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 9,000. *TR

REAR WHEEL FINAL DRIVE BEARING FAILURE. WAS FOUND WHEN REPLACING THE REAR TIRE. LOOKING AT OPTIONS FOR THE REPAIR NOW.

REMOVED REAR WHEEL TO PERFORM MAINTENANCE AND CHECK REAR WHEEL FLANGE BEARINGS AS ADVISED BY MANY OTHER OWNERS DISCUSSIONS ON VTXOA.COM, WHO'VE EXPERIENCED THIS IDENTICAL PROBLEM. THE BEARINGS WERE IN VERY ROUGH SHAPE AND NEEDED TO BE REPLACED. THIS APPEARS TO BE ATTRIBUTED TO INCORRECTLY DIMENSIONED HONDA PARTS, FOR WHICH THEY'VE NEVER PROVIDED AN ACCEPTABLE, ENGINEERED SOLUTION, OR ACKNOWLEDGED IT FOR THAT MATTER. FAILED COMPONENT: QTY OF 2 BEARINGS IN ITEM DESCRIBED AS FLANGE SET, PN 42630-MCH-000.

TWO FAULTY FLANGE BEARINGS IN LESS THAN 18,000 MILES. FAILURE NOTED DURING TIRE CHANGES IN BOTH INSTANCES. BOTH REPLACED AT OWNER'S COST @ OVER 190 DOLLARS EACH INSTANCE. *TR

HONDA 2002 VTX 1800RS DURING REAR TIRE REPLACEMENT AT 36K MILES DISCOVERED WHEEL BEARING ON THE RIGHT SIDE (BRAKE SIDE) WAS VERY BAD...HAD NO WARNING, NO WHEEL WOBBLE, WHEEL TURNED FREE, BUT WOULDN'T HAVE BEEN VERY LONG. AXLE SHAFT DISCOLORED, NO REASON FOR THIS FAILURE! ALL REAR BEARINGS REPLACED! FRONT BEARINGS REPLACED FOR SAFETY! *TR

2002 HONDA VTX 1800S REAR WHEEL FLANGE BEARING. WORN OUT AGAIN FOR THE SECOND TIME APPROX 8 TO 10,000 MILES. *TR

TL*THE CONTACT OWNS A 2002 HONDA VTX1800C. WHILE THE CONTACT WAS DRIVING 50 MPH, HE NOTICED THAT THE REAR TIRE FELT DIFFERENT AS IF IT WERE NOT PROPERLY ALIGNED. THE VEHICLE ALSO PULLED TO THE LEFT. HE HEARD CLUNKING NOISES AND THE WELD ON THE SWING ARM DRIVESHAFT HOUSING FAILED. THE CONTACT TOOK PICTURES AND NOTIFIED THE DEALER. THE DEALER THEN ADVISED HIM TO CALL NHTSA AND THE MANUFACTURER. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 17,000.