2009 HYUNDAI ELANTRA Complaints

I am reporting Hyundai’s failure to complete open Campaign 127/NHTSA Recall 15V-100 on my 2009 Hyundai Elantra. I acquired the vehicle from a family member in late July 2026 after the previous owner died and the vehicle was delayed in probate. I sought recall service immediately after legal transfer. Component/system: The Electronic Power Steering (EPS) failed. Power steering assist is completely unavailable. The EPS warning lamp is illuminated and the EPS module reports DTC C1604. The vehicle and EPS system remain at [XXX] Hyundai in [XXX] and are available for inspection upon request. Safety risk: The vehicle was driven from [XXX] to [XXX] during transportation during its transfer to me, and the power steering failed en route. Loss of steering assist substantially increased steering effort suddenly& created a safety risk to the driver, passengers and other motorists. Dealer confirmation: Yes. The condition is recognized by [XXX] Hyundai. I presented the vehicle on XXX specifically for the open EPS recall, and it has remained there since. This is the second area Hyundai dealer that attempted to decline recall service. [XXX] states it cannot perform the prescribed software update because the required Hyundai tablet/programming equipment is no longer available. The dealer has also pressured me to retrieve the unrepaired vehicle and attempted to charge for diagnostics. Other inspections: Hyundai Consumer Affairs is involved under case #XXX. No police or insurance representative has inspected the vehicle. Hyundai’s latest update is that it is attempting to source either the required computer or part, but no remedy or completion date has been provided. Warnings/symptoms: When the EPS failed, the EPS warning lamp illuminated and steering assist was lost. OBD-II/EPS diagnostics subsequently identified C1604. The vehicle has been continuously available for recall repair since XXX. Thank you for your review & assistance with this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Power steering assist motor stopped working, leaving the car with hard manual steering. Dealer inspection confirms the issue across several year models, inclding my 2009. There were 2 other year models with the same issue in their shop with mine that day. One was 2018. One was a 2023. Car is very difficult to steer around curves at any speed. Warning lamp on dash says "EPS".

My ABS system started smoking while the vehicle was in the off position. Police and fire department showed up. Police report number is 2026151090. I was called outside from the establishment and the emergency services were waiting on me. Corporate is now trying to get me to pay the tow out of pocket. I called the NTSHA holiness but was unable to mention this issue about the towing. Also corporate has stated they will likely not service the vehicle.

The contact owns a 2009 Hyundai Elantra. The contact received notification of NHTSA Campaign Number: 20V061000 (Service Brakes, Hydraulic). The contact stated that while driving approximately 35 MPH, the TPMS and powertrain warning lights illuminated, but the vehicle drove normally. The contact stated that a month later, while the vehicle was parked and turned off, a pedestrian saw smoke coming from the engine compartment. The contact arrived at the scene, and the Police and Fire Department were already on scene. The contact stated that a fireman entered the vehicle and opened the hood, and disconnected the battery. A Police report was filed. The contact inspected the vehicle, reconnected the battery, and there was smoke coming from the ABS module inside the engine compartment. The contact then disconnected the battery. The battery was later reconnected, and the vehicle was driven to the residence. The contact arrived at the residence and removed the ABS fuse, and the smoke ceased. The vehicle was taken to an auto shop where a handheld diagnostic machine retrieved DTC: P0441 (EVAP system incorrect purge flow). The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 168,000.

The contact owns a 2009 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The EPS warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. In addition, the contact stated that an unknown recall with a similar description of the failure was completed in 2023. The contact stated that the failure reoccurred. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 118,000.

Vehicle has a major problem steering down the road as I am traveling, its also makes loud clicks while turning left or right, also if freezing up and getting stiff along the way, The item that's causing this problem is call EPS , my light will not go out on its own, My local dealership will not honor the warranty or the recall stated it was repair ed I am the 2 or 3 owner of said vehicle, I can see where it show data update March 30 2026 , , It was never fix and Bentley Hyundai in Huntsville Alabama, will not honor this recall for my vehicle,

NHTSA 20V-061 (Hyundai 188): ABS/HECU Module NHTSA 15V-100 (Hyundai 127): Electric Power Steering (EPS) NHTSA 13V-113 (Hyundai 110): Brake Light Switch

Got in the car to come home put the key in ignition turned it and battery was dead went to turn off and something popped and cloud of smoke started rolling out from underneath the hood once hood was up the smoke got stronger from behind the motor the battery we had to get the battery unplugged and pulled out to get the electricity out the vehicle because of the battery being dead but sill plugged up at the time it would continue smoking more and more and thicker thicker so My husband pulled the battery out immediately as doing so we both inhaled some smoke but we was more concerned about it catching on fire so we pulled through it . We are confused on how or why this happened nothing has broke or went wrong with my vehicle but serpentine belt brake and tire ware my mother had car inspected and service back in May nothing was said that there is or will be wrong with my car. We had no idea that there was anything wrong no warning lights no signs of any problems up to this incident.

During a car accident yesterday. Upon impact at about 30 mph the seatbelt ripped and provided no deceleration during a head on collision. If it wasn’t for the airbag I would have been very seriously injured. It has not yet been inspected by insurance but I have a few videos of the failure for the seatbelt to work.

About 3 years ago the EPS light came on. Brought it to the dealer who said it needed 3500.00 dollars worth of work to replace the steering column. Refused the work and they reset the light. Now after checking i see this was part of a recall 127 . My car was checked and stamped fine so out of luck. Car works good for 3 years now it is doing it again. Just driving straight down the road and power steering stops working, then starts working. Right now steering is fine and the PS light is on all the time. Any help would be appreciated. Car only has 120,000 miles and is in great shape except forthe steering.