2022 HYUNDAI SANTA CRUZ Complaints

Took 2022 Santa Cruz Limited in for an oil change and tire rotation at Grayson Hyundai in West Knoxville, TN, 11-2-22, on the way home smelled burning oil. Found that the dip stick was out of the engine block and oil sprayed all over the interior of the engine compartment, underside components, underside shield, wheel wells, brake caliper, etc when I got home (85 miles away from dealership). I took pics off the engine compartment and dip stick that was left out before they towed it to the dealership. Contacted service adviser, they towed it back and provided loaner. They said, "it lost no oil" and was still full. They said they would remove all the oil from the engine compartment and figure out what the issue was. They had the vehicle for two weeks and said that the dipstick "failed" and showed me the original dipstick with now a very visible cut in the o-ring that was not there before when I took pics of the dipstick before they towed it from my home. I use my vehicle for emergency response and did not feel safe driving the vehicle with oil still all over the engine compartment and underside of all the vehicle. Hyundai customer service did NOTHING, they told me to drive it as it is despite being covered in oil. I went back and forth with Hyundai Customer Service and they would not give me higher position names, numbers or contact information for me to escalate my grievance and safety concern, then HUNG UP ON ME. I had to immediately trade the vehicle and lost my 2.74 interest rate and much of my equity as it only had 26000 miles on it with only 25,000 owed.

Vehicle is equipped with automatic headlights. They constantly turn on and off during the day as soon as you enter any type of shadow. This causes the headlights to “flash” the driver in front of you. While traveling on the interstate at 75 mph if you go under an overpass they turn on, less than 1 second but take 30-60 seconds to turn off! During that time the dash darkens and you cannot see the speedometer,HVAC controls, etc. Even with the headlight switch turned to OFF the dash continues to dim as if the headlights were on! I have had the dealer (San Tan Hyundai in Gilbert AZ) check them twice. Each time I am told operating as designed. This needs a software update to make the automatic headlight system less sensitive. There is no reason why my dash is dimming while the system is off or why the headlights are coming on during a bright sunny day because I drove through a shadow.

When driving home from work, the vehicle shuttered and almost lost power to the vehicle. Received error code DTC P1C2D03 Powertrain TCU through the MyHyundai application and is available for inspection. My safety is put at risk due to loosing power to the vehicle while driving which almost caused an accident on the highway. There is a similar recall in place for the 2022 Hyundai Santa Cruz for the same issue. However, the recall only applied to the Santa Cruz with a certain vin prefix. I haven't had the vehicle inspected by the manufacturer (Earliest appointment is 17 November 2023). I only received the check engine light once the shuttering started to happen.

1.Spring 2023 Received a Recall on tow hitch wiring package (may catch on fire)... No solution yet! I was experiencing transmission problems around same time. 2. My Hyundai App warns of transmission problem on 07/22/2023. Took my (19 month old) 2022 Santa Cruz to Preston Hyundai 07/24/2023. Earliest appointment available was scheduled for 08/09/2023 (16 days waiting period). 3. 08/09/2023, at Preston Hyundai, says they must order a new transmission and refuses to give me my truck back claiming it is UNSAFE to Drive (even though I drove it 16 days (over 400 miles) waiting for my service appointment!). Truck has remained at Preston Hyundai since 08/09/2023 and replacement transmission ETA is 10/24/2023, making total time in dealership 76 days to date (or 92 days since being notified on my Hyundai appof transmission problem! Truck has not moved or been started since 08/24/2023. 4. Back on 07/22/2023, I attempted to program Navigation system with "vacation address" but Nav System displayed prompt that Nav it needed a map update. I cleared the "OK" prompt off the display but I started getting "Check Engine" dummy light appearing and other dummy lights appearing! Also my tachometer gauge (also is the right turn signal mirror camera), quit working and started beeping every 10 seconds or so. 5. On 07/24/2023, at Preston Service Dept., I ask them to update Nav System. I was told that it takes too long and they won't do it! (lacking personnel and time and I should do it myself. I researched "How To" and discovered many warnings from owners that their vehicles computer system got messed up attempting the map update. I've been communicating with Hyundai headquarters who suggested I inquire about the "BuyBack" Program at my Dealership! I did inquire on 10/10/2023 and they've never heard of it, but evaluated my truck and offered me $27,000 for my 20 month old truck, leaving me a $15,000 expense for a new 2024 Santa Cruze. 6. I've now contacted a "Lemon Law" Law Firm!

2022 Santa Cruz issues periodically with RPM will reach 4,000-5,000 (Engine sounds to be reving..sp), mph is near zero, on acceleration from a stopped position. To me, sounds to be torque converter, transmission or electrical system. Have had to dealer on 2 occasions, of which, they cannot reproduce issue.(May 25, August29). This issue is rare but when it occurs (last happening this week Oct 4)concerns of vehicle stopping completely and resulting in accident. Contacted Hyundai customer complaint location, to no avail. It may not be of concern to others but it is to me. When occurs removing foot from accelerator, start process of pulling forward again, all is good. This happened in July, when necessary to have someone else drive vehicle. They were ready to park and call tow truck. Advised what to do to rectify issue, towing was not necessary. Case numbers [XXXXXXX], NHTSA numbers assigned 829558: 828559: 827470. May be others……but I thought my contacting NHTSA was reporting issue as well. Any additional information needed, will provide. Contacted local dealer Sept 29, as well as Hyundai Consumer Affair (hmausa) to advise my intentions. Have contacted Consumer Affairs several times, assigned case number, Sept 1. but no resolution of issue. Have previously, via email, forwarded documentation to NHTSA. First date taken for “look at” was May 25,2023. Actually unsure of first occurrence date. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Lose of power, twice, one was around July early August, driving from my home doing about 30 mph I lost power, and the word limit showed on my dash, thinking I may have done something wrong myself I didn't think much of it until last Wednesday 09/27/23 it happened again, after leaving my destination I was driving home went around a corner and was up to about 35 mph and my truck lost power, which was completely nerve wrecking I had to pull over quickly and the word limit showed up again, I restarted the vehicle and drove off, and called a hyandai dealership and made an appointment which is for today Monday 10/02/23

Warning lights and chime for every ADAS system. Inoperative ADAS system. Driving down a two lane highway ALL of the safety systems warning came on in succession: Check cross traffic, lane keep, cross traffic, blind spot, forward safety, TPMS, etc. When this is happening the AC stops blowing cold and the controls are unresponsive. The warnings will occasionally pause and go back to normal, is quiet for a minute, the AC resumes working, then the dinging resumes and warnings flash. I stopped and restarted, all came back. I looked up where the sensors are and checked for obstructions, none. Disconnected, reconnected battery, it went away for a few miles then came back. No DTC's on app.

2022 Santa Cruz with 5850 miles ... lost power when accelerating on busy road (avoided accident) ... Transmission Control System malfunction warning ... notified by dealer transmission will need to be replaced

The contact owns a 2022 Hyundai Santa Cruz. The contact stated that while driving at various speeds, the Lane Departure feature malfunctioned, causing the vehicle to drive off the road on several occasions, and crossed double yellow lines with oncoming traffic ahead. The contact almost struck a pedestrian. In addition, the Forward Collision Avoidance system also malfunctioned several times causing the vehicle to abruptly stop while driving on the freeway with no other vehicles nearby. The vehicle was taken to the local dealer on several occasions and no cause for the failure was found. The sensors were updated but after retrieving the vehicle, the failure immediately reoccurred. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 10.

Twice, as I accelerated the transmission slipped out of gear as if it was shifted into Neutral. In both cases it finally shifted into gear and started to accelerate. In one case I was accelerating on to the Interstate. The Santa Cruz was taken to the dealer on Sept. 7th 2023 but they could not reproduce the problem and indicated there were no error codes. When the problem occurred I did not see a warning light on the dash.